2005 Chrysler 300C Engine Problems

When the fuel tank is topped off the vehicle stalls 2-6 times until the excess fuel is burned off. This has happened on the road, in parking lots, intersections, etc. It causes total loss of power & power steering. Additionally, I usually have to shift to Park, Neutral, Reverse, Drive, Reverse, and then drive again in order to get the transmission to lock back in forward gearing. Causing me to have to additionally pull over, or stop, when/wherever the incident occurs.

NHTSA ID

11476176

Incident

Jul 24, 2022

EVERY TIME I FILL MY GAS TANK UP THE CAR OIL LIGHT COMES ON AND IT STALLS. SOMETIMES IT DOES THIS 2 OR 3 TIMES THEN IT RUNS OK UNTIL ITS TIME TO FILL CAR UP AGAIN, THEN THE SAME THING HAPPENS.

NHTSA ID

11396233

Incident

Feb 15, 2021

Mileage

120,000 mi

THE MAIN GROUNDING WIRE PASSENGER-SIDE ENGINE BLOCK CONTACT POINT HAD CORROSION(RUST) LIMITING ELECTRICAL CURRENT FLOW TO THE WIRING HARNESS. THIS CAUSED TOO MUCH CURRENT TO FLOW TO 2 SMALLER 16 GAUGE GROUNDING WIRES ATTACHED TO THE REAR OF EACH HEMI CYLINDER HEAD TO FRY. THIS DIRECTLY AFFECTS THE CCN BUS COMMUNICATIONS TO THE CPU. ANY DEVICE, MODULE, OR SENSOR ATTACHED TO THE CCN BUS CAN HAVE INTERMITTENT BEHAVIOR. EXAMPLES OF VERY BAD BEHAVIOR IN MY CAR: 1. THE ALARM RANDOMLY GOING OFF WHILE PARKED OR WHEN DRIVING THE CAR. 2. WHILE PARKED AND THE ALARM SET THE SUNROOF DECIDED TO OPEN UP DURING A RAINSTORM FILLING MY CAR WITH 3 INCHES OF RAIN. 3. THE 300C DOESN'T USE A THROTTLE CABLE. IT UTILIZES A THROTTLE POSITION SENSOR THAT COMMUNICATES WITH THE CPU OVER THE CCN BUS. JUST TOUCHING THE GAS PEDAL WAS THE SAME AS PRESSING THE GAS PEDAL TO THE FLOOR. IT'S A GOOD THING THAT WHEN THIS HAPPENED TO ME THERE WAS NO TRAFFIC ON THE ROAD AND I WAS CLOSE TO HOME. SINCE THIS IS CCN 2-WIRE TWISTED PAIR BUS COMMUNICATION ISSUE ANYTHING THAT COMMUNICATES WITH THE CPU CAN HAVE A RANDOM INTERMITTENT PROBLEM. SINCE THESE CARS ARE GETTING OLDER I HAVE TO THINK THAT THERE ARE OTHER CARS THAT ARE OR WILL HAVE SIMILAR ISSUES. PRAY TO GOD THAT YOUR THROTTLE DOESN'T STICK WIDE OPEN LIKE MINE DID. I HAD TO KEEP MY FOOT BURIED ON THE BRAKE WHILE I WAS SCREAMING DOWN THE ROAD UNTIL I WAS ABLE TO TURN OFF THE IGNITION. HAVE FUN COMING TO A STOP OR DRIVING HOME AFTER THAT HAPPENS. FORMALLY I WAS AN I2C BUS COMMUNICATIONS(2 WIRE BUS) EXPERT AT BOTH INTEL CORP AND CISCO SYSTEMS. I KNOW WHAT I AM TALKING ABOUT. TODAY I TALKED WITH A BREMERTON CHRYSLER/DODGE/JEEP TECHNICAL SERVICE REPRESENTATIVE ABOUT THIS ISSUE. BOTTOM-LINE OVER $3000 TO FIX. THERE MAY HAVE BEEN SOMEBODY SOMEWHERE THAT IS DEAD BECAUSE OF THIS FACTORY DEFECT AND NO ONE IS THE WISER. WHY NOT A FACTORY RECALL ISSUE?

NHTSA ID

11361862

Incident

Oct 14, 2018

Mileage

120,000 mi

WHENEVER I DO A QUICK ACCELERATION, MY CHECK ENGINE LIGHT COMES ON AND THE CAR TEMPORARILY LOSE POWER. WHEN THE CAR LOSE POWER, I CANNOT CONTROL IT, WHICH IS VERY DANGEROUS. WHEN THE CHECK ENGINE LIGHT COMES ON NO CODES ARE STORED. ALSO, I HAVE EXPERIENCE THIS PROBLEM WHILE SITTING AT A RED LIGHT. FOR THE MOST PART, THIS PROBLEM MOSTLY OCCUR DURING ACCELERATION. I HAVE HAD THE SPARK PLUGS REPLACED AND THROTTLE BODY CLEANED BUT THE PROBLEM PRESIST. FROM MY RESEARCH, THIS PROBLEM APPEARS TO BE REGULAR THROUGHOUT THE CHRYSLER/DODGE FAMILY. THIS PROBLEM NEEDS TO BE RECTIFIED BEFORE SOMEONE LOSE THEIR LIFE IN AN UNNECESSARY ACCIDENT.

NHTSA ID

11350571

Incident

Jan 6, 2020

Mileage

243,400 mi

I WAS GOING TO CHECK THE OIL LEVEL WHEN THE TOP OF THE DIPSTICK CAME OFF IN MY HAND. IT IS MADE OF PLASTIC.; I WAS OPENING THE DRIVERS DOOR, THE HANDLE CAME HALFWAY OFF, SUBSEQUENTLY ALL HANDLES HAVE DONE THE SAME THING. THE WASHER FLUID DOES NOT SPRAY. THESE PROBLEMS ALL HAPPENED IN THE PAST 3 OR 4 YEARS. THE VEHICLE WAS STATIONARY FOR THESE PROBLEMS. WHILE TURNING, THE STEERING WHEEL WOULD NOT CONTINUE TOO TURN, HEARD A " THUNK", FINALLY TURNED BUT THE TURN SIGNAL MECHANISM DOES NOT WORK NOW.

NHTSA ID

11299494

Incident

Oct 10, 2017

Mileage

79,000 mi

TL* THE CONTACT OWNS A 2005 CHRYSLER 300C. WHILE DRIVING 45 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO TWO INDEPENDENT MECHANICS, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. FAILURE CODES APPEARED AFTER THE VEHICLE WAS RETRIEVED. LITHIA CHRYSLER DODGE JEEP RAM FIAT OF SANTA FE (4470 CERRILLOS RD, SANTA FE, NM 87507, (505) 629-0746) STATED THAT THERE APPEARED TO BE AN ELECTRICAL FAILURE AND WERE CHECKING ALL THE WIRING ON THE HARNESS WITH MULTIPLE CODES APPEARING. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 81,000. THE VIN WAS UNKNOWN.

NHTSA ID

11219063

Incident

Dec 1, 2018

Mileage

81,000 mi

A COUPLE MONTHS BACK THE ENGINE SHUT DOWN GOING DOWN THE ROAD, COMPUTER CHECKED SHOWING THE HEAT SENSOR WENT BAD ,HAD IT REPLACED AND ALSO INSTALLED A NEW THERMOSTAT JUST IN CASE. YESTERDAY 12/6 2018 TOOK THE CAR OUT AND WENT TO THE OUTLETS ROUGHLY 25 MILES AWAY CAR RAN GREAT . STOP FOR GAS ON THE WAY BACK A MILE FROM HOME, LEFT THE STATION WENT A 1/4 MILE THE CAR SHUT DOWN AGAIN,STARTED RIGHT BACK UP WENT ANOTHER 1/2 MILE AND IT SHUT DOWN AGAIN, STARTED RIGHT BACK UP AND WENT 1/4 MILE TO THE HOUSE. HAD MY SON IN LAW WHO IS A MECHANIC DO A COMPUTER CHECK AND NOTHING SHOWS UP. CAR HAS 38777 MILES ON IT AND GARAGE KEPT, LITTLE DANGEROUS SINCE U LOOSE THE STEERING AND BRAKES WHEN IT SHUTS DOWN, FORTUNATELY FOR ME I HAD A PLACE TO PULL OVER TO GET OFF THE HIGHWAY. CHECKING WITH THE DEALERSHIP TOMORROW TO SEE IF OTHERS HAD THIS PROBLEM. HAD A VERY SIMILAR PROBLEM WITH MY CHRYLER CROSSFIRE YEARS BACK WHERE THE CAR WOULD NOT ACCELERATE HAD SOME CLOSE CALLS AT STOP SIGNS HAD TO REPLACE THE COMPLETE ACCELERATION UNITE HAD LESS THAN 4000 MILES ON THE CAR BUT THE CAR WAS OUT OF WARRANTY COST ME OVER $300 BUT THE ENGINE DIDN'T SHUT DOWN LIKE THIS ONE.WAS ON A TOWN STREET WHEN IT SHUT OFF

NHTSA ID

11164139

Incident

Dec 28, 2018

Mileage

38,776 mi

MY CAR STALLS WHILE DRIVING PERIODICALLY STALLS WHEN THE CAR IS AT IDLE. IT EVEN STALLLS GOING DOWN THE HIGHWAY AT SPEEDS 65. WE HAVE CHANGED EVERYTHING POSSIBLE EXCEPT THE ENGINE. THE CAR STARTS RIGHT UP AFTER STALL BUT WILL STALL IN TRAFFIC. I HAVE LOOKED AT MANY FORUMS AND THEY ALL SAY THE SAME THING NUMEROUS COMPLAINTS OF CAR SHUTTING OFF WHILE DRIVING. I HAVE CHECKED ALL RECALLS. THIS IS A MAJOR SAFETY CONCERN. THIS HAPPENS EVERYDAY.

NHTSA ID

11111380

Incident

Jul 1, 2018

Mileage

94,995 mi

MY CHRYSLER 300C HAS 114,805 MILES ON IT. I DROVE IT TO THE GAS STATION BEFORE GOING HOME. FILLED IT UP WITH GAS. WENT TO START IT UP AND IT WOULDN'T. I HAD TO HAVE IT TOWED TO THE SHOP. THE OUTSIDE TEMPERATURE LAST NIGHT WAS 63. THE ENGINE TEMPERATURE WAS NORMAL. THERE WERE NO WARNING SIGNS. THE CAR DROVE FINE ALL THE WAY FROM MY OFFICE TO THE GAS STATION WHICH IS 33 MILES. MECHANIC SAYS THE VALVE SEAT HAS DROPPED AND THE ENGINE IS COMPLETELY RUINED NOW. I NOW HAVE TO PAY ALMOST $7,000 TO GET MY CAR DRIVEABLE AGAIN.

NHTSA ID

11081606

Incident

Mar 26, 2018

Mileage

114,805 mi

OIL LIGHT CAME ON AT SLOW SPEED AND ENGINE SHUT OFF BY IT SELF, ON A CITY STREET. WHY?

NHTSA ID

11043197

Incident

Nov 2, 2017

Mileage

46,000 mi

THE CYLINDER VALVE SEAT FELL OFF THE CYLINDER HEAD, THEN FELL DOWN INTO THE PISTON CAUSING DAMAGE TO THE VALVES AND PISTON THUS THE ONLY REPAIR POSSIBLE IS TO REPLACE THE ENGINE. NOT SURE WHEN THIS HAPPENED BECAUSE THERE WERE NO WARNING SIGNS.

NHTSA ID

11033867

Incident

Oct 4, 2017

THIS CAR WILL STALL AT COMPLETELY RANDOM INTERVALS. IT HAS DONE IT AT SPEED, ON ACCELERATION, ON DECELERATION, AT STOPS. OCCASIONALLY THE CRUISE CONTROL WILL NOT FUNCTION CORRECTLY. THE CAR WILL ALSO SPIT, SPUTTER AND BUCK AT SPEEDS ABOVE 35MPH. WHEN THIS HAPPENS, THERE IS A TOTAL LOSS OF POWER STEERING, BRAKES, ETC. IN ORDER TO RESTART THE CAR, IT REQUIRES BEING PLACED INTO NEUTRAL OR PARK, AND TRYING AT LEAST 3 TIMES BEFORE ENGINE WILL RUN AGAIN. THE CAR WILL USUALLY CONTINUE TO STALL 3-10 TIMES. ON RETURNING TO "DRIVE" THE CAR WILL USUALLY STAY STATIONARY FOR ANOTHER 5-10 SECONDS BEFORE SURGING FORWARD. REVERSE DOES NOT HAVE THIS EFFECT. CAR HAS BEEN CHECKED BY SEVERAL MECHANICS, WHO CAN PULL NO CODES, AND DON'T SEEM TO HAVE ANY CLUE WHAT IS CAUSING THE INTERMITTENT ISSUE. IT IS VERY DANGEROUS SITUATION, AS THERE IS NO WARNING THE CAR IS ABOUT TO STALL, AND THERE IS NO PATTERN TO WHEN IT WILL STALL. IN GOOGLING THE ISSUE, I WAS ABLE TO FIND THE CHRYSLER CAMPAIGN X53 EXTENDED WARRANTY ON "SOME" 2006 300CS, BUT WHEN I CALLED THE CHRYSLER DEALER TO CHECK MY VIN, I WAS TOLD MY CAR IS NOT COVERED UNDER THIS KNOWN DEFECTIVE GAS TANK. THE MESSAGE BOARDS HAVE MANY INSTANCES OF PEOPLE DESCRIBING THIS EXACT ISSUE FOR THIS EXACT CAR. THIS A SERIOUSLY LIFE THREATENING ISSUE.

NHTSA ID

11024821

Incident

Sep 10, 2017

Mileage

150,000 mi

WHENEVER I FILL UP AT THE GAS STATION ABOUT 2-3 MINUTES LATER WHILE I'M DRIVING THE ENTIRE DASH BOARD WILL LIGHT UP AND THE CAR WILL CUT COMPLETELY OFF. I HAVE TO PUT IN IN PARK AND TRY TO RESTART IT ABOUT 5 TIMES, EACH TIME THE OIL LIGHT COMES ON AND IT JUST STALLS, ONCE IT DOES CATCH THE SPEED FLUCTUATES UP AND DOWN BUT ABOUT 5 MINUTES LATER IT HAPPENS ALL OVER AGAIN. I KNOW IT HAS NOTHING TO DO WITH THE OIL BECAUSE I HAD GOTTEN AN OIL CHANGE BEFORE I PUT THE GAS IN THE CAR. THIS HAD HAPPENED A COUPLE OF YEARS AGO SO I HAD JUST STOPPED FILLING THE CAR UP AND THIS TIME I FORGOT. THE CAR CUTS OFF WHILE IN MOTION, YOU CAN'T TURN THE STEERING WHEEL, IT JUST STOPS WHERE EVER YOU ARE, ALL I COULD DO WAS CUT ON THE HAZARDS AND KEEP TRYING TO RESTART IT, IT SOUNDS LIKE YOU ARE TRYING TO RESTART WHILE IT'S ALREADY ON, IT MAKES A SCREECHING SOUND, AND SOUNDS LIKE IT'S TRYING TO CATCH.

NHTSA ID

11002640

Incident

Jul 1, 2017

Mileage

182,000 mi

NORMAL DAY DRIVING MY VEHICLE. DROVE APPROXIMATELY 24 MILES TO A SHOPPING CENTER IN THE CITY. TURNED THE IGNITION CAR STARTED AS EXPECTED. CAR THEN DIED UNEXPECTEDLY. ATTEMPTED TO GET IT STARTED TO NO AVAIL. CALLED A TOW TRUCK AND HAD THE VEHICLE TAKEN TO A TRUSTED ASE CERTIFIED MECHANIC A COUPLE MILES AWAY. GET A CALL LATER STATING THE ENGINE IS DAMAGED! MECHANIC STATED THAT THESE CARS ARE WELL KNOWN FOR DROPPING VALVES. I PROCEED TO ASK WHAT'S THE DAMAGE? THESE WORDS I WOULD LEARN TO REGRET... I WAS GIVEN A QUOTE OF $4000-$7000 DEPENDING ON HOW MANY PARTS WERE AFFECTED BY THIS ONE FAILED PIECE. THOUSANDS OF PEOPLE IN FORUMS ARE HAVING THIS ISSUE ALSO. HOW IS IT A COMPANY DOESN'T ACKNOWLEDGE A MAJOR PROBLEM LIKE THIS AND GET AWAY WITH IT? I WAS FORCED TO GET A $6000 LOAN TO FIX A CAR WITH 101K... YEA 1,000 MILES OVER WARRANTY! CHRYSLER NEEDS TO OWN UP TO THIS PROBLEM. *TR

NHTSA ID

10948418

Incident

Oct 22, 2015

Mileage

101,000 mi

TAKATA RECALL , SO I TAKE CARE OF MY CHRYSLER 300C 5.7 VERY WELL I ALWAYS CHECK THE FLUIDS ON THE COOLENT AND OIL AND CHANGE MY OIL WHEN ITS NEEDED. I WAS RUNNING OUT OF GAS ON THE FREEWAY BARELY MAKING IT TO THE GAS STATION AND I FILLED UP MY GAS TANK, WHEN I TRIED TO STARTING MY CAR IT DIDNT START. MY CAR JUST HESITATED AND I THOUGHT MY BATTERY WAS GOING OUT BUT IT WAS A BRAND NEW ONE AND MY FUEL PUMP WAS CHANGED A FEW MONTHS PRIOR. ALSO I TOOK MY CAR TO GET SERVICED A WEEK PRIOR TOO AT MY LOCAL PEPBOYS AND CHANGED THE OIL PRESSURE SENSOR AT LEAST THATS WHAT THEY TOLD ME WHAT IT WAS. SO MY CAR STARTED IN THE GAS STATION PARKINGLOT AND WHITE SMOKE CAME OUT OF MY EXHAUST AND MY CAR JUST TURNED OFF ON ME. MY CAR IS SITTING NOW COLLECTING DUST BECAUSE IT DROPPED A VALVE DUE TO THE 2005 5.7 HEMI DESIGN. I BELIEVE DODGE AND CHRYSLER KNOW ABOUT THIS MALFUNCTION THATS BOND TO HAPPEN WHETHER YOU TAKE CARE OF YOUR ENGINE OR NOT. I DESERVE TO HAVE A RECALL ON MY CAR , IM ALMOST DONE PAYING IT OFF AND ITS NOT MY FAULT THIS HAPPENED TO ME.

NHTSA ID

10937317

Incident

Apr 1, 2016

Mileage

154,527 mi

DROPPED INTAKE VALVE SEATS ON THIS HEMI ENGINE. BASED ON MY RESEARCH, THIS IS A KNOWN PROBLEM ON THE HEMI ENGINES FROM THIS TIME PERIOD. STOPPED AT THE STORE FOR 20 MINUTES, CAME OUT AND TRIED TO START THE ENGINE AND ALL I HEARD WAS METAL ON METAL AS THE ENGINE TRIED TO TURN OVER. ENGINE NEEDS TO BE REBUILT OR NEED TO BUY ANOTHER REBUILT ENGINE.

NHTSA ID

10905957

Incident

Sep 7, 2016

Mileage

185,000 mi

CAR DIES AFTER FUELING. IT WILL SPUTTER THEN DIE, IT WILL ALSO DIE WHILE COMING TO A STOP. AFTER REFUELING IT SPUTTERS AND DIES AT GAS STATION BUT IT CAN HAPPEN WITHIN THE NEXT COUPLE OF MILES. IT WILL DIE WHILE PULLING OUT IN TRAFFIC AND EXTREMELY DANGEROUS. READING ON LINE THIS IS A COMMON PROBLEM AND NO ONE CAN FIGURE IT OUT. IT ALSO WILL NOT ALWAYS GO BACK INTO GEAR AFTER IT DIES.

NHTSA ID

10873084

Incident

Sep 2, 2015

Mileage

150,000 mi

CAR STALLS WITH NO WARNING OR ENGINE LIGHTS/CODES. WHILE DRIVING(VERY DANGEROUS!!)

NHTSA ID

10852566

Incident

Mar 29, 2016

Mileage

90,000 mi

DRIVING DOWN THE ROAD IT DIES IN TRAFFIC AND THE STEERING WHEEL GETS STIFF AND DOESNT LET U TURN IT SHUT IT OFF IT STARTS RIGHT BACK UP NOTHINGS WRONG WITH IT THIS IS A SERIOUS DEAL DRIVING IN TRAFFIC ALSO LIGHTS DIM CHANGED BATTERY IT HELPS BUT EVENTUALLY GOES BACK TO DOING AND AS YOUR DRIVING DOWN ROAD THE CAR ACTS LIKE IT DOESNT WANNA GO THEN IT ACCELERATES ON ITS OWN I JUST WANT MY CAR FIXED I LOVE THIS CAR EVERYWERE IVE SEARCHED AND TAKEN TO THEY SAY ITS THE TPIM

NHTSA ID

10839978

Incident

Sep 30, 2013

Mileage

120,000 mi

EVERY TIME I COMPLETELY FILL MY TANK MY CAR WILL OCCASIONALLY STALL AT TRAFFIC LIGHTS OR DRIVING. AFTER A FEW TIMES RESTARTING THE ENGINE IT WILL BE FINE UNTIL I FILL THE TANK AGAIN. IT SEEMS TO HAPPEN MOSTLY WHEN THE TANK GOES BELOW 1 QUARTER OF THE TANK. I HAVE SEEN COMPLAINTS BEFORE FROM OTHER MAKES ABOUT A FUEL FLOAT VALVE IN THE TANK THAT CAN SEND A SIGNAL TO YOUR COMPUTER THAT THE TANK IS EMPTY AND SHUT THE ENGINE OFF. WHY IS THIS NOT A RECALL FOR THIS MODEL? THERE IS DEFINITELY A DANGER IN TRAFFIC SITUATIONS.

NHTSA ID

10795295

Incident

Nov 3, 2015

Mileage

137,000 mi

WARNING DASH LIGHTS/SIGNALS (SERVICE ENGINE, OIL, ESP. SERVICE BREAK ASSIST SYSTEM , SPEEDOMETER FLUXUATED ETC) ENGINE STALLED. I COULD HAVE EASILY BEEN REAR ENDED HAD THERE BEEN OTHER VEHICLES BEHIND ME. THIS HAPPENED A COUPLE MORE TIMES SINCE THAT DATE. ON 7/22/15 TOOK VEHICLE TO CHRYSLER DEALERSHIP , NEWARD DE. FOR THEM TO CHECK AND FIX. ON 7/31/15 DEALERSHIP CALLED ME STATED PROBLEM WAS FIXED THEY HAD REPLACED PTS MODULE AND SHIFTER. I DIDN'T EVEN GET IT OFF THE LOT, STARTED VEHICLE UP AND ABOVE MENTIONED LIGHTS CAME ON AGAIN. THE MECHANIC (DROVE) AND I WENT FOR A TEST DRIVE. SERVICE ENGINE AND OTHER DASH WARNING LIGHTS CAME ON. MECHANIC TOOK CAR BACK TO SHOP STATED HE RESET SOME CODES AND VEHICLE WAS FIXED. I WAS CHARGED $868.00 FOR SAID REPAIR AND OIL CHANGE. I DROVE VEHICLE OFF LOT.... ABOUT TWO MINUTES INTO DRIVING SAME PROBLEMS OCCURRED AND VEHILCE STALLED AGAIN. TOOK VEHICLE BACK TO DEALER.. STILL THERE. THEY STATE THEY ARE TRYING TO FIND THE PROBLEM.. WHILE CHECKING THE WEB I FOUND THAT MANY,,, MANY OF THESE CAR OWNERS HAVE REPORTED THIS SAME PROBLEM WHICH IS AN EXTREMELY DANGEROUS ISSUE AND YET NO RECALL.. I DON'T UNDERSTAND WHY. DO PEOPLE HAVE TO DIE FIRST BEFORE SOMETHING IS DONE ABOUT THIS. PLEASE TAKE SOME ACTION ON THIS.

NHTSA ID

10745985

Incident

Jun 28, 2015

Mileage

42,700 mi

TL* THE CONTACT OWNS A 2005 CHRYSLER 300C. WHILE DRIVING AT APPROXIMATELY 45 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR PASSENGER SIDE WHEEL OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000.

NHTSA ID

10735520

Incident

Feb 15, 2015

Mileage

73,000 mi

I WAS DRIVING HOME FROM WORK IN A RESIDENTIAL AREA AROUND MY HOME GOING ABOUT 25-27MPH. I CAME TO A STOP AND MY CAR LITERALLY WENT UP IN WHITE SMOKE, LEAKED LARGE AMOUNTS OF OIL AND THAN THE CAR SHUT OFF, AT TIME I DIDN'T KNOW WHAT THE PROBLEM WAS AND HAVE BEEN TILL THIS DAY TAKING IT TO MANY REPAIR SHOPS TO HAVE WHAT THEY THOUGHT WAS WRONG FIXED UNTIL I FINALLY TOOK IT TO ENGINE SPECIALIST AND SAID ENGINE BLEW. I HAVE NOT HAD CAR MORE THAN 3 YEARS AND CHRYSLER DOESN'T WANT TO DO ANYTHING ABOUT AND REFUSE TO HELP. IT IS NOT FAIR TO US WHO PAY SO MUCH MONEY ON A CAR THAT CHRYSLER THEM SELF TOLD ME WAS A BIG ISSUE IN THE 2005 CHRYSLER 300C 5.7 V8 HEMI HAVING ENGINE FAILURE AND DON'T EVEN RECOMMEND PEOPLE TO BUY THIS PATICULAR MODEL OF CAR.. PLEASE HELP I DON'T KNOW WHAT TO DO AND THINK THESE ENGINES SHOULD BE RECALLED AND CHRYSLER SHOULD BE FORCED TO FIX THEM.

NHTSA ID

10732807

Incident

Apr 27, 2015

Mileage

147 mi

FILLED THE CAR WITH GAS AND THE CAR DIED WITHIN 5 MINUTES OF THE GAS STATION. RESTARTED THE CAR AND HAD THE SAME THING HAPPEN TWO MORE TIMES. THIS HAS SINCE HAPPENED AFTER EVER FILL UP SINCE. WE BOUGHT THIS VEHICLE MAY 1ST 2015. THE ISSUES WITH IT DYING STARTED HAPPENING THE VERY FIRST FILL UP. WE JUST FIGURED IT WAS A VAPOR LOCK BUT AFTER READING THE COMPLIANTS, OVIOUSLY NOT. THIS NEEDS TO BE RECALLED AS SOMEONE IS GOING TO HURT.

NHTSA ID

10715960

Incident

May 1, 2015

Mileage

79,856 mi

MY WIFE WAS TAKING OUR TWO KIDS TO SCHOOL WHEN THE CAR MADE A HORRIBLE NOISE WHEN FIRST TRYING TO START THE CAR EARLY IN THE MORNING. I HAD IT TOWED TO MY MECHANIC WHERE HE FOUND THAT THE CYLINDER VALVE SEAT FELL OFF THE CYLINDER HEAD AND FELL DOWN INTO THE PISTON CAUSING SEVERE DAMAGE TO THE VALVES AND PISTON. REPLACING THE ENGINE FOR $8000 WAS AN OPTION, HOWEVER YOU ARE REPLACING IT WITH THE SAME TYPE OF ENGINE THAT COULD POTENTIALLY REPLICATE THE PROBLEM AGAIN. AFTER RESEARCHING THIS SEEMS TO BE A MANUFACTURES DEFECT OF THIS ENGINE FOR 2005-2006 CHRYSLER 300 C. THIS HAPPENED 4 MONTHS AFTER MY WARRANTY EXPIRED. *TR

NHTSA ID

10714797

Incident

Apr 24, 2015

Mileage

116,342 mi