RoadVitals

2002 Cummins C Gas Plus Engine

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Apr 4, 2003
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2002 Cummins C Gas Plus Engine. 1 safety recall has been issued covering this model year; and 3 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
03E021000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Apr 4, 2003
1,142 units potentially affected
The defect: CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES BUILT FROM JUNE 2001 THROUGH MARCH 2003. THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.
The risk: IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.
The remedy: CUMMINS WILL NOTIFY ITS CUSTOMERS AND REPLACE THE ELECTRONIC CONTROL MODULE CALIBRATION FREE OF CHARGE. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357.
CUMMINS, INC.Manufacturer number 0310View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

TSB230019-032120

ENGINE AND ENGINE COOLING

This Technical Service Bulletin describes the verification and resolution of active fault codes FC 3232 and FC 2771. This is an update to the previously submitted communication.

C0819

ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING:ENGINE

CUMMINS: ORION VOLTAGE REGULATOR CAMPAIGN. ADDRESSING A FUEL LIFT PUMP VOLTAGE REGULATOR ISSUE. AUTHORIZES REPAIR SHOP TO REMOVE CUMMINS VOLTAGE REGULATOR FROM WIRING HARNESS AND INSTALL SEPARATE 12-VDC POWER SOURCE FOR ORION BUS APPLICATIONS WITH ISB CM850 ENGINES AND 24-VDC ELELCTRICAL SYSTEMS. *PE

0345

ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER

C GAS PLUS ENGINES OPERATING AT ALTITUDE HAVE EXPERIENCED HIGH TURBO FAILURE RATES. THE TURBINE WHEEL IS FAILING DUE TO HIGH CYCLE FATIGUE. AN IMPROVED TURBO HAS BEEN RELEASED. THIS CAMPAIGN COVERS REPLACING THE CENTER CARTRIDGE ASSEMBLY OF THE TURBO WITH A NEW CARTRIDGE ASSEMBLY. *TT

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Cummins C Gas Plus Engine by model year
YearComplaintsRecallsInvestigationsIssue Index
2003010—
2002Viewing010—
2001110—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.