2006 Dodge Grand Caravan Problems

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD NOISES COMING FROM THE STEERING COLUMN. THE CONTACT DROVE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE VIN WAS INCLUDED IN AN UNKNOWN RECALL; HOWEVER, NO RECALL WAS FOUND. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000.

WHEN DRIVING IN RAINY CONDITIONS (NOTE: WET ROAD, NOT HIGH WATER), POWER STEERING FAILED AND VAN WAS UNCONTROLABLE. THIS HAS HAPPENED 2X IN THE PAST YEAR. DEALERSHIP SAYS THIS IS A COMMON ISSUE WITH THIS MODEL, AS WATER CAN GET TO THE POWER STEERING BELT. THEY OFFERED NO SOLUTION. I NEARLY RAN INTO A DITCH AS I WAS UNABLE TO STEER. THANKFULLY I WAS ABLE TO STOP THE CAR WITHOUT CAUSING AN ACCIDENT, BUT THIS WAS A DANGEROUS SITUATION. BOTH TIMES THIS HAPPENED I WAS DRIVING ON A CITY STREET IN RAINY CONDITIONS.

The contact owns a 2006 Dodge Grand Caravan. The contact stated that on several occasions, the air bag warning light illuminated for two minutes and then disappeared. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 146,032.

LIGHTS GO OUT WHEN THE RAIN GETS UP UNDER THE CAR FROM SPLASHING ON THE ROAD. YOU HAVE TO PULL OVER TO THE SIDE OF THE ROAD, TURN IT OFF AND TURN IT BACK ON SEVERAL TIMES AND IT STAYS ON FOR A SHORT TIME. PROCEDURE IS REPEATED AGAIN. ONLY IN RAINY WEATHER AND OREGON GETS A LOT OF SPORADIC RAIN. ALSO, THE IGNITION TENDS TO TURN THE AIRBAG LIGHTS ON AND OFF WHENEVER I TURN A CORNER LEFT OR RIGHT OF HIT A BUMP.

The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact stated that one of the windows failed to roll down. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

THE REAR POWER LIFT GATE ON MY 2006 DODGE GRAND CARAVAN DOES NOT STAY OPEN WHEN LOADING OR UNLOADING ITEMS BUT KEEPS CONTINUALLY CLOSING HARD AUTOMATICALLY WHEN NEEDING TO HAVE IT STAY OPEN TO ALLOW FOR LOADING OR UNLOADING. THIS HAPPEN WHETHER ONE TRIES TO OPEN THE DOOR USING THE HANDLE MANUALLY OR AUTOMATICALLY WITH THE KEY FOB. THIS HAS HAPPENED OVER THE LAST 3 OR 4 YEARS ESPECIALLY DURING WINTER BUT NOT CONFINED TO WINTER ONLY. MY GRANDSON AND MYSELF ALMOST GOT CAUGHT MORE THAN ONCE AND INJURED IN ITS UNEXPECTED DOWNWARD FREE-FALL. THIS IS VERY DANGEROUS TO ANYONE TRYING TO ACCESS THE BACK PORTION OF THE VAN AS THE HEAVY LIFT GATES CLOSES ON THEM TRAPPING THEM AND CAUSING POTENTIAL SERIOUS INJURY. THIS HAPPENS WHEN VEHICLE IS STATIONARY AND IN THE GARAGE OR STATIONARY IN A SHOPPING PARKING LOT WHEN LOADING GROCERIES OR OTHER PURCHASES. OR WHEN PUTTING THE REAR SEATS UP OR DOWN TO UTILIZE BACK PORTION OF VAN. SOMEONE CANNOT HOLD THE LIFT GATE OPEN WHEN ANOTHER IS TRYING TO ACCESS THE BACK OF THE VAN AS THE LIFT GATE FALLS HARD AND CANNOT BE STOPPED. THERE ARE CURRENTLY 93,360 MILES DRIVEN.

DRIVER SIDE SLIDING DOOR STUCK IN LOCKED POSITION. UNABLE TO UNLOCK USING DOOR LOCK SWITCH, UPPER CONSOLE DOOR SWITCH, KEY FOB OR MANUALLY. PASSENGER STUCK AND HAD TO CRAWL OUT DIFFERENT DOOR.

SLIDING DOOR LOCK ACTUATOR FROZE UP. THIS RENDERS THE SLIDING DOOR COMPLETELY INOPERABLE. IF THAT DOOR WAS NEEDED FOREGRESS, IT WOULDN'T BE AVAILABLE.

The contact owns a 2006 Dodge Grand Caravan. The contact stated that when the vehicle was purchased in 2010, the vehicle was missing the EGR (Exhaust Gas Recirculation) valve. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle idled roughly, jerked and stalled while driving. The check engine warning light was illuminated. The vehicle was taken to Auto Zone, where it was diagnosed with power train failure. The vehicle was taken to the dealer, where the contact was informed that the vehicle was missing the Exhaust Gas Recirculation (EGR) valve. The contact was provided DTCs: P0403 and P0404. The vehicle was not repaired. In 2019, the vehicle was taken to a tire business and the EGR valve was installed on the vehicle. The failure was progressively worsened, and the vehicle was no longer being driven. Upon further investigation, the contact found information on various auto websites indicating that the vehicle was manufactured in Canada and imported to the United States. The contact was the second owner. The contact found information on other auto websites that stated that the EGR valve was removed from the vehicle, and it was removed in stages. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The failure mileage was approximately 122,000.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 45 MPH, THE OIL PRESSURE AND AN UNKNOWN WARNING INDICATOR ILLUMINATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THE FAILURE COULD NOT BE DUPLICATED. ON NOVEMBER 9, 2019, WHILE DRIVING 55 MPH, WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS LOSING SPEED, BUT WAS ABLE TO BE PULLED OVER TO THE SIDE OF THE ROAD. IN ADDITION, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE CONTACT CALLED THE POLICE DUE TO HER DISABLED HUSBAND BEING IN THE COLD FOR OVER TWO HOURS. A POLICE REPORT WAS FILED. HE WAS TRANSPORTED TO THE HOSPITAL, BUT THERE WERE NO INJURIES OR MEDICAL ATTENTION NEEDED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO AN INDEPENDENT MECHANIC. THE CONTACT WAS INFORMED THAT THERE WAS AN OIL LEAK IN THE ENGINE AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

UNABLE TO FILL WITH GAS AT SERVICE STATION (EVAPORATIVE SISTEM). THE NOZZLE KEPT SHUTTING OFF EVEN THOUGH THE TANK WAS NEARLY EMPTY.

I'VE TAKEN THE VEHICLE TO PEPBOYS TWICE BECAUSE ALTHOUGH THE GAS GAUGE WAS WORKING, THE VEHICLE WOULD CLICK THE GAS NOZZLE OFF AND WOULD NOT ACCEPT FUELING. PEPBOYS REPLACED THE IN-TANK PUMP AS A REMEDY TWICE. DODGE/CHRYSLER SAID IT WAS THE BREATHER TUBE. WHO'S RIGHT?

The headlights and taillights come on randomly throughout the day and night while the car is parked and off. The warning dings for accidentally leaving your lights on happens every time you open the doors even though the lights are off. This has been going on since we got the vehicle.

LIGHTS GO OUT WHEN THE RAIN GETS UP UNDER THE CAR FROM SPLASHING ON THE ROAD. YOU HAVE TO PULL OVER TO THE SIDE OF THE ROAD, TURN IT OFF AND TURN IT BACK ON SEVERAL TIMES AND IT STAYS ON FOR A SHORT TIME. PROCEDURE IS REPEATED AGAIN. ONLY IN RAINY WEATHER AND OREGON GETS A LOT OF SPORADIC RAIN. ALSO, THE IGNITION TENDS TO TURN THE AIRBAG LIGHTS ON AND OFF WHENEVER I TURN A CORNER LEFT OR RIGHT OF HIT A BUMP.

SLIDING DOOR LOCK ACTUATOR FROZE UP. THIS RENDERS THE SLIDING DOOR COMPLETELY INOPERABLE. IF THAT DOOR WAS NEEDED FOREGRESS, IT WOULDN'T BE AVAILABLE.

