2007 Damon Daybreak Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2007 Damon Daybreak, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical250.0%
- Other / unspecified125.0%
- Tires & wheels125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WE HAVE AN IOTA TS-50R RELAY TRANSFER SWITCH UNIT IN OUR 2007 DAMON DAYBREAK 3274 MOTOR HOME, PURCHASE USED FROM A DEALER IN APRIL 2019 WITH 11,800 MILES. IT RECENTLY STARTED OVER HEATING AND MALFUNCTIONS. AFTER EXTENSIVE RESEARCH, MANY MOTORHOME MODELS MFG BY VARIOUS SOURCES HAVE RECALLED THE UNIT AND/OR CONSUMERS HAVE REPORTED HAVING SAME ISSUES WITH FIRE HAZARD. I HAVE SPOKEN WITH THE PREVIOUS OWNER; AN ELDERLY GENTLEMAN WHO VERY RARELY USED THE MOTORHOME. THOR ACQUIRED DAMON VIA MERGE AND CURRENTLY HAS A RECALL ON THE IOTA ITS-50R BUT ONLY INCLUDES NEWER MODELS WITH THE SAME RELAY TRANSFER SWITCH. GOOGLING PRODUCED MANY FORUMS WITH CONTENT EXACT TO OUR ISSUE, SOME WITH MELTDOWNS, SOME WITH FIRES. IOTA ENGINEERING HAS YET TO ISSUE A RECALL, DESPITE THESE LIFE THREATENING SAFETY ISSUES. *JS
STATIONARY: EQUIPPED WITH AN IOTA ITS-50R, TRANSFER SWITCH IS EXPERIENCING FAILURE AND HEATS. BYPASSING THE DELAY CAUSES THE SWITCH TO WORK WHEN IT OTHERWISE WON'T. THERE IS A RECALL ON THE IOTA ITS 50R ISSUES BY THOR AND THE 2007 DAMON DAYBREAK IS NOT A CURRENTLY INCLUDED PRODUCT LINE - BUT SHOULD BE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
THIS YEAR ON OUR ANNUAL FAMILY VACATION WE HAD 2 TIRE FAILURES, ONE OCCURRED TRAVELING DOWN THE HIGHWAY AND WAS THE INNER REAR TIRE DRIVERS SIDE OF THE REAR DUAL WHEELS. THE OTHER FAILURE OCCURRED AFTER THE RV HAD BEEN PARKED FOR 20 MINUTES IN MY DRIVEWAY. THE TIRE EXPLODED AFTER THE RV HAD BEEN PARKED FOR OVER 20 MINUTES. UPON INSPECTION OF THE TIRE FAILURE IT WAS A INNER SIDEWALL (ENGINE FACING) BLOWOUT AT THE 11:00 O'CLOCK POSITION. I HAVE CONTACTED GOODYEAR ABOUT THE FAILURE AND THEY HAVE REFERRED ME TO A SERVICE CENTER FOR THE TIRE TO BE INSPECTED. THE TIRE SIZE IS 245/70R/19.5 THIS FAILURE IS IN ITS NATIVE STATE SINCE THE EXPLOSION. IT WOULD BE IN THE NATIONAL HIGHWAY TRANSPORTATION SAFETY ADMINISTRATION INTEREST TO HAVE THIS PARTICULAR ASSET IN TACT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2007 DAMON DAYBREAK EQUIPPED WITH GOODYEAR TIRES UNISTEEL TIRES, SIZE: 245/70/R19.5 (NA). WHILE DRIVING AT APPROXIMATELY 65 MPH, THE REAR OF THE VEHICLE VIBRATED AND THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED. AFTER THE VEHICLE WAS PARKED, THE FRONT DRIVER SIDE TIRE BLEW OUT WITHOUT WARNING. THE CONTACT OBSERVED THAT THE BLOW OUT WAS ON THE INNER WALL OF THE TIRE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE TIRE WAS NOT REPLACED. THE DOT NUMBER WAS UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 14,107.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .