1990 Dodge D250 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1990 Dodge D250, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes228.6%
- Suspension228.6%
- Body & structure114.3%
- Driver assistance114.3%
- Other / unspecified114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE BRAKE LINE FRACTURED ITS IN FRONT OF THE AXLE THE BRAKE FLUID LEAK OUT . TT
CONSUMER WAS DRIVING AND GO TO APPLY THE BRAKE FAILED HAVE ABS ANTI-LOCK BRAKE THERE IS NO WARNING . TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
UPPER BALL JOINT FAILED, AFTER REPAIR WORK COMPLETED UPPER BALL JOINT PULLED OUT OF CONTROL ARM DUE TO THREADS BEING STRIPPED, DAMAGING CONTROL ARM AND NEW BALL JOINT.
UPPER AND LOWER BALL JOINTS FAILED, REPAIR MADE HOWEVER FAILURE OCCURED DUE TO STRIPPING OF THE THREADS OUT OF THE UPPER CONTROL ARM, RESULTING IN LOSS OF CONTROL.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
ISSUES WITH FRAME CRACKING ON 2WHEEL DRIVE DIESEL EQUIPPED 1990-1993 DODGE PICKUP WHERE LOWER CONTROL ARM MOUNTED TO FRAME EARS. ALSO FRAME CRACKING BETWEEN ENGINE MOUNTS AND STEERING BOX ON 2WHEEL DRIVE MODELS AND BETWEEN FRONT SPRING HANGERS AND STEERING BOX ON 4 WHEEL DRIVE DIESELMODELS. IF TRUCKS HIT IN FRONT RIVETS BECOME LOOSE AND ADDITIONAL FRAME DAMAGE OCCURS. 1972-1993 1/2 TON MODEL IE D100 AND D150 HAVE NOTORIETY FOR CRACKING FRAMES AT STEERING BOXES. I HAVE OWNED MANY OF THESE TRUCK OVER THE YEARS INCLUDING CURRENT WITH ISSUES: D13BB8J501603 - D150 2WD, [XXX] - W350 DSL 4WD, AND [XXX] - D250 DSL 2WD . VEHICLES WERE STATIONARY WHEN DEFECTS DISCOVERED DURING ROUTINE INSPECTION AND MAINTENANCE. D150 FRAME UPGRADED MANY YEARS AGO WITH CROSSMEMBER FROM STEERING BOX TO IDLER ARM WITHOUT ANY FAILURES. WORKING TO BUILD CORNER BRACES AND FRAME REINFORCEMENTS FOR DIESEL MODELS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1991 DODGE D250 (N/A). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE RPMS INCREASED AS THE VEHICLE WAS IN FULL THROTTLE. THE CONTACT WAS ABLE TO DECELERATE BY SWITCHING TO NEUTRAL HOWEVER, THE VEHICLE THEN STALLED. THE FAILURE WAS RECURRING. THE VEHICLE WAS INSPECTED AND DIAGNOSED BY AN INDEPENDENT MECHANIC, WHO REPLACED THE THROTTLE POSITION SENSOR CHIP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE AND CURRENT MILEAGE WAS 85000. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
ISSUES WITH TIRE FAILURES, WITH LT236X75R16 TIRE FAILURES ON THIS D250 AND W350 TRUCKS. KNOW OTHER INDIVIDUALS EXPERIENCING THE SAME ISSUES AND HAVE BEEN RIDING BEHIND THEM WHEN I WITNESSED SAID FAILURES OCCURR. BRANDS HAVE INCLUDED BUT NOT BEEN EXCLUSIVE TO GENERAL, CONTINENTAL, ETC. I HAVE BLOWN OR HAD TREAN PEEL OFF 5 TIRESIN THE PAST 6 YEARS WHILE ONE FRIEND HAS 6 SIMILAR OCCURRENCE IN THE PAST YEAR. RUBBER SEEMS TO BECOME BRITTLE AND SEPERATE FROM THE STEEL CORD. MAY BE RELATED TO A RUMOR THAT THE RUBBER COMPUNDS WERE ALTERED TO CAUSE TIRES TO "DRY ROT" AFTER SEVERAL YERAS SO NO SITTING IN JUNKYARDS FOREVER. OWN OVER 30 VEHICLES AND HAVE CONSTANT PROBLEMS WITH CRACKING IN TREAD AND SIDEWALL AREAS ON ALL TIRES. BUT THE LT235X85R16 TIRES SEEM TO HAVE THE MOST CATASTROPHIC FAILURES PARTICULARLY AT HIGHWAY SPEEDS TO THE POINT I AM PULLING THEM OFF ALL THE VEHICLES THAT I CAN. ENVIROMENTALLY THIS CAUSES MORE WASTE IN OIL LOSS AND MANUFACTURING BYPRODUCT CREATION WHEN NEW TIRES MUST CONSTANTLY BE PURCHASED TO REPLACE DRY ROTTING TIRES WITH ALMOST NEW TREAD ON THEM!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .