RoadVitals

2002 Country Coach Affinity Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Feb 1, 2007
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

07V031000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Feb 1, 2007
2,406 units potentially affected
The defect: CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
The risk: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
The remedy: COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.
COUNTRY COACH INCView on NHTSA.gov
03V109000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Mar 26, 2003
485 units potentially affected
The defect: ON CERTAIN MOTORHOMES EQUIPPED WITH INTERNATIONAL THERMAL RESEARCH (ITR)HURRICANE HOT WATER HEATERS, THE ELECTRONIC CONTROL BOARD MAY ADVERSELY AFFECT SAFETY FEATURES IN SOME OF THE SYSTEMS PROTECTING AGAINST OVERHEATING AND POTENTIAL FIRE SITUATION.
The risk: IF THE SAFETY FEATURES DO NOT SHUT DOWN PROPERLY, THE HEATING SYSTEM CAN CONTINUE HEATING, POSSIBLY RESULTING IN A FIRE.
The remedy: THE DEFECTIVE ELECTRONIC CONTROL BOARD WILL BE REPLACED. IN THE MEANTIME, CUSTOMERS SHOULD TURN THE SYSTEM OFF USING THE MASTER ON/OFF SWITCH LOCATED ON THE SIDE OF THE ELECTRONIC CONTROL BOX WHICH IS ADJACENT TO THE HEATER. OWNERS WHO TAKE THEIR MOTORHOMES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ITR AT 1-800-755-1272 OR COUNTRY COACH AT 1-800-547-8015.
COUNTRY COACH INCView on NHTSA.gov
01V322003

VEHICLE SPEED CONTROL:ACCELERATOR PEDAL

Nov 26, 2001
194 units potentially affected
The defect: VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
The risk: IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.
COUNTRY COACH INCView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources