2002 Damon Daybreak Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Damon Daybreak, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes342.9%
- Body & structure114.3%
- Electrical114.3%
- Steering114.3%
- Suspension114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2002 DAMON DAYBREAK RV. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS A DELAYED RESPONSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT ROTORS AND CALIPERS NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 09V110000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOTIFIED AND STATED THE VIN WAS NOT INCLUDED. THE APPROXIMATE FAILURE MILEAGE WAS 30,052.
WHILE TRAVELING AT 35 MPH WITH OUR 2002 DAMON DAYBREAK RV WITH THE P32 CHASSIC WE SMELLED A BURNING BRAKE ODOR REAL BAD INSIDE. AT THAT TIME THE BRAKE PEDAL PRESSURE WAS GOOD. WE HAD JUST LEFT OUR HOME HEADING OUT ON OUR TRIP WHEN THIS OCCURRED. WE MADE THE DECISION TO TURN AROUND AND HEAD BACK TO OUR LOCAL REPAIR SHOP FOR INSPECTION. WE PULLED IN TO OUR REPAIR SHOP WE HAD NO BRAKE PEDAL. AFTER STOPPING IN THE PARKING LOT OF THE REPAIR SHOP I FOUND THE FRONT BRAKES ON FIRE. YES ON FIRE. LUCKILY WE HAD A FIRE EXTINGUISHER INSIDE AND WAS ABLE TO EXTINGUISHER THE FIRE BUT NOT AFTER A LOT OF DAMAGE WAS DONE. I AM NOW TOLD JUST TODAY WE ARE LOOKING AT A MINIMUM OF $2500 TO $3000 IN REPAIRS FOR STARTERS. THIS RV HAS ONLY 25,422 MILES ON IT. PROBLEMS SUCH AS OURS HAS BEEN RECORDED FOR YEARS AND DAMON CORPORATION OR WORKHORSE CHASSIC REFUSES TO ACKNOWLEDGE THE PROBLEM. I SPOKE TO BOTH THIS MORNING AND WAS TOLD THEY WERE SORRY FOR OUR PROBLEM BUT THEY HAVE NO RESPONSIBILITY FOR IT. WHEN A LIFE IS TAKEN AS A RESULT FROM THIS BRAKE PROBLEM THEN MAYBE SOMETHING WILL HAPPEN. THAT'S SAID TO THINK THIS WAY BUT TRUE. THE P32 CHASSIC PROBLEM IS JUST AS BAD AS THE W20 SERIES RECALL. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
CONSUMER STATES THE VEHICLE CHASSIS STRUCTURE, WAS NOT WELL DESIGNED BY THE MANUFACTURER CAUSING PROBLEMS HILE DRIVING THE VEHICLE. DEALER HAS BEEN NOTIFIED. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
VEHICLE SHUT DOWN WHILE EXITING THE HIGHWAY.*MR WHILE LEAVING THE EXPRESSWAY AT 5 MPH THE MOTORHOME'S NEUTRAL SWITCH FAILED AND CAUSED THE VEHICLE'S BRAKES TO ACTIVATE SUDDENLY. THE SUDDEN BRAKING WAS FOLLOWED BY THE ENGINE SHUTTING DOWN. THE CONSUMER CONTACTED THE MANUFACTURER AND THEY INDICATED THAT THEY WERE AWARE OF THE PROBLEM WITH THE NEUTRAL SWITCH . THE CONSUMER IS CONCERNED BECAUSE THE MOTORHOME IS NOT EQUIPPED WITH AND EMERGENCY BRAKE AND IF THE PART FAILED AGAIN WHILE DRIVING AT A FASTER SPEED THE OUTCOME MAY BE DIFFERENT. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
PROBLEMS WITH VEHICLE'S STEERING AND SUSPENSION.*MR (NAR) DEALER WAS NOTIFIED AND TO DATE HAS YET FIXED THE PROBLEM. *CB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
PROBLEMS WITH VEHICLE'S STEERING AND SUSPENSION.*MR (NAR) DEALER WAS NOTIFIED AND TO DATE HAS YET FIXED THE PROBLEM. *CB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .