RoadVitals

2003 Compressor Mount Kit 4012120-02

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Jul 20, 2011
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Mar 6, 2003
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 3 NHTSA owner-reported complaints for the 2003 Compressor Mount Kit 4012120-02, most frequently naming the heating & air conditioning and engine categories. 1 safety recall has been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Heating & air conditioning360.0%
  • Engine240.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
03E015000

EQUIPMENT

Mar 6, 2003
249 units potentially affected
The defect: TRANS/AIR COMPRESSOR MOUNT KITS, PART NOS. 4012120-01, 4012120-02, AND 4012120-03, MANUFACTURED BETWEEN SEPTEMBER 1, 2002, AND MARCH 3, 2003. THE MOUNTS IN QUESTION ARE ONLY INSTALLED IN 2003 FORD VEHICLES WITH A 7.3L ENGINE. THESE COMPRESSOR MOUNT KITS CONTAIN A BELT GUARD THAT SHOULD NOT BE USED ON A 2003 MODEL YEAR VEHICLE. THERE MAY BE CONTACT BETWEEN THE BELT GUARD AND THE BRAKE LINE. THIS CONTACT, IF SEVERE ENOUGH, COULD RUD THROUGH THE BRAKE LINE RESULTING IN REDUCED BRAKING CAPACITY.
The risk: THIS CONDITION COULD HAPPEN WITHOUT PRIOR WARNING, POSSIBLY RESULTING IN A VEHICLE CRASH.
The remedy: TRANS/AIR WILL NOTIFY ITS CUSTOMERS AND REMOVE THE BELT GUARD. OWNER NOTIFICATION BEGAN JANUARY 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TRANS/AIR WARRANTY DEPARTMENT AT 1-800-673-2446 EXT. 268.
TRANS/AIR MANUFACTURING CORP.Manufacturer number 03-001View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Heating & air conditioningEngine
Filed Jul 20, 2011

20 AFTER I PURCHASED MY CAR AT CARMAX IN LAUREL, MD IN JUNE 2009 I HAD TO TAKE IT BACK BECAUSE MY AC WAS BLOWING HOT AIR, AFTER A DIAGNOSIS CARMAX SENT MY CAR TO A FITZGERALD VOLKSWAGEN DEALERSHIP IN ANNAPOLIS, MD WHERE THEY DIAGNOSED IT FOR THE SAME PROBLEM AND IN TURN HAD TO REPLACE MY AC COMPRESSOR, CONDENSOR AND CLUTCH. I RAN THE AC FOR APPROXIMATELY 2 MONTHS (JULY & AUG 2009) THAT YEAR, SINCE WE WERE ALREADY HALF WAY THROUGH THE SUMMER. IN MAY 2010 WHEN I TURNED MY AC ON AGAIN IT BLEW HOT AIR, I SENT IT BACK TO CARMAX WHO DIAGNOSED IT AGAIN AND SAID THE AC COMPRESSOR AND PRESSURE SWITCH SHOULD BE REPLACE, LESS THAN A YEAR SINCE THE INITIAL AC WAS REPLACED THE FIRST TIME. AT THIS POINT, I CALLED FITZGERALD AND WAS TOLD I WAS PAST MY 12,000 MILES PER THE REPLACEMENT WARRANTY AND THAT I WOULD HAVE TO PAY FOR THE WORK WHICH WAS QUOTED AT $2300 AND $1700. AFTER I COMPLAINED TO THE ATTORNEY GENERAL OFFICE, THE DEALER OFFERED A GOOD WILL ONE TIME OFFER DECREASING THE ESTIMATED COST TO $900. I DECLINED THE OFFER SINCE I DON'T BELIEVE I SHOULD HAVE TO PAY FOR SOMETHING THAT CLEARLY WAS NOT DONE CORRECTLY THE FIRST TIME. AFTER PURCHASING AN EXTENDED WARRANTY FOR ANOTHER ISSUE, I TOOK THE CAR BACK TO THE DEALER, THEY DIAGNOSED WITH THE SAME PROBLEM I AGREED TO HAVE THEM FIX IT BASED ON MY WARRANTY COVERAGE HOWEVER, I WAS DENIED COVERAGE BY THE WARRANTY COMPANY BECAUSE VOLKSWAGEN PREVIOUSLY ISSUED A TSB REGARDING AC ISSUES IN 2006 VW PASSAT. THIS TSB WAS ISSUED IN 2007, MY CAR WAS PURCHASED IN 2009. SO AS OF TODAY 7/20/2011 I AM STILL WITHOUT A WORKING AC SYSTEM AND I AM CURRENTLY DRIVING AROUND IN HEAT ADVISORY WEATHER WITH NO AC. I AM FORCED TO MAKE ALTERNATE ARRANGEMENTS FOR TRANSPORTATION AS A RESULT, SINCE THE EXCESSIVE HEAT EXPOSURE CAUSES ME HEADACHES & DIZZINESS. *KB

NHTSA ID
10413736
Incident
Jun 23, 2009
Mileage
24,336 mi
Heating & air conditioningEngine
Filed May 28, 2011

I HAVE A 2007 JEEP LIBERTY AND @ 44,000 MILES I HAD TO HAVE THE COMPRESSOR REPLACED, THE AUTO SHOP STATED THAT THE WIRES BURNED OUT AND THIS STOP THE COMPRESSOR WORKING, I ASKED HOW THIS COULD HAVE BEEN PREVENTED AND THE MECHANIC STATED THAT THIS COULD HAVE NOT BEEN AVOIDED DUE TO THE WAY JEEP HAS THE COMPRESSOR HOUSED. THIS COST ME OVER $1,000.00. *TR

NHTSA ID
10403621
Incident
May 20, 2011
Mileage
44,177 mi
Heating & air conditioning
Filed Jun 1, 2004

IN JULY 2001, WE PURCHASED A 2001 CHEVROLET SILVERADO (OKLAHOMA PACKAGE) FROM LAWRENCE MARSHALL CHEVROLET. IN MAY 2002, AT APPROXIMATELY 20,000 MILES, THE AIR CONDITIONER COMPRESSOR SHORTED OUT THE DISTRIBUTOR CAP WHICH STOPPED THE ENGINE FROM TURNING OVER. LAWRENCE MARSHALL FIXED IT UNDER FACTORY WARRANTY AT THAT TIME AND CONSIDERED IT COMPLETELY FIXED. IN MAY 2003, AT APPROXIMATELY 40,000 MILES, THE SAME CONDITION WAS FIXED BY LAWRENCE MARSHALL AND BECAUSE THEY CONSIDERED IT A FACTORY DEFECT, THEY FIXED IT FOR NOTHING. NOW THE SAME THING HAS HAPPENED AT 60,000 MILES ON THE SAME VEHICLE. WHEN YOU TURN ON THE AIR CONDITIONER, THE ENGINE DIES, BUT ONLY WHEN THE AIR CONDITIONER IS RUN FOR A WHILE. THIS VEHICLE IS DRIVEN BY MY SON, AND I DON'T WANT HIM TO GET STRANDED IN THE MIDDLE OF NO WHERE WITH THE TRUCK NOT STARTING. THE FIRST TIME THIS HAPPENED, IT HAD GOTTEN SO BAD THAT THE SALESMAN FROM LAWRENCE MARSHALL HAD TO HAVE THE TRUCK TOWED FROM IN FRONT OF NEW SALES TO THE SERVICE DEPARTMENT AT HIS ESTABLISHMENT. THE SECOND TIME IT HAPPENED, WE HAD TO HAVE IT TOWED FROM A FRIENDS HOUSE TO THE DEALERSHIP. NOW IT HAS STARTED HAPPENING AGAIN. PLEASE DO SOMETHING TO RECTIFY THE SITUATION.*AK

NHTSA ID
10074608
Incident
May 30, 2002