Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 1999 Dodge 1500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 16 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
MY TRUCK JUST CUT OFF WOULDNT START BACK RUN STRAIGHT WIRE FROM IGNITION CHANGED IGNITION RELAY NOTHING NEXT RUN STRAIGHT WIRE FROM RELAY TO BATTERY IT STARTED UP I HAVE NO O/D AND HAVE TO SHIFT BY HAND SOMETIMES TRUCK STALLS BUT STARTS RIGHT BACK UP BEEN THIS WAY SINCE 2010 TRUCK HAS 55000 MILES ON IT.
TRANSMISSION STAYS STUCK IN 2ND GEAR WILL NOT UP SHIFT
AM ON THIRD ENGINE EACH TIME OIL PUMP FAILED,AND NOW THIS ONE IS ACTING UP, POWERTRAIN END OF YEAR BUILT TRUCK HAS A LOT OF 2000 PARTS ON IT, REAR END SEIZED UP DRIVE SHAFT BROKE REAR YOAK SPLIT IN TWO, SUSPENSION TIE RODS AND IDLE ARMS ALWAYS BREAKING, TWO BREAK DISKS 1 LEFT SIDE 1 RIGHT SIDE BROKE, LEFT ONE SPLIT RIGHT DOWN THE MIDDLE, THE RIGHT SIDE THE CENTER OF THE HUB BROKE RIGHT OUT AT THE BEARINGS RIPED RIGHT OUT
REAR DIFFERENTIAL JUST FELL OFF OF THE TRUCK GOING DOWN HIGHWAY! SMOKE EVERYWHERE , I MAINTAINED COMPOSURE AND GOT OFF OF THE SIDE OF THE HIGHWAY. THANKFULLY NO ONE WAS INJURED AS I WAS IN THE PASSING LANE PASSING A SEMI WHEN THIS HAPPENED.
TL* THE CONTACT OWNS A 1999 DODGE RAM 1500. WHILE DRIVING 60 MPH, THE GEARS SLIPPED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
TRANSMISSION CONTINUALLY SHIFTS BACK AND FORTH BETWEEN 2ND AND 3RD GEARS AND/OR 3RD AND 4TH GEARS. *TR
TL* THE CONTACT OWNS A 1999 DODGE RAM 1500. THE CONTACT STATED THAT WHILE DRIVING 35 MPH THE TRANSMISSION DROP FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THE TRANSMISSION AND THE TRANSFER CASE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 115,000.
TL*THE CONTACT OWNS A 1999 DODGE RAM 1500. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT HEARD A GRINDING NOISE FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE REAR DIFFERENTIAL AND PINION BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE OCCURRED THREE ADDITIONAL TIMES AND THE VEHICLE WAS REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED ASSISTANCE FOR THE FIRST THREE REPAIRS BUT NOT THE FOURTH. THE FAILURE MILEAGE WAS 14,044 AND THE CURRENT MILEAGE WAS APPROXIMATELY 50,000.
DODGE RAM 1500 YEAR 1999 [XXX] MILEAGE: 66,164 [XXX] CUSTOMER SERVICE: I RESPECTFULLY REQUEST REIMBURSEMENT FOR THE RESENT REPAIRS INCURRED IN REFERENCE TO INVOICE #[XXX] AS I WAS DRIVING DOWN THE FREEWAY EARLY THURSDAY MORNING OF THE 9TH OF FEBRUARY OF THIS YEAR, I HEARD A VERY LOUD BANGING OF METAL ON METAL AT THE SAME TIME THE REAR WHEELS OF MY TRUCK LOCKED UP. THE TRUCK THEN SKIDDED OFF THE ROAD BARELY MISSING THE GUARDRAIL AND OTHER CARS IN THE ADJACENT LANES. I TOOK THE TRUCK TO MARIETTA DODGE. UPON INSPECTION BY THE DEALERSHIP I WAS SHOWN BY THE TECH THAT THE CLIPS THAT HOLD THE PIN THAT SUPPORTS THE FICTION CLUTCH AND GEAR ASSEMBLY OF THE DIFFERENTIAL HAD FALLEN OUT INTO THE HOUSING LETTING THE PIN AND THE CLIPS FALL DOWN INTO THE GEARS CAUSING REAR-END TO LOCKUP AND SEVERE DAMAGE TO IT. THIS IN-TURN DAMAGED THE RING AND PINION GEARS AS WELL AS THE CASE, THE BEARINGS AND SO ON. A LIST OF THE PARTS AND LABOR ARE ON THE ACCOMPANYING. INVOICE # [XXX] TOTAL: $3730.86 I TOOK THE DAMAGED PARTS TO THE MACHINE SHOP AT THE BASE AND HAD THEM MAG-NI-FLUX TESTED. WE FOUND THAT THE SEVERAL OF THE PARTS HAD STRESS CRACKS INCLUDING THE RIGHT REAR AXIAL JUST BEHIND THE HUB THAT COULD OF LED TO ANOTHER ACCIDENT SHORTLY DOWN THE ROAD. THE MACHINIST CONCLUDED THAT THE CLIPS COULD HAVE FAILED DO TO POOR CASTING AND OR METAL FATIGUE. I WOULD TRULY APPRECIATE SOMEONE GETTING BACK TO ME ABOUT THIS REQUEST FOR REIMBURSEMENT AS SOON AS POSSIBLE. THANK YOU FOR YOUR TIME AND CONSIDERATION ON THIS MATTER. SINCERELY [XXX] *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
DRIVING ALONG HIGHWAY 70 NEAR QUICNY CA. WHEN RIGHT REAR AXLE BROKE SENDING THE VEHICLE INTO THE ROAD EMBANKMENT OVER TURNING THE VEHICLE ONTO ITS ROOF, THEN FLIPPING IT AGAIN ONTO THE REMAINING THREE WHEELS. THE VEHICLE HAD FRONT IMPACT AND THE AIR BAGS DID NOT DEPLOY. *JB
1999 DODGE RAM EXPERIENCING PROBLEMS WITH THE BRAKES AND THE CATALYTIC CONVERTER.*MR 1 YEAR OLD AND NOT ON REPOSITORY. WHEN THE BRAKES WERE APPLIED A LIGHT ON THE DASH ILLUMINATED. THE DEALER STATED THERE WAS NO PROBLEM WITH THE BRAKES. THE CONSUMER TOOK THE VEHICLE TO ANOTHER MECHANIC, WHO STATED HE WAS SOLD A VEHICLE WITH NO BRAKES. THE MECHANIC STATED THE VEHICLE NEEDED TO FRONT BRAKES WITH SHIMS, FRONT ROTORS, TWO FRONT CALIPERS, BEARINGS, TWO REAR SHOES, TWO REAR HARDWARE, TWO DRUMS AND TWO REAR WHEEL CYLINDERS. THE VEHICLE JERKED WHEN THE CONSUMER PLACED THE GEAR INTO REVERSE. THE FRONT WHEEL ON THE DRIVERS SIDE WOULD SHAKE WHEN THE CONSUMER HIT A POTHOLE. THE WINDOWS WOULD FOG WITH A GREASY FILM, THE HEATING COIL WAS REPLACED. THE CHECK ENGINE LIGHT ILLUMINATED AND THE 02 SENSOR WAS REPLACED. THE PCV VALVE HOSE WAS REPLACED, THE LEFT BRAKE LIGHT BULB WAS REPLACED, 4 INJECTORS WERE REPLACED. *JB
WHILE DRIVING AT ANY SPEED CONSUMER HEARD A SQUEAKING SOUND COMING FROM THE REAR AXLE OF THE VEHICLE. REAR PINION BEARINGS WERE REPLACED FIVE TIMES. DEALER CLAIMED THAT THE PROBLEM WAS CORRECTED. HOWEVER, CONSUMER INSISTED THAT THE PROBLEM WAS STILL EVIDENT. *AK *MR
VEHICLE HAD A REAR DIFFERENTIAL PROBLEM AND WAS REPAIRED FOUR TIMES WITH NO REMEDY. CONSUMER THOUGHT OF REPLACING THE ENTIRE COMPONENT, BUT DEALER REFUSED BECAUSE IT WOULD BE IMPOSIBLE TO ORDER FOR THE PARTS. *LA *MR
WHILE DRIVING 45 MPH A LOUD NOISE WAS HEARD AND THE BRAKES LOCKED WHICH CAUSED THE VEHICLE TO VEER TO THE RIGHT. VEHICLE WOULD NOT MOVE AND HAD TO BE TOWED TO THE DEALER. THE DEALER REPLACED THE DIFFERENTIAL. *AK *TS *NLM
TRANSFER CASE SHATTERED , DRIVESHAFT BROKE LOOSE WHILE DRIVING. *AK
CONSUMER NOTICED THAT WHEN TRAVELING A LOUND NOISE COME FROM UNDERNEITH THE VEHICLE. CONSUMER CONTACTED THE DEALER REGARDING THE PROBLEM. DEALER DETERMINED THAT THE NOISE WAS DUE TO A CRACK WITHIN THE DRIVESHAFT, DEALER HAS REPLACED THE DRIVESHAFT. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .