RoadVitals

2007 Damon Intruder Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Sep 9, 2010
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

10V407000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS:TANK ASSEMBLY

Sep 9, 2010
271 units potentially affected
The defect: DAMON IS RECALLING CERTAIN MODEL YEAR 2007-2011 CHALLENGER, MODEL YEAR 2005-2007 INTRUDER MOTOR HOMES. THESE MOTOR HOMES DO NOT HAVE THE PROPER CLEARANCE BETWEEN THE REAR SUSPENSION LEAF SPRING AND THE VEHICLE LIQUID PROPANE FUEL TANK. AS THE SUSPENSION TRAVELS IT IS POSSIBLE FOR THE LEAF SPRING SHACKLE BOLT TO COME IN CONTACT WITH THE TANK. THIS POTENTIALLY COULD PUNCTURE THE TANK AND RESULT IN A FIRE OR EXPLOSION.
The risk: IN THE EVENT OF A FIRE OR EXPLOSION, THERE IS A POTENTIAL FOR PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
The remedy: DAMON WILL INSPECT TO SEE IF THE PROPER CLEARANCE BETWEEN THE SHACKLE BOLT AND THE TANK EXISTS. IF IT IS FOUND THERE IS NOT ENOUGH CLEARANCE, THE TANK WILL BE RELOCATED TO PROVIDE THE PROPER CLEARANCE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 6, 2010. OWNERS MAY CONTACT DAMON WARRANTY SERVICE DEPARTMENT AT 877-855-2867.
THOR MOTOR COACHManufacturer number RC000018View on NHTSA.gov
09V225000

SERVICE BRAKES, HYDRAULIC

Jun 16, 2009
2,415 units potentially affected
The defect: DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.
The risk: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY AND OWNER NOTIFICATION FOR THIS CAMPAIGN PLEASE SEE 09V-110. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
DAMON CORPORATIONView on NHTSA.gov
08V255000

EQUIPMENT:OTHER:LABELS

Jun 5, 2008
265 units potentially affected
The defect: DAMON IS RECALLING 265 MY 2007 INTRUDER (373, 374, 378), MY 2007-2009 OUTLAW (3611), AND MY 2009 CHALLENGER (371, 376, 377, 378) MOTOR HOMES BUILT ON FORD CHASSIS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE METRIC AND ENGLISH VALUES FOR THE TIRE AIR PRESSURES WERE INADVERTENTLY SWITCHED. THE LABELS READ 90KPA/620PSI AND SHOULD READ 620KPA/90PSI.
The risk: UNDER OR OVER-INFLATED TIRES CAN CAUSE OR CONTRIBUTE TO PREMATURE TIRE FAILURE, POSSIBLY RESULTING IN A SUDDEN BLOWOUT OR OTHER FAILURE WHICH COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE.
The remedy: OWNERS WILL BE SENT A REVISED CERTIFICATION LABEL WITH THE CORRECT TIRE PRESSURE VALUES ALONG WITH INSTALLATION INSTRUCTIONS. THE RECALL BEGAN ON JULY 14, 2008. OWNERS MAY CONTACT DAMON AT 1-800-860-3812.
DAMON CORPORATIONManufacturer number 08-124View on NHTSA.gov
06V451000

ENGINE AND ENGINE COOLING

Nov 28, 2006
1,517 units potentially affected
The defect: ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
The risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
The remedy: CHEVROLET AND WORKHORSE ARE HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225 AND 06V289). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, WORKHORSE AT 877-294-6773, OR DAMON AT 1-574-264-5517.
DAMON CORPORATIONView on NHTSA.gov
06V236000

STEERING

Jun 30, 2006
116 units potentially affected
The defect: CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
The risk: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
The remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR DAMON AT 574-264-2900.
DAMON CORPORATIONView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources