2011 Dodge Durango Recalls

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

In response to this investigation, Fiat Chrysler Automobiles (FCA) is conducting a recall to address headliner fires that occur post 14V-391.On December 22, 2015 FCA notified the Office of Defects Investigation (ODI) of safety recall 15V-879 to remedy potential headliner fires occurring in 389,252 model year (MY) 2011-2013 Dodge Durango and Jeep Grand Cherokee vehicles manufactured from December 3, 2009 to September 1, 2012.Note this recall, which was scoped based on vehicle design level and field events, does not include all MY 2013 or any MY 2014 Durango and Grand Cherokee vehicles; ODI and FCA will continue to monitor the field experience for this population.ODI opened this investigation based on allegations of fires occurring in the headliner area after the remedy for recall 14V-391 had been conducted.Recall 14V-391 involved MY 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured by FCA from January 5, 2010 to December 11, 2013.The recall was influenced by ODI investigation EA14-001.During EA14-001, data provided by FCA indicated fires were caused by an electrical short in the vanity lamp wiring for either visor.Visors are mounted to the (metal) roof of the vehicle through the headliner with three screws. EA14-001 determined it was possible for the wiring to be pierced or abraded by one of the screws, or otherwise become electrically shorted either during initial vehicle assembly or subsequent headliner area repairs presenting a fire risk.Most of the fires occurred while the vehicle was being driven.The 14V-391 remedy consisted of installing a plastic guide way on each visor to route wiring away from the attachment screws and prevent electrical shorting.Additionally abrasion resistant tape was installed in key areas to protect the wiring integrity.In order to install the guide, the headliner had to be lowered and the existing visor and headliner wiring rerouted, a somewhat complex procedure that required sufficient service technician care and expertise.FCA modified the 14V-391 remedy multiple times to improve it.ODI has identified a total of 43 NHTSA complaints across affected vehicles indicating a fire occurring after the vehicle had been remedied under 14V-391.FCA reported 159 additional unique complaints of post-remedy fires. The fire events primarily occurred while driving however a few reported fires starting after the vehicle was parked. Ten customers incurred injuries including minor burns and smoke inhalation, no crashes were reported.According to FCA, the vehicles recalled under 15V-879 were manufactured with longer wiring connecting the visors to the main harness in the headliner.Field experience clearly shows these vehicles are experiencing more post 14V-391 fires, 189 out of 202 known incidents to date.Recall 15V-879 addresses any remaining risk of fire after the 14V-391 recall remedy is performed.The 15V-879 remedy installs new design level visor assemblies containing added wire sheathing, shortened wiring, revised wiring retainer and wiring loop relief.In addition, part of the metal structure (body in white) where the wiring is routed will be modified (removed) using a template to allow more clearance.The recall action initiated by the vehicle manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at SaferCar.gov under the following identification (ODI) numbers:10640524, 10653417, 10684130, 10691520, 10692710, 10703058, 10705802, 10711836, 10715282, 10717265, 10717266, 10723677, 10726438, 10733003, 10733598, 10735042, 10743410, 10744097, 10745129, 1

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den

On July 1st, 2014 Chrysler Group LLC (Chrysler) notified the Office of Defects Investigation (ODI) that it would conduct a safety recall to remedy a wiring-related fire hazard on the headliner of approximately 661,888 model year (MY) 2011-2014 Jeep Grand Cherokee and Dodge Durango vehicles manufactured between January 5, 2010 and December 11, 2013 (see NHTSA Safety Recall 14V-391), with notifications to begin in August 2014. According to Chrysler, the fire is caused by an electrical short in the vanity lamp wiring for either one of the sun visors mounted on the vehicle. The sun visors are mounted to the roof of the vehicle through the headliner with three metal screws. It is possible for the sun visor wiring to be pierced by one of these screws either during initial vehicle assembly or later headliner area repairs which may cause an electrical short potentially resulting in fire.ODI opened an investigation involving MY 2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles based on consumer reports of headliners catching fire at the front of the passenger's compartment near the sun visors. Complainants reported failure symptoms that ranged from discoloration to open flame burning of the headliner and/or sun visor material. Complainants reported a burning plastic smell and smoke from the headliner, often occurring while the vehicle was in motion. Damage ranged from a small burn spot on the headliner to a near complete burn of the vehicle resulting in a total loss; sunroof damage/glass shattering occurred in some cases. Incidents are more likely to occur when the ignition key is in the on position.However, several vehicles continued to burn after the key was turned off, and key-off fires, while highly unlikely, cannot be fully eliminated as a potential problem. The earliest incidents chronologically were often associated with vehicle assembly or in-plant repair procedures. Chrysler revised assembly and in-plant repair procedures for the headliner which reduced the number of fields incidents.However, anytime a repair is made to the headliner of the vehicle there could still be a risk of shorting the wiring and creating a hazard.Dealership technicians will inspect the vehicles for damaged wiring caused by an improper service procedure and repair any damage. Also, all vehicles will have a plastic guideway installed on each sun visor that routes the wiring away from the attachment screws preventing the wiring from being shorted. All MY 2011-2014 Grand Cherokee and Dodge Durango built before December 11, 2013 are affected by the recall; vehicles manufactured after this date had the guideway installed during vehicle production.ODI received a total of 6 complaints as of June 2014, all of which reported a fire and two of which alleged related injuries. All 6 incidents occurred while the vehicle was being driven. In each case the driver smelled smoke and witnessed the headliner burning on either the driver or passenger side. Two complaints indicate smoke inhalation injuries to the driver. In response to ODI's information request letters of 8/28/2013 and 2/26/2014, Chrysler provided consumer and warranty data which was received by ODI on 10/7/2013 and 3/19/2014. Analysis of the Chrysler data indicated a total of 91 unique incidents related to the investigation of which about two thirds reported an open flame and smoke, the remaining showed only small burn marks with no visible flame. Three Chrysler reports indicated injuries consisting of minor burns on the customer?s hands and smoke inhalation.The investigation is closed on the basis of the recall action the manufacturer has undertaken which is sufficient to address NHTSA?s con

The Office of Defects Investigation (ODI) has identified 5 reports of vehicle headliners catching fire at the front of the vehicle near the sun visors on Jeep Grand Cherokees.Customers reported a range of fire conditions ranging from minor overheating to an open flame at the headliner and/or sun visor material while driving the vehicle. In some reports the fire spread to the front seats and/or door panels of the vehicle.In one report, the sunroof was damaged causing the glass to shatter.The cause of these fires is an electrical short in the vanity lighting wiring circuit that is routed to either one of the sun visors.The sun visors are mounted to the roof of the vehicle through the headliner with three screws.The sun visor wiring may be penetrated, or pierced by one of these screws either during initial vehicle assembly or subsequent headliner area repairs.The piercing causes an electrical short that could result in a fire.There is no dedicated fuse for the affected circuit so the electrical short can continue until the short clears or the vehicle is keyed off.The Dodge Durango uses the same headliner assembly, and Chrysler indicates there are similar headliner fire incidents affecting this model. Therefore, these vehicles have been added to the scope of the investigation.Analyzing the data received from Chrysler along with ODI reports indicates there may be a total of 52 unique fire incidents (including 3 injury allegations) on Grand Cherokee and Durango vehicles which ODI will continue to evaluate during the investigation.Based on ODI's evaluation of currently available data, this investigation is being upgraded toEngineering Analysis EA14-001.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10536895, 10556110, 10522665, 10522159, 10515592