2006 Chrysler Pt Cruiser Fuel system Problems

FUEL ODOR IN PASSENGER COMPARTMENT INVESTIGATED AND FUEL LEAK IN THE ENGINE COMPARTMENT WAS FOUND. THE LEAK IS AT THE CONNECTION FROM THE FUEL TANK TO THE FUEL RAIL CONNECTION. THE CONNECTION IS ON THE VEHICLE RIGHT/PASSENGER SIDE AND AGAINST THE FIRE WALL. IF NO RECALL, AT LEAST ALL REGISTERED DRIVERS SHOULD BE NOTIFIED OF THE ISSUE. LEAK WAS DISCOVERED ON 1ST LOOK DUE TO GOOGLE SEARCH OF ISSUE. ISSUE IS NOTICED AT START UP AND DISAPPEARS (LEAK CONTINUES) WITH VEHICLE SPEED OR WITH AIR FLOW DILUTION. CUSTOMERS NEED TO FIX OR FACE THE POSSIBILITY OF A UNDER HOOD FIRE. THANKS.

NHTSA ID

11386711

Incident

Jan 5, 2021

Mileage

77,000 mi

QUICK CONNECT FITTING ON THE PLASTIC FUEL LINE AT FIREWALL LEAKS FUEL, WHICH IS A FIRE HAZARD. THE PLASTIC FUEL LINE FROM THERE TO THE ENGINE WAS REPLACED A YEAR AGO, BUT NOW IT LEAKS AGAIN. FROM WHAT I HEAR, THIS IS A VERY COMMON PROBLEM ON THESE CARS. THE O-RINGS CAN'T HANDLE THE CONSTANT ROTATIONAL MOTION BECAUSE OF THE ROCKING OF THE ENGINE BACK AND FORTH. CHRYSLER SHOULD ENGINEER A PROPER FIX.

NHTSA ID

11243208

Incident

Aug 4, 2019

Mileage

135,000 mi

JUST PURCHASED THIS CAR 3 DAYS AGO. THE MAIN FUEL LINE STARTED TO LEAK TODAY NEAR THE REAR ENGINE FIREWALL, WHERE THERE IS A CONNECTION TO SOME KIND OF VALVE. VERY VISIBLE FUEL LEAK AT THE CONNECTOR. THIS IS A FIRE HAZARD DUE TO THE FUEL LINE LEAK BEING DIRECTLY ABOVE THE EXHAUST. CHRYSLER WILL DO NOTHING ABOUT THIS ISSUE AND AS I HAVE SEEN ON MANY FORUMS REGARDING THIS VEHICLE TYPE AND THIS SAME ISSUE, THIS IS A VERY COMMON PROBLEM THAT THE DEALER SHOULD MAKE RIGHT WITH THESE VEHICLES HAVING A "POTENTIAL FIRE ISSUE " AND RECALL THIS VEHICLE FOR THE FUEL ISSUE AND MOST IMPORTANT, IT'S POTENTIAL TO DESTROY THE VEHICLE AND CONTENTS DUE TO A DEFECTIVE FUEL CONNECTOR BEFORE SOMEONE BURNS UP IN THIS VEHICLE. I PLEAD WITH YOU TO HAVE THIS VEHICLE RECALLED DUE TO IT'S FUEL LEAKING ISSUE. THANK YOU. THGE FUEL LEAKS WHILE RESTING IN PLACE OR IN MOTION. THE AMOUNT THIS LEAK GIVES OUT IS MORE THAN ADEQUATE TO LEAK ONTO THE VEHICLES EXHAUST AND "BOOM", THERE GOES THE VEHICLE UP IN FLAMES.

NHTSA ID

11241376

Incident

Jul 29, 2019

Mileage

180,000 mi

VEHICLE HAS SAME TIMP AND FAILED FUEL PUMP RELAY OF RECALL UNITS FROM MANUFACTURER AFFECTING 2007-2014, JEEP, DURANGO, AND TOWN AND COUNTRY. SEVERAL MECHANICS PREVIOUSLY COULD NOT FIND THE ISSUE WITH STALLING AND POOR ACCELERATION. THIS OCCURRED AND WORSENED OVER 6 MONTHS, BEFORE THE FUEL PUMP FINALLY FAILING.

NHTSA ID

11202663

Incident

Feb 14, 2019

Mileage

50,000 mi

TL* THE CONTACT OWNS A 2006 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE ENGINE FAILED AND THE ENGINE INDICATOR REMAINED ILLUMINATED. ALSO, THE VEHICLE RODE ROUGHLY WHILE DRIVING. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE OIL, WATER PUMP, AND FUEL PUMP LEAKED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 144,385. *TT *TR

NHTSA ID

11075611

Incident

Feb 1, 2018

Mileage

144,385 mi

THE WARNING LIGHTS ON THE DASHBOARD GO HAYWIRE, GIVING FALSE READINGS. THE GAS TANK IS FULL, BUT THE FALSE ALARM SAYS EMPTY - AND THE CAR STALLS. I HAD TO PAY $1221 FOR THE REPLACEMENT OF ELECRONIC CLUSTER, LATER ON $660 FOR ANOTHER ELECTRONIC PART. THIS DIDN'T HELP AND THE CAR KEPT GIVING FALSE ALARMS. THE CAR WOULD STALL ON HIGHWAY.

NHTSA ID

11074037

Incident

May 27, 2017

Mileage

41,000 mi

I HAVE A 2006 CONVERTIBLE PT CRUISER TURBO LITE (TURBO TUNED TO TAKE REGULAR GAS) - AND HAVE THE EXACT SAME PROBLEM THIS GUY I QUOTED BELOW HAD/HAS. RAW GAS FUMES FILL THE CAR EVERY TIME I TURN A CORNER OR ACCELERATE THE CAR TO PASS A SLOW MOVING VEHICLE ON THE INTERSTATE. USUALLY THE SLOW VEHICLE IS GOING ABOUT 60 SO IT'S NOT LIKE I THINK I'M ON THE SPEED-LIMIT-FREE AUTOBAHN. THE GAS TANK IS ALWAYS LESS THAN 1/2 FULL SINCE I RARELY DRIVE OUT OF TOWN. QUOTE FROM FACEBOOK - WARNING: ALL PT CRUISER OWNERS. FIRE HAZARD.. I JUST SUBMITTED THE FOLLOWING COMPLAINT TO THE NHTSA. THERE IS A SHORT JUMPER FUEL LINE (PLASTIC) THAT CONNECTS THE MAIN FUEL LINE THAT RUNS FROM THE TANK UP TO THE FIRE WALL WITH THE FUEL RAIL. THIS LINE LEAKS FUEL WHERE IT CONNECTS TO THE MAIN LINE. IT HAS BEEN REPLACED THREE TIMES AND CONTINUES TO LEAK. THIS IS DANGEROUS BECAUSE THIS LINE IS ONLY A FEW INCHES FROM THE TURBO OR EXHAUST AND ON A RIGHT HAND TURN COULD DRIP ON TO THE TURBO OR EXHAUST AND IGNITE...THE SMELL OF FUEL ENTERS THE CABIN. PLEASE NOTE THAT I AM A ASE CERTIFIED MASTER TECHNICIAN AND BESIDES OWNING A PT CRUISER HAVE WORKED ON SEVERAL OTHERS AND ALMOST EVERY SINGLE ONE HAS THIS PROBLEM WHETHER IT IS A TURBO ENGINE OR NOT...IT IS ONLY A MATTER OF TIME BEFORE SOMEONE EXPERIENCES AN ENGINE COMPARTMENT FIRE BECAUSE OF THIS PROBLEM... WHAT REALLY BOTHERS ME THE MOST IS THAT IF YOU ASK ANY CHRYSLER DEALER (ASK THE TECH) THEY WILL TELL YOU THIS IS A COMMON PROBLEM SO THERE IS NO DOUBT CHRYSLER IS AWARE. I GUESS SOMEONE IS GOING TO HAVE TO DIE OR SUFFER SEVERE INJURY BEFORE CHRYSLER DOES ANYTHING ABOUT THIS. "

NHTSA ID

11014784

Incident

Mar 17, 2017

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2006 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, ALL THE WARNING LIGHT ILLUMINATED AND THE FUEL GAGE WAS DECREASING INDEPENDENTLY. IN ADDITION, THE RPM WAS DECREASING CAUSING THE VEHICLE TO STALL. THE VEHICLE WAS ABLE TO RESTART MINUTES LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. THE VIN WAS NOT PROVIDED.

NHTSA ID

10860886

Incident

Apr 21, 2016

Mileage

53,000 mi

I BOUGHT A PT CRUISER SEDAN AND THE CAR LOT I BOUGHT IF FROM SAID IT NEEDED FRONT SHOCKS AND IT WOULD BE READY IN TWO DAY. I PICK UP THE PT CRUISER AND DECIDED TO TAKE IT TO MY MECHANIC AND HAVE IT CHECK OUT FROM TOP TO BOTTOM. IT HAS OVER 100 MECHANICAL ISSUES, FROM SHOCKS WHICH WERE NEVER PUT ON. THERE IS OIL IN THE SPARK PLUGS AND LEAVES A SMELL WHEN THE HEATER IS ON WHICH MAKES US VERY ILL. IT IS NOT SAFE TO DRIVE. ALSO, THE CAR LOT I BOUGHT IT FROM WHICH IT WAS SOLD FOR AROUND $2,000 DOLLARS AND NEEDS OVER $3,000 DOLLARS WORTH OF WORK. THEN I GOT SLAPPED WITH AN EXTRA 5,000 FROM THE LOAN COMPANY. THIS IS A LEMON. I AM NOT PAYING FOR ANYTHING AND HIM AND I HAVE WENT AROUND AND AROUND ABOUT THIS PIECE OF JUNK. THEY CAN REPO IT AND THEN I AM GETTING AN ATTORNEY FOR SELLING ME A CAR THAT SHOULD NOT BE ON THE ROAD. TOO DANGEROUS.

NHTSA ID

10559663

Incident

Dec 13, 2013

Mileage

104,000 mi

THERE IS A SHORT JUMPER FUEL LINE (PLASTIC) THAT CONNECTS THE MAIN FUEL LINE THAT RUNS FROM THE TANK UP TO THE FIRE WALL WITH THE FUEL RAIL. THIS LINE LEAKS FUEL WHERE IT CONNECTS TO THE MAIN LINE. IT HAS BEEN REPLACED THREE TIMES AND CONTINUES TO LEAK. THIS IS DANGEROUS BECAUSE THIS LINE IS ONLY A FEW INCHES FROM THE TURBO OR EXHAUST AND ON A RIGHT HAND TURN COULD DRIP ON TO THE TURBO OR EXHAUST AND IGNITE. ALSO IF SITTING IN TRAFFIC OR DRIVING AT SLOW SPEEDS WITH THE A/C OR HEATER ON IT MUST BE KEPT IN RECIRCULATE OR THE SMELL OF FUEL ENTERS THE CABIN. PLEASE NOTE THAT I AM A ASE CERTIFIED MASTER TECHNICIAN AND BESIDES OWNING A PT CRUISER HAVE WORKED ON SEVERAL OTHERS AND ALMOST EVERY SINGLE ONE HAS THIS PROBLEM WHETHER IT IS A TURBO ENGINE OR NOT. THE DEALER WILL DO NOTHING ABOUT IT BECAUSE THERE IS NO RECALL ON IT. I AM PRETTY CERTAIN IT IS ONLY A MATTER OF TIME BEFORE SOMEONE EXPERIENCES AN ENGINE COMPARTMENT FIRE BECAUSE OF THIS PROBLEM. ANYONE OWNING A PT CRUISER SHOULD HAVE THIS LINE INSPECTED TO SEE IF IT IS LEAKING AND IF SO FILE A SIMILAR COMPLAINT. IT IS VERY EASY TO SPOT AS THE LINE WILL APPEAR WET OR COVERED IN MOIST DIRT AT THE CONNECTOR. ALSO WITH THE ENGINE NOT RUNNING THERE WILL BE A VERY STRONG FUEL SMELL TOWARDS THE BACK OF THE ENGINE ON THE PASSENGER SIDE. FOR THOSE LIKE MYSELF THAT ALSO DETEST THE LOUSY FUEL ECONOMY THIS CAR GETS, THE FUEL LEAK MENTIONED ABOVE IS SURELY A CONTRIBUTING FACTOR. WHAT REALLY BOTHERS ME THE MOST IS THAT IF YOU ASK ANY CHRYSLER DEALER (ASK THE TECH) THEY WILL TELL YOU THIS IS A COMMON PROBLEM SO THERE IS NO DOUBT CHRYSLER IS AWARE. I GUESS SOMEONE IS GOING TO HAVE TO DIE OR SUFFER SEVERE INJURY BEFORE CHRYSLER DOES ANYTHING ABOUT THIS. *TR

NHTSA ID

10496165

Incident

Apr 7, 2010

Mileage

33,000 mi

VERY POOR MPG ON 2006 PT CRUISER TURBO WITH 18,000 MILES, PREMIUM CHEVRON/SHELL/UNION 76 FUEL ONLY. APPROX 12.9 CITY AND MAYBE 15.5 HIGHWAY. IN SHOP THREE TIMES WITH ISSUE, NEVER IMPROVED. *TR

NHTSA ID

10233447

Incident

Mar 20, 2008

Mileage

12,022 mi

I HAVE HAD THIS 2006 PT CRUISER FOR OVER A YEAR AND A HALF. WITHIN THAT YEAR AND A HALF, I HAVE NOW HAD TO REPLACE THE TIRES, BRAKES. THE AIR CONDITIONER JUST WENT OUT. THIS CAR HAS BEEN HORRIBLE. I CAN'T BLOW THE HORN WITHOUT POUNDING IT. THE LAMP ASSEMBLIES HOLD MOISTURE, THE THING DRINKS GAS AND RIGHT NOW WITH GAS PRICES THIS IS A PROBLEM. YET, NOBODY WANTS ME TO TRADE IT BECAUSE IT ISN'T WORTH A PENNY BECAUSE NOBODY WANTS THEM. THEY NEED TO RECALL THE FACT THEY LIED ON THE STICKERS ABOUT GAS MILEAGE. I MAY GET 17 MILES PER GALLON. HORRIBLE CAR. I HOPE PEOPLE STOP BUYING THEM UNTIL THEY FIX THE PROBLEMS THEY ALREADY HAVE. *TR

NHTSA ID

10228559

Incident

May 11, 2008

Mileage

44,052 mi

THE HORN IS HARD TO LOCATE AND BLOW. TERRIBLE FUEL MILEAGE - 4 CYL CAR ONLY GETS 16 MPG AND EATS GAS BADLY. ANYWAY I AM CURRENTLY FIGHTING CHRYSLER CORPORATION BECAUSE OF THEIR MANUFACTURING ERROR THEY PUT THE WRONG ENGINE IN MY NEW 2006 PT CRUISER CONVERTIBLE - TOURING EDITION. CHRYSLER'S BOOK, BROCHURES ETC. CLEARLY STATE THAT NOTHING BUT A STANDARD 2.4L 180HP TURBO ENGINE IS TO GO IN THIS CAR AND CHRYSLER PUT A REGULAR (NON-TURBO) ENGINE IN THIS CAR. CHRYSLER LIES AND SAYS THAT THE DOWNGRADED NON-TURBO ENGINE IS AN OPTION. BUT THERE IS NO OPTIONAL ENGINE AVAILABLE FOR THIS CAR AND ANOTHER ENGINE IS NOT SUPPOSED TO GO IN THE CAR. CHRYSLER REFUSES TO GIVE ME THE CORRECT CAR THAT I AM CURRENTLY PAYING FOR ETC. CHRYSLER CORP. CONTINUE TO LIE AND GIVE CUSTOMERS A VERY HARD TIME. *NM

NHTSA ID

10174193

Incident

Sep 4, 2006

CAR HORN HARD TO LOCATE AND BLOW. VERY LOW FUEL MILEAGE - ONLY GET 16 MPG ON A 2.4L NON-TURBO ENGINE-EATS GAS BADLY. SOMETIMES SEEMS LIKE THE ENGINE WANTS TO STALL. HAVE COMPLAINED TO DEALERSHIP AND CHRYSLER CORPORATION - BUT MAINLY BECAUSE CHRYSLER MANUFACTURERS PUT A NON-TURBO ENGINE IN MY 2006 PT CRUISER CONV. TOURING WHEN ONLY A TURBO ENGINE IS TO BE IN THIS CAR. CHRYSLER REFUSES TO GIVE ME THE CORRECT CAR AND TAKE THIS MANUFACTURING ERROR CAR BACK. THEY ARE LYING AND SAYING THAT THE 150 HP(NON-TURBO) ENGINE IS AN OPTION ENGINE. THERE IS NO OTHER ENGINE AS AN OPTION FOR THIS CAR - I HAVE THEIR BOOK AND OTHER DOCUMENTS. I AM CURRENTLY SEEKING HELP TO GET THE CORRECT CAR WITH THE TURBO ENGINE I AM PAYING FOR. CHRYSLER DOES NOT CARE AND GIVES THEIR CUSTOMER A HARD TIME. *NM

NHTSA ID

10174184

Incident

Sep 4, 2006