2005 Dodge Dakota Interior & seats Problems

The contact owns a 2005 Dodge Dakota. The contact stated that the vehicle had been shipped to them. While the vehicle was parked, the contact inspected the vehicle and observed that the frame was severely corroded. The contact also noted that the frames of all the vehicle doors were corroded as well. The vehicle was taken to an independent mechanic, where it was not formally diagnosed; however, the mechanic informed the contact that the frame was severely corroded, the vehicle was structurally compromised, and they were unsure whether the vehicle could be repaired. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 81,892.

NHTSA ID

11725826

Incident

Mar 20, 2026

Mileage

81,892 mi

WHILE DRIVING ON I-635 NORTHBOUND AT AROUND 25 TO 30 MPH WITH 4X4 ACTIVATED ON A SINGLE LINE AVAILABLE SINCE IT WAS CLEARED AND SALTED. WITHOUT WARNING I WAS THE ONLY VEHICLE THAT VEERED RIGHT HARD AND I LOST CONTROL OF THE VEHICLE ALMOST CRASHING ONTO THE METAL BEAM ALONG THE HIGHWAY. I WENT PAST THE SHOULDER AND DOWN TO THE BOTTOM OF HILL, BUT THANKFULLY VEHICLE DIDN'T TURN OFF. I HAD TO SWITCH OFF 4X4 AND BACK ON AND WAS ABLE TO CLIMB UP DESPITE THE SNOW BACK TO THE HIGHWAY WITH NO FURTHER REOCCURRENCE. UNFORTUNATELY WHEN THIS HAPPENED MY PASSENGER SEAT WENT FORWARD AND IS NOW STUCK AND I BROKE LEVER TRYING TO BRING IT BACK FROM FRONT RECLINING. BECAUSE OF THE ROUGH TERRAIN THE REAR QUARTER PANELS WHERE THE WAS SOME RUST HAVE CRACKED

NHTSA ID

11400268

Incident

Feb 8, 2021

Mileage

189,000 mi

HEATED DRIVER SEAT CAUGHT FIRE. CALLED DEALERSHIP AND WAS TOLD THERE WAS A RECALL ON THE DRIVER HEATED SEAT. THE DEALER SAID THERE WAS AIRBAG RECALL ON THE DRIVER AND PASSENGER SIDE OF THE TRUCK. THE DEALER SAID THEY WOULD NOT REPAIR AIRBAGS AND WOULD NEED TO CONTACT DODGE FOR A CASE NUMBER. CONTACTED DODGE AND WAS TOLD JUST DRIVE CAREFULLY.

NHTSA ID

11311862

Incident

Feb 27, 2020

Mileage

112,855 mi

I RECEIVED A RECALL NOTICE FOR THE T80 HEATED SEATS IN MY 2005 DODGE DAKOTA I CALLED THE CHRYSLER REPRESENTATIVE SCHEDULE A REPAIR SERVICE WITH PERKINS DODGE COLORADO SPRINGS HE ORDERED THE SEATS I TOLD THE REPRESENTATIVE THAT THE PASSENGER SIDE HAD A BURN HOLE IN IT AND HAD CAUGHT FIRE WHEN THE NEW SEATS ARRIVED AT PERKINS DODGE I TOOK MY TRUCK IN TO BE REPAIRED THEY TOLD ME THEY WILL NOT DO THE PASSENGER SEAT BECAUSE OF THE BURN HOLE HAS CUT OUT PIECES. I TOLD THEM I HAD TO REMOVE SOME OF THE BURNT MATERIAL TO PUT A SEAT COVER ON AND STILL UTILIZE THE SEAT. SEATS ARE STILL UNDER RECALL THEY ORDERED THEM KNOWING THAT THERE WAS A BURN HOLE I DON'T UNDERSTAND WHY THEY WILL NOT PROCEED WITH THE REPAIR THE INFORMATION FOR THE CASE NUMBER AND REPRESENTATIVE I TALKED TO IS HERE.... MY NAME IS [XXX] FROM THE FCA CASE MANAGEMENT DIVISION, I HAVE BEEN ASSIGNED AS YOUR CASE MANAGER. HERE IS SOME INFORMATION THAT WILL BE HELPFUL FOR YOU TO HAVE: YOUR CASE NUMBER IS [XXX] THE CHRYSLER CASE MANAGEMENT TELEPHONE NUMBER IS: [XXX] MY DIRECT EXTENSION: [XXX] MY WORK HOURS ARE: 8:00 AM - 4:30 PM EASTERN STANDARD TIME (MONDAY-FRIDAY). I WILL CONTACT YOU WITHIN ONE BUSINESS DAY OF YOUR APPOINTMENT BY TELEPHONE TO REVIEW YOUR CASE WITH YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR - (RECALL RELATED INCIDENT) TS

NHTSA ID

11217628

Incident

May 30, 2019

TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED THAT THE PART FOR NHTSA CAMPAIGN NUMBER: 17V820000 (SEATS) WAS UNAVAILABLE. THE DEALER (PARKWAY CHRYSLER DODGE JEEP RAM, 21560 HALL RD, CLINTON TWP, MI 48038, (586) 465-7210) WAS UNABLE TO VERIFY A REASONABLE TIME FRAME TO RECEIVE THE PART. THE CONTACT STATED THAT A HOLE WAS BURNED IN THE DRIVER'S SEAT NEAR THE CONSOLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND WAS NOT ABLE TO SPECIFY WHEN THE PART WOULD BE SUPPLIED TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11132702

Incident

Dec 20, 2017

TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 17V820000 (SEATS). THE CONTACT STATED THAT THE MANUFACTURER FAILED TO REPAIR THE VEHICLE WITHIN A REASONABLE AMOUNT OF TIME. THE DEALER (JOHN GREENE CHRYSLER/JEEP/DODGE, 910 JAMESTOWN ROAD, MORGANTON, NC 28655) CONFIRMED THAT PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT ALSO STATED THAT THE FRONT PASSENGER SEAT CAUGHT FIRE IN FEBRUARY OF 2017. THE FIRE WAS EXTINGUISHED BY THE DRIVER. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11122094

Incident

Dec 18, 2017

TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE SEAT HEATERS WERE TURNED ON. AFTER THE PASSENGER EXITED THE VEHICLE, THE PASSENGER STATED TO THE CONTACT THAT THE SEATS WERE VERY HOT. THE CONTACT STATED THAT THE PASSENGER SEAT STARTED TO SMOKE AS THE VEHICLE WAS DRIVEN 25 MILES TO THE FIRE STATION WHERE THE FIRE WAS EXTINGUISHED AND THE CONTACT WAS INFORMED THAT THE FIRE STARTED IN THE SEAT. THE CONTACT WAS ABLE TO DRIVE TO THE DEALER BRICKNER'S OF ANTIGO INC. (123 E HIGHWAY 64, ANTIGO WI 54409) WHERE IT WAS DIAGNOSED THAT A FUSE FOR THE HEATED SEATS WERE TURNED OFF. THE NEXT DAY THE CONTACT DROVE THE VEHICLE BACK TO THE SAME DEALER FOR AN OIL CHANGE AN AT THAT TIME WAS INFORMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V820000 (SEATS) AND THAT THE VEHICLE COULD NOT BE REPAIRED BECAUSE THE PARTS FOR THE RECALL WERE DISCONTINUED. THE MANUFACTURER WAS ALSO CONTACTED AND WAS UNABLE TO PROVIDE ANY FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 195,000. *TT *JS *TT

NHTSA ID

11081544

Incident

Feb 1, 2018

Mileage

195,000 mi

I HAVE A 2005 DODGE DAKOTA WITH LEATHER SEATS. I TURNED ON BOTH DRIVER AND PASSENGER HEAT TO THE SEATS DROVE ABOUT TWO MILES TO DROP MY CHILD OFF TO SCHOOL. WHEN I GOT BACK HOME I NOTICED A BURN HOLE AND MELTED LEATHER AROUND THE HOLE. I HAVEN'T USED IT SINCE.

NHTSA ID

11063204

Incident

Jan 3, 2018

Mileage

137,000 mi

TURNED ON PASSENGER SEAT WARMER TO KEEP A MEAL WARM IN A WHITE FOAM FOOD CONTAINER. 5 MINUTES LATER WHEN I ARRIVED AT HOME THE BOTTOM OF THE CONTAINER HAD A MELTED HOLE IN IT. THE SEAT WAS EXTREMELY HOT TO THE TOUCH IN ONE SPOT ON THE SEAT. THE REST OF THE SEAT BOTTOM AND BACK WERE NOT WARM AT ALL. SEVERAL DAYS LATER MY WIFE TURNED THE SEAT WARMER ON TO LOW AND WITHIN A COUPLE OF MINUTES SHE EXCLAIMED THAT THE SEAT WAS BURNING HER BOTTOM. WE SHUT THE SEAT WARMER OFF AND THE SEAT BEGAN TO COOL DOWN. THE SEAT WARMER HAD WORKED JUST FINE BEFORE THESE INCIDENTS. IT COULD HAVE SERIOUSLY BURNED MY WIFE IF COULD GET HOT ENOUGH TO MELT A FOAM FOOD CONTAINER. BOTH TIMES THE TRUCK WAS PARKED AND TRAVELING. TOP SPEED WAS 30ISH.

NHTSA ID

11063081

Incident

Nov 15, 2013

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED THAT THE DRIVER'S SIDE HEATED SEAT OVERHEATED WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.

NHTSA ID

11058365

Incident

Nov 10, 2017

Mileage

56,000 mi

I WAS PICKING UP MY BOYS FROM SCHOOL WHEN I SMELLED SOMETHING BURNING. THEN I SAW SMOKE COMING FROM MY DRIVERS SIDE SEAT. I TURNED OFF THE HEAT TO THE SEAT. WHEN I GOT OUT OF THE TRUCK, THERE WAS A BURN MARK IN THE SEAT AND ON MY JACKET.

NHTSA ID

11054920

Incident

Dec 14, 2017

Mileage

158,580 mi

SEAT HEATER MALFUNCTION, CAUSING SMALL FIRE AND HOLE MELTED INTO THE SEAT.

NHTSA ID

11053314

Incident

Nov 10, 2017

Mileage

45,000 mi

TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED THAT THE WIRING INSIDE THE DRIVER'S SEAT CUSHION BURNED HOLES IN THE FABRIC. THE VEHICLE WAS TAKEN TO RAIRDONS CHRYSLER DODGE OF KIRKLAND (12828 NE 124 TH ST KIRKLAND, WA 98034), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND SENT A SPECIAL INVESTIGATOR, BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 81,000. UPDATED 10/26/17*LJ UPDATED 10/30/2017*JS

NHTSA ID

11014026

Incident

Apr 1, 2017

Mileage

81,000 mi

HEATED SEAT ELEMENT BURNED SEAT FOAM. FOUND SAME BEFORE IT COULD COMPLETELY BURST INTO FLAMES. SAME DID MELT HOLE IN THE FOAM AND SCORCH THE SEAT COVERING.

NHTSA ID

10840099

Incident

Jan 6, 2016

Mileage

85,900 mi

HAD DRIVER SIDE HEATED SEAT TURNED ON LOW AND THE SEAT CAUGHT ON FIRE. LUCKILY I HAD NOT LEFT BECAUSE I FORGOT MY LIST INSIDE AND WENT INSIDE HOUSE. WHEN I CAME BACK OUT THE SEAT WAS SMOKING SO I RAN IN AN GOT SOME WATER TO POUR ON SEAT. IT PUT THE FIRE OUT. FIRE DEPT. CAME OUT AND THEY TOOK A PICTURE AND PULLED THE FUSE OUT.

NHTSA ID

10811314

Incident

Dec 20, 2015

Mileage

148,557 mi

WHILE DRIVING AT 10 MPH, THE DRIVER SIDE SEAT HEATER BURNED THROUGH THE SEAT AND THE DRIVERS COAT LEAVING BURN MARKS. *TR

NHTSA ID

10715383

Incident

Apr 15, 2015

Mileage

72,000 mi

WHILE DRIVING, MY DAUGHTER SMELLED SOMETHING BURNING AND PULLED OVER TO INVESTIGATE. SHE NOTICED THE COAT SHE WAS WEARING WHILE DRIVING WAS SMOKING AND WAS SCORCHED AT THE BOTTOM. SHE THEN NOTICED THE DRIVERS SEAT WHERE SHE WAS SITTING WAS ALSO SCORCHED AND HAD BURNED A HOLE THROUGH THE FABRIC OF THE SEAT. SHE STATED SHE HAD THE HEATED SEAT TURNED ON HIGH AT THE TIME. ON SEVERAL OCCASIONS, I HAVE FELT A BURNING SENSATION TO MY RIGHT BUTTOCK WHILE DRIVING AND JUST TURNED THE SEAT HEATER OFF NOT THINKING ANY FURTHER THAT THERE WAS A PROBLEM. *TR

NHTSA ID

10673087

Incident

Jan 14, 2015

Mileage

32,000 mi

THE DRIVERS SEAT BACK WILL NOT STAY IN POSITION AND WILL GO IN A TOTAL RECLINE POSITION AT ANY TIME.THE LOCKING SYSTEM WILL NOT HOLD. THIS COULD BE A PROBLEM IF IT SUDDENLY LETS GO WHILE DRIVING. *TR

NHTSA ID

10637991

Incident

Sep 22, 2014

Mileage

71,000 mi

TL* THE CONTACT OWNS A 2005 DODGE DAKOTA. THE CONTACT STATED THE FOUR WHEEL SYSTEM DISENGAGED ON ITS OWNS WHILE DRIVING AT UNKNOWN SPEEDS. THE DOORS MALFUNCTIONED AND LOCKED AND UNLOCKED WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 140,000. THE APPROXIMATE CURRENT MILEAGE WAS 150,000.

NHTSA ID

10598554

Incident

Jan 1, 2014

Mileage

140,000 mi

VEHICLE WAS PARKED AND RUNNING, HEATED SEATS WERE ON, DRIVERS SIDE SEAT STARTED SMOKING, BURNING A BROWN MARK IN SEAT. *TR

NHTSA ID

10574865

Incident

Mar 15, 2014

Mileage

152,000 mi

DRIVER'S SEAT HEATER SHORTED/OVERHEATED TO CAUSE BURNING AND CHARRING OF THE SEATS MATERIALS, INCLUDING A COAT I WAS WEARING. *TR

NHTSA ID

10559594

Incident

Jan 7, 2014

Mileage

126,000 mi

DRIVING HOME FROM WORK ON A COLD MORNING AND TURNED ON THE HEATED SEAT. TILL I GOT HOME THE BACK OF THE SEAT HAD A HOLE IN IT FROM THE HEATING ELEMENT AND IT ALSO BURNED A HOLE IN MY BIG WINTER COAT...I CONTACTED THE DEALER AND MADE THEM AWARE OF THIS....NO HELP THERE....THERE WAS NO RECALL FOR THIS ISSUE...WHAT IF MY GRANDCHILD WAS SITTING IN THAT SEAT? I ONLY LIVE 8 MILES FROM MY PLACE OF EMPLOYMENT..IT GOT THAT HOT THAT DARN FAST!!!!!!!! *TR

NHTSA ID

10510480

Incident

Apr 21, 2011

Mileage

75,000 mi

VEHICLE WAS PARKED UNDER THE CARPORT, WAS NOT RUNNING, KEYS WERE NOT IN THE IGNITION. IT HAD BEEN PARKED APPROXIMATELY 2 1/2 HOURS WHEN SON IN LAW HAPPENED TO COME OVER AND SAW THE INSIDE OF THE TRUCK FULL OF SMOKE. HE OPENED THE DOOR AND DETERMINED THAT THE PASSENGER SEAT WAS THE SOURCE OF THE SMOKE AND THE INSIDE OF THE SEAT WAS BURNING. THE SEAT WAS FULLY DESTROYED, BUT THE FIRE WAS ABLE TO BE PUT OUT BEFORE ANY FURTHER DAMAGE OCCURED. HAD THIS NOT BEEN DISCOVERED WHEN IT WAS, THE ENTIRE VEHICLE COULD HAVE BEEN DESTROYED, ALONG WITH THE CARPORT AND POSSIBLY THE ENTIRE HOME. *TR

NHTSA ID

10501291

Incident

Mar 1, 2013

Mileage

62,000 mi

DRIVERS SIDE HEATED SEAT CAUGHT ON FIRE. *TR

NHTSA ID

10496812

Incident

Feb 7, 2013

Mileage

75,000 mi

DRIVER'S SIDE HEATER SEAT BURNT HOLE IN MY SEAT, MY BLUE JEANS AND MY WALLET, WARPED CREDIT CARD. THREE MONTHS AGO, A FRIEND BACKED MY TRUCK OUT OF HIS DRIVEWAY AND WHEN I LEFT HIS HOUSE, I NOTICED A HOLE IN THE BACK SEAT COVER. I BLAMED HIM FOR BURNING A HOLE IN MY SEAT SINCE HE IS A SMOKER. I HAVE NOTICED THAT LATELY MY SEAT HAD BEEN GETTING AWFUL "HOT" BUT NEVER THOUGH IT MIGHT BE BURNING. THEN, TUES JAN 22, I GOT OUT OF MY TRUCK AND NOTICED THE HOLE BURNT IN THE BOTTOM CUSHION. I HAVE SPENT THE PAST WEEK TALKING WITH THE DEALER AND CHRYSLER ABOUT IT SINCE IT IS A SAFETY ISSUE. CHRYSLER IS WILLING TO HELP ME OUT 50% COST. WHAT I AM FINDING OUT IS THAT THE DEALER ARTIFICIALLY INFLATES THE COSTS SO THAT IN REALITY, IT REALLY WON'T COST CHRYSLER A DIME. OBVIOUSLY, THIS HAS BEEN GOING ON FOR SOME TIME. THE PROBLEM WITH THE NHTSA IS THAT THESE ISSUES ARE MINOR TO THEM IN THE BIG PICTURE OF THINGS PERCENTAGE WISE - SO THEY IGNORE IT. BUT TO THE CONSUMER, IT IS MAJOR. IF THE NHTSA WAS SMART OR REALLY ON TOP OF THINGS - THEY WOULD LOOK AT THE OVERALL NUMBERS OF THE CAR COMPANY AND THEY WOULD FIND THAT THE CHRYSLER CORP. HAS HAD TROUBLE WITH THEIR HEATED SEATS FOR OVER A DECADE. ALL THEIR BRANDS. RECALL ON JEEP GR CHEROKEE 2001-2004 ; SEBRING; TOWN & COUNTRY; DODGE/RAM TRUCKS. WHY DOES NHTSA NOT CARE ABOUT THE INDIVIDUALS IN THESE CASES. THERE WAS A PARALYZED MAN THAT HAD HIS SEAT ACCIDENTALLY TURNED ON - HE ENDED UP WITH THIRD DEGREE BURNS ON HIS THIGH ABOUT THE SIZE OF A QUARTER. I WOULD SAY THAT THE NHTSA NEEDS TO DO SOME HOMEWORK ON CHRYSLER AND EXERCISE A RECALL ON ALL OF THESE HEATED SEAT ELEMENTS. HOW MANY PEOPLE NEED TO SUFFER? WHY IS EVERYTHING BASED ON NUMBERS?? DOES ANYONE IN THIS WORLD CARE ABOUT THE INDIVIDUALS BEING HARMED??IN MY OPINION, YOU ARE FAILING TERRIBLY BY NOT GOING AFTER THE CHRYSLER CORP. FOR THEIR NEGLECT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10494871

Incident

Jan 22, 2013

Mileage

133,200 mi