RoadVitals

2003 Crane Lcf Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Newest Jul 21, 2004
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

3 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

04V339000

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Jul 21, 2004
3 units potentially affected
The defect: CERTAIN TRUCKS EQUIPPED WITH NEXGEN LIQUID NATURAL GAS (LNG) TANKS ARE BEING RECALLED. THE INTRODUCTION OF WATER INTO THE DISCHARGE SIDE OF BOTH THE PRIMARY AND SECONDARY RELIEF VALVES SIMULTANEOUSLY AND SUBSEQUENT FREEZING IN SERVICE CAN RENDER THE VALVES TEMPORARILY INOPERATIVE.
The risk: IF NOT INSPECTED THE RISK OF TANK OVER-PRESSURIZATION AND A CATASTROPHIC TANK RUPTURE CAN OCCUR, POTENTIALLY RESULTING IN SERIOUS INJURY OR DEATH.
The remedy: CRANE WILL PERFORM AN INSPECTION AND PROVIDE INSTRUCTIONS FOR ORDERING AND INSTALLING THE RETROFIT KIT. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2004. OWNERS SHOULD CONTACT CRANE AT 918-832-7305.
CRANE CARRIER COMPANYView on NHTSA.gov
03V241000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

May 15, 2003
2 units potentially affected
The defect: ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.
The risk: IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
The remedy: BOTH UNITS HAVE ALREADY HAD THE ELECTRONIC CONTROL MODULE CALIBRATION REPLACED.
CRANE CARRIER COMPANYView on NHTSA.gov
03V167000

SERVICE BRAKES, AIR:SLACK ADJUSTERS:AUTOMATIC

May 1, 2003
130 units potentially affected
The defect: ON CERTAIN TRAILERS EQUIPPED WITH A SPECIFIC COMBINATION OF REYCO SUSPENSION, EATON DRIVE AXLE, AND BENDIX SLACK ADJUSTERS, THE FAILURE OF A DRIVE AXLE SLACK ADJUSTER TO AUTOMATICALLY ADJUST AS REQUIRED TO COMPENSATE FOR BRAKE WEAR, WILL CAUSE AN OUT OF ADJUSTMENT CONDITION. IF THIS CONDITION OCCURS AND IS NOT IDENTIFIED AND CORRECTED THROUGH NORMAL INSPECTIONS AND MAINTENANCE, THE SLACK ADJUSTER WILL OVER-ROTATE AND MAY CONTACT THE SUSPENSION LOWER SPRING SADDLE.
The risk: IF THIS OCCURS, BRAKING PERFORMANCE WILL BE INHIBITED, INCREASING THE RISK OF A CRASH WITHOUT WARNING.
The remedy: CRANE CARRIER WILL SUPPLY, AT NO CHARGE, GUNITE SLACK ADJUSTERS AND INSTALLATION INSTRUCTIONS TO REPLACE THE EXISTING BENDIX SLACK ADJUSTERS ON THE DRIVE AXLE. THE INSTALLING FACILITY WILL BE REIMBURSED BY CRANE FOR ONE (1) HOUR LABOR PER VEHICLE AT THEIR POSTED LABOR RATE. OWNER NOTIFICATION BEGAN ON JUNE 10, 2003. OWNERS SHOULD CONTACT CRANE AT 1-918-832-7305.
CRANE CARRIER COMPANYView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources