2003 Damon Challenger Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Damon Challenger, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Visibility240.0%
- Body & structure120.0%
- Brakes120.0%
- Fuel system120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
SUN VISORS CAN NOT BE REACHED WHILE SITTING. I HAVE TO PULL OVER TO THE SIDE OF THE ROAD TO ADJUST. AT TIMES THIS IS REAL DANGERIOUS SINCE MOST OF THE HIGHWAYS DO NOT HAVE PLACES WIDE ENOUGH TO ALLOW THIS. THIS PROBLEM HAPPENS ALL THE TIME, REAL BAD WHEN YOU ARE TRAVELING TO THE WEST.*AK
THE CONSUMER IS CONCERNED ABOUT THE SUN VISORS ON THE MOTOR HOME. WHILE DRIVING, THE DRIVER HAD TO UNBUCKLE THE SEAT BELT AND STAND UP TO REACH THE SUNVISOR. ONCE THE VISOR WAS PULLED DOWN IT WAS TOO SHORT TO BLOCK THE GLARE OF THE SUN AND AS A RESULT THE DRIVER COULD NOT SEE WHILE DRIVING. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
INSIDE COMPARTMENT DOORS DON'T HAVE SUPPORT, THIS IS SAFETY A SAFETY ISSUE THEY WERE NOT WELL DESIGNED. DEALER NOTIFIED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2003 DAMON CHALLENGER, WORKHORSE RECREATIONAL VEHICLE. SHE RECEIVED A RECALL LETTER PERTAINING TO THE FAILURE (SEE NHTSA CAMPAIGN ID NUMBER: 09V225000, NHTSA ACTION NUMBER: EA07016, COMPONENT: SERVICE BRAKES, HYDRAULIC) AND TOOK THE VEHICLE TO THE NEAREST AUTHORIZED DEALER. BEFORE ANY REPAIR WORK WAS PERFORMED ON THE VEHICLE THE DEALER STATED THAT THE REPAIR WAS AT NO COST; HOWEVER, THE DEALER ADVISED HER THAT THE VEHICLE WAS READY FOR PICK-UP. THE REPAIRS COST WAS OVER $800 AND WOULD NOT BE COVERED BY THE MANUFACTURER DESPITE THE FACT THAT HER SPECIFIC RV WAS A PART OF THE RECALL. THE WORKHORSE DEALER WOULD NOT COVER THE INSPECTION TO THE VEHICLE NOR THE REPLACEMENT OF ANY PARTS SINCE THE PARTS ARE SUBJECT TO WEAR. THE MANUFACTURER WAS CONTACTED AND VERIFIED THAT THERE WAS AN OPEN RECALL ON THE VEHICLE; HOWEVER, SHE WAS ADVISED BY THE CUSTOMER SERVICE AGENT THAT SHE NEEDED TO SPEAK WITH THE REGIONAL MANAGER SINCE HE WAS NOT AUTHORIZED TO GIVE HER ANY ADDITIONAL INFORMATION PERTAINING TO THE ISSUE. THE CONTACT WAS UPSET THAT SHE WAS BEING CHARGED FOR COMPONENTS AND INSPECTIONS LISTED IN THE RECALL. THE RECALL WAS NOT HONORED. REPAIRS WERE MADE TO THE BRAKES, BRAKE PADS, A FLUSH WAS PERFORMED AND AN INSPECTION, ALL OF WHICH WERE AT THE OWNERS EXPENSE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 33,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
STALLING WHEN IT RAINS. IT SEEMS THAT THE AIR FILTER IS RIGHT IN FRONT OF THE RIGHT FRONT WHEEL. WHEN IT RAINS THE FRONT TIRE KICKS UP WATER IN THE AIR FILTER HOUSING SOAKING THE AIR FILTER CAUSING THE ENGINE TO QUIT RUNNING. THIS HAPPENS EVERY TIME IT RAINS HARD. I HAVE TO REPLACE THE FILTER IN ORDER TO CONTINUE DRIVING. CARRYING EXTRA AIR FILTERS IS STARTING TO GET EXPENSIVE. RIGHT NOW I USE DUCK TAPE TO SEAL THE FILTER BOX. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .