Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2008 Chrysler Aspen 4X2 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
TL* THE CONTACT OWNS A 2008 CHRYSLER ASPEN 4X2. ON SEVERAL OCCASIONS, WHILE FUELING THE TANK, A SIGNIFICANT AMOUNT OF FUEL WOULD SPEW OUT OF THE TANK. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 63,000.
TAKATA RECALL HAS NOT BEEN CHANGED AND IVE CALLED SEVERAL TIMES TO GET IT CHANGED. ALSO IM SMELLING GAS ON THE INSIDE OF MY TRUCK AND I HAVE A TWO WEEK OLD BABY.
AT TIME OF FILL UP, WHEN THE PUMP STOPS FULL SPEWS OUT OF THE FUEL FILLER NECK. IT HAS BEEN THIS WAY SINCE WE PURCHASED THE CAR AND WHEN I BROUGHT THIS TO THE SALES MANAGERS ATTENTION HE PLAYED IT OFF AS NO BIG DEAL. HE DID OFFER AN EXTENDED WARRANTY TO PURCHASE TO HAVE THE CAR "FIXED" SO IT WOULDN'T SPEW FUEL ON THE GROUND OR PERSON PUMPING GAS. I FIND IT HARD TO BELIEVE THIS HAS NOT BEEN ADDRESSED IN A RECALL.
ENGINE STALLS CONSISTENTLY WITH FULL TANK OF GAS. SAME PROBLEM OTHER CHRYSLERS HAVE WITH EVAPORATIVE EMISSIONS SYSTEM VALVE. *TR
GASOLINE DISCHARGED (APPROXIMATELY 1/4 GALLON) OUT OF FUEL FILLER AFTER GASOLINE FILLER NOZZLE SHUTS OFF AT FILL-UP WHEN TANK REACHES CAPACITY. THIS HAPPENS AT ALL GAS PUMPS, NOT A SPECIFIC STATION. MANY ATTENDANTS AT GAS STATIONS HAVE STATED THAT THIS IS A SAFETY CONCERN AS FUEL GETS ON THE GROUND AND ON THE PERSON FUELING. *TR
GASOLINE DISCHARGED OUT OF FUEL FILLER AFTER GASOLINE FILLER NOZZLE SHUTS OFF AT FILL-UP. GAS SPILL AT EACH FILL-UP IS SIGNIFICANT. *TR
WHEN FUELING AT ANY STATION FUEL BLOWS OUT THE TANK EVERYWHERE, ABOUT A HALF A GALLON. IT GETS ON THE PERSON FUELING AND THE GROUND, BUT ONLY WHEN FILLED UP UNTIL THE PUMP CUTS OFF. *KB
WHEN GAS IS PUMPED INTO THE VEHICLE WHEN IT IS FULL GAS SPILLS OUT OF THE TANK. MANY ATTENDANTS AT GAS STATIONS HAVE STATED THAT THIS IS A CONCERN WITH THE VEHICLE.
GAS SPILLS OUT OF TANK (APPROXIMATELY 1/4 GALLON) WHEN TANK REACHES CAPACITY. THIS HAPPENS AT ALL GAS PUMPS, NOT A SPECIFIC STATION. VARIED SPEED OF PUMP AND WEATHER CONDITIONS HAVE NOT CHANGED THIS ISSUE.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .