2016 Chrysler 200 Electrical Problems

I am reporting multiple safety-related issues involving my 2016 Chrysler 200 S. On 02/06/2024, after an oil change at a dealership, the underbody skid plate bolts were not reinstalled. While driving, the skid plate fell and I lost control of the vehicle, creating a serious safety hazard. No warning indicators were present prior to this failure. The issue was identified immediately after leaving the dealership and is not properly documented in service records. In July 2022, following a battery replacement by the same dealership, the vehicle repeatedly lost power and stalled, leaving me stranded multiple times. I paid for diagnostic testing, but there is no documentation confirming proper diagnosis or repair. I was later advised incorrect hardware had been installed. On 02/27/2026, I was told the check engine light was on and diagnostic codes were cleared without repair. There is no documentation of the codes or repairs performed. I was also informed on 11/19/2022 that parts were ordered for a safety recall. From that date until 02/27/2026, I was repeatedly told parts were unavailable. I scheduled repair and dropped off the vehicle on 03/13/2026. I received notice that repair had begun, but later discovered the vehicle had not been serviced at all. No explanation was provided. Additionally, service records are inaccurate. A vehicle history report shows service on 03/17/2026 at a dealership I have never visited. The vehicle was not serviced anywhere on that date. These issues involve loss of control, repeated stalling, improper repairs, failure to complete a recall, and inaccurate reporting. Documentation is incomplete or missing. Supporting documents are available.

NHTSA ID

11728090

Incident

Feb 6, 2026

While driving, my 2016 Chrysler 200 (3.6L V6) experienced a sudden and complete electrical failure. All systems shut down simultaneously, including the dashboard, engine, power steering assist, and electrical accessories. The vehicle coasted to a stop and would not restart—no crank, no dash lights, no response. After allowing the vehicle to cool for approximately 30–45 minutes, electrical power returned and the vehicle restarted normally. This failure mode is identical to the Power Distribution Center (PDC) connector defect that resulted in a recall for the 2015 Chrysler 200. My vehicle is the same platform with the same component architecture, yet no recall exists for the 2016 model year. This is a serious safety defect that creates a risk of crash, loss of steering assist, and loss of vehicle control while driving.

NHTSA ID

11707905

Incident

Dec 29, 2025

UNKNOWN- I was driving and it was storming bad, I accidentally drove through this road that was flooded and my car then said throttle control and my car started to not drive as well then when I took a turn my car stopped and it would not move. I turned it off and it started going again, then when I was going up a hill while I trying to turn my car would not move, the vehicle stability indicator turned out and so many more signs, so then I tried to turn my car off again and it was stuck in drive and would not turn off, I wasn’t able to move the gears it was locked on drive but not moving so I had to disconnect my battery and then it started moving again, not safely but I made it home. Please what do I do

NHTSA ID

11669201

Incident

Jun 24, 2025

Vehicle has 46,000 miles on odometer. A year ago the "Service Airbag System" light would intermittently illuminate. It is now staying lit all the time. I was speaking with an acquaintance as they had the same vehicle. Theirs caught on fire under the seat in the electrical connection box for the airbag. I took it to a few of our local mechanics and they say it is a substantial safety issue as they pulled the codes B0028-13 and B0020-13. Right side and left side seat deployment squib circuit open. The airbags will not deploy upon impact. The consensus from the mechanics was that Chrysler has known this is a common problem in these vehicles and needs to address the repair. After calling Chrysler and finding out they do know this is a problem in design it will still cost $4000.00 to repair as it's not covered under warranty. This vehicle is unsafe and it makes me wonder how many people are driving these vehicles not knowing the potential danger. It will be going to the dealership when one of them can "fit me in".

NHTSA ID

11665035

Incident

Jun 2, 2025

The contact owns a 2016 Chrysler 200. The contact stated while driving approximately 35 MPH, the instrument cluster flickered, and the vehicle stalled. The contact was able to restart the vehicle. The contact stated that the failure was intermittent and occurred at various speeds. The contact had taken the vehicle to an independent mechanic who was unable to duplicate the failure. The vehicle was not repaired. The failure reoccurred and the vehicle was no longer drivable. The contact had not taken the vehicle to a dealer or an independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 15V470000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was approximately 90,000.

NHTSA ID

11657598

Incident

Feb 25, 2025

Mileage

90,000 mi

I took my car to Carman Dodge Chrylser Dealer located 196 s Dupont hwy , new castle de, 19720. My car was scheduled for a recall repair u90 and power train software update. I took my car in 4-10-25 and it stayed overnight until 4-11-25. When receiving my car I was presented with new issues that caused a no bus code and radio died. My car had no internal issues prior to taking my car to the dealer for recall repairs. I have all the documentation and employees names for the service department. I was told by my advisor Lance Grey and supervisor Joseph Troboletti that there is nothing else they can do. Other than these new problems that occurred just so happened to be coincidental. And in order to get things replace I would have to wait until July and I may be eligible for a small discount on the parts. So that means I would have to wait 3 months to get repairs and drive a car with my children with no working windows , radio and etc.

NHTSA ID

11654686

Incident

Apr 11, 2025

The transmission jumped into neutral while going 65mph also indicating “service park brake” and “service transmission”. The vehicle slowing down almost caused another vehicle to rear end me as I was looking for a safe place to try and pull over. No one has inspected properly these vehicles despite numerous customer complaints of the same nature. The car had no lights on but afterwards the power train light came on.

NHTSA ID

11638984

Incident

Jan 28, 2025

Unknown

NHTSA ID

11632171

Incident

Dec 23, 2024

My vehicle Chrysler 200 2016 has several car mechanical issues. The shifting gears. Rough shifting while driving.The affected vehicle would lurch through gears, and it would sometimes shut down or automatically shift to neutral. Grinding or a crunching sound. Clutch slips or doesn't “feel right” Burning smell or high engine revs. Car started rough, shifting and having transmission problems a year after we had it. Airbag sensor won’t turn off.

NHTSA ID

11589499

Incident

Mar 15, 2023

I believe the brake or something related to the brakes failed. I ran a stop sign, with no evidence of brake marks on the road. I crossed over a highway hit a side walk almost hit a house. The safety of myself and others was at extreme danger. When finally came to a stop I couldn't put my car in Park, or back in drive or shut my car off, i beleive i had no braking or something electrical failed. My car is totaled. The only light on was the airbag light before the accident.

NHTSA ID

11544434

Incident

Sep 7, 2023

Throttle- My car just shut off and won't turn back on I had a computer update last week and then a week later i shut the car off like normal and tried to turn it back on and it wouldn't do nothing. The Dealership did a pcm update of service bulletin 18-020-17 on 6-1-23. I had drove for 2.5hrs without any warning lights or anything suggesting a problem.

NHTSA ID

11526160

Incident

Jun 8, 2023

While backing up in my parking space, my car completly shut off. The steering was locked and the car would not start back up. I had to disconnect the battery to get it to restart

NHTSA ID

11520874

Incident

May 8, 2023

Car shuts off while idle

NHTSA ID

11506150

Incident

Feb 8, 2023

Electrical system under the seats smoked and went out for the air bags. Cost me $2,200 dollars out of pocket. I am on Social Security. Can't afford such dept. Brakes are sluggish and can't be trusted to stop quickly. Power Train ,Electrical System,Engine not safe. Electrical system, Service Brakes, Forward Collision Avoidance System needs to be looked at and replace if needed.

NHTSA ID

11486474

Incident

Sep 22, 2022

My car stalls when cranking and has shut down before while on the interstate. I think it’s an electrical problem no signs on the dashboard and saying key fob not detected

NHTSA ID

11481688

Incident

Aug 29, 2022

Car is stalling for unknown reason without any warning or light appearing on dash. Feeling unsafe especially when driving on the highway because I never know when it will happen. Has been happening every day for the past 3 days. Happened in the beginning after a couple months of having the car and the first time I took it in, they couldn't find anything wrong or replicate the problem.

NHTSA ID

11467216

Incident

May 31, 2022

Wire connector under the passenger seat disables the airbag and turns on the SRS light with the code B0028-13 Right side Airbag circuit open. I have noticed that FCA is aware of the problem as the fix is to replace the wire Connectors under the seat. As an alignment mechanic I am in and out of a lot of vehicles and just about all of the 2015 to 2017 Chrysler 200s I have worked on have this code, some also have B0020-13 which is the left side seat air bag circuit open.

NHTSA ID

11465341

Incident

Oct 16, 2020

Driving and the car just completely shuts off and/or malfunctions. It’s been when I’m slowing down to make a turn. The computer system/car shuts off and it’s impossible to get it turned back on for 1-4 minutes. Very dangerous and almost gotten into an accident twice now.

NHTSA ID

11459961

Incident

Apr 6, 2022

About 2 weeks ago , my car began malfunctioning and randomly shutting off while driving. The car gives no indication that there is an issue before hand which is dangerous. It has happened to me while entering the freeway and while on regular streets. In addition, when this happens, my gearshift somehow gets stuck which makes me unable to move the car. Sometimes I cannot turn the car off, it would get stuck running. The shift would malfunction illuminating other shifts even though it is stuck. This issue has happened to me again in the wee hours of this morning at 3am on a dark road. I feared for me life… I see that this is an ongoing issue in many complaints that I see but there has been no resolve from the manufacturer. Please help.

NHTSA ID

11448458

Incident

Jan 21, 2022

Airbag light has came on with dealership replacing the wiring harness under the seat twice. The light is now on for a third time. After online forum research, I learned that wiggling the wiring connections can get the connection back and airbag light to go away. It worked. Numerous complaints of loose wiring. Purchased the vehicle brand new currently with 125k miles. First repair was free. Second was out of warranty and I had to pay for parts.

NHTSA ID

11444905

Incident

Dec 17, 2021

The Chrysler 200's engine keeps suddenly shutting off while driving, mainly while making turns on streets and freeway on/off ramps. There are no warning lights, sounds, or visual cues to indicate any sort of problem. Sometimes the vehicle may just stall, most other times it just turns off and asks that I switch the shifter to park to then turn the vehicle back on. This issue is very concerning as it’s dangerous for the vehicle to shut down in traffic and could prove fatal.

NHTSA ID

11442664

Incident

Dec 3, 2021

The contact owns a 2016 Chrysler 200. The contact stated that while depressing the brake pedal to start the vehicle, the pedal was hard to depress. Additionally, while driving the vehicle would suddenly stall without warning. The failure had occurred on multiple occasions. The cause of the failure was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 73,000.

NHTSA ID

11441709

Incident

Nov 1, 2021

Mileage

73,000 mi

The airbag light comes on constantly, it puts MYSELF or anyone who is in my car at risk. It says to check the airbag and the wiring under the seat is the problem. It's loose. I constantly have to wiggle it for it to go away and a dealership wants to charge 300 dollars for a diagnosis and repair. If I crash, I feel as if the airbag will not deploy and it seems a lot of people online have the same issue when googling the problems.

NHTSA ID

11428994

Incident

Jun 1, 2021

My car gave me a service airbag message when I started it on July 31st. I already had an appointment scheduled with a Chrysler dealer to resolve an unrelated recall issue, so I asked them to look into what was causing the airbag issue, as well. They told me that the jumper wiring needed to be replaced on both sides of the vehicle in order to resolve diagnostic code B0020-13. They quoted me over $2,800.00 to fix the issue and told me that my airbags would not go off if I were to get in an accident unless the repairs were made. I am unable to afford this, so I contacted FHA customer service to seek cost assistance, but was told my car is too far out of warranty. My car only has 78,000 miles, so I should not have any safety issues with it. I was told by the technician that this is a common problem with my vehicle. Seeing as this is a safety issue and it is a common issue, I believe it is worth investigating to determine if it is caused by a manufacturing defect. I, like most people, cannot afford this costly of a repair, so I am putting my life at risk each time I drive my car, which I now know will not deploy the safety bags if I get in an accident. To make matters worse, I had to pay a $150.00 diagnostics fee just to find this out.

NHTSA ID

11427801

Incident

Jul 31, 2021

3 ongoing problems. 1. Our car dies while driving. This is Dangerous. Tonight is the 3rd (maybe 4th) time in about a year or year and a half or so. The first two times modesto jeep dodge chrysler determined it was too low on oil (but the mileage was much less than when oil change was due according to my oil change sticker. Also very dangerous because there is never an oil light that comes on the dashboard to warn oil low. About 3 months ago it died 500 miles before oil change supposed to be due. Tonight it died again with no warning. Oil change is not supposed to be due for another 1000 miles. Very scary. No warning light. 2. After I'm stopped at a stop sign or light then during acceleration car jerks. 3. I've had this car about 3 years. The airbag light came on shortly after I owned the car. Never been in an accident in this car.

NHTSA ID

11418192

Incident

May 22, 2021