THE AUTOMATIC DOOR LOCKS ARE JAMMED ON BOTH SIDES OF THE VEHICLE AND WILL NOT UNLOCK EVEN MANUALLY. WHILE THIS MAY SEEM LIKE A MINOR ISSUE, IF WE WERE TO END UP IN AN ACCIDENT WITH NO WAY FOR MY 5 CHILDREN TO EXIT THE VEHICLE EXCEPT THROUGH THE FRONT 2 DOORS, IT WOULD BE A HUGE SAFETY ISSUE. I UNDERSTAND THAT THE AUTOMATIC LOCKS OCCASIONAL MALFUNCTION, THERE SHOULD BE A SAFETY MECHANISM THAT AT LEAST ALLOWS FOR IT TO OPERATE MANUALLY BUT THIS IS NOT THE CASE. I RESEARCHED ONLINE AND ON MANY SITES THERE ARE OTHERS WITH THE SAME ISSUE. I CALLED CHRYSLER TO ISSUE A COMPLAINT AND THEY REFERRED ME HERE. *TR

The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact stated that one of the windows failed to roll down. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

THIS VEHICLE HAS A STALK ON THE STEERING COLUMN THAT CONTROLS THE WINDSHIELD WASHER, WIPER, AS WELL AS THE VEHICLE BRIGHT LIGHTS, AND THE TURNING SIGNALS. AROUND MAY. 2014 THE WASHER BEGAN WORKING INTERMITTENTLY. SOMETIMES IT WOULD WORK, SOMETIMES NOT. WIGGLING THE STALK WOULD SOMETIMES MAKE IT WORK. BY PULLING THE STALK TOWARD THE DRIVER, THE BRIGHT LIGHTS ARE SUPPOSE TO COME ON TEMPORARILY, UNTIL RELEASED. THEY STOPPED WORKING, ALSO ABOUT MAY, 2014. IT IS STILL WORKING INTERMITTENTLY, BUT NOW THE TURNING SIGNALS ARE ALSO AFFECTED, WORKING INTERMITTENTLY, OR EVEN PUTTING ON THE LEFT TURN SIGNAL, WHEN THE SWITCH IS TURNED FOR A RIGHT TURN, OR RIGHT FOR LEFT. I AM AFRAID THAT THIS SWITCH IS DEFECTIVE, AND CAN CAUSE AN ACCIDENT IF IT DOES NOT WORK RELIABLY.

My complaint involves more than one incident...it is the braking system on this vehicle. One incident was in Panama City Beach, Florida. My entire braking system locked up and I had numerous items replaced. Another more recent incident happened in Alabama. My left front brake heated up to the point it smelled like the vehicle was on fire. I have had several calipers and rotors replaced, numerous brake pads and not all of these repairs has been done by the same garage. I read complaints from others about the manufacturers brake system is too small for this style vehicle. They have experienced the same problems I have had. I bought this vehicle in 2015 and I have 155,000 miles on it. I have had to replace a water pump and spark plugs and wires, regular oil changes, etc. The only real problem I have had has been the brakes. I have spent almost $3,500 on brakes alone. I would think the braking system could be a very hazardous situation in the traffic of today. Please help me and others who are experiencing this problem with the braking systems on the 2006 Dodge Grand Caravans. Thank you.

TAKATA RECALL 1. THE KEY FOB, AUTOMATICALLY CONTROLLED REAR DOOR HATCH DOES NOT STAY OPEN WHEN USING THE KEY FOB OR MANUALLY OPENING THE HATCH DOOR. IT HAS CLOSED NEARLY UPON MYSELF - THE OWNER, AND OTHERS - WITHOUT WARNING WHEN STOPPED, MOTOR OFF AND LOADING OR UNLOADING ITEMS. THERE IS NO WAY TO ASSESS WHAT CAUSED THIS AS IT GETS BELOW NORMAL WEAR. SINGLE PARTY USE, NO KIDS. THIS INCIDENCE STARTED 12/12/2016 2. THE FRONT BRAKES MAKE A SCRAPING NOISE AND WOBBLING OF STEERING WHEEL UPON COMING TO A STOP. THIS WAS MENTIONED TO THE DEALER EARLIER THIS YEAR AND BRAKES, PADS AND ROTORS WERE CHECKED AT DEALER, AND IT WAS STATED THAT NOTHING WAS WRONG. NEW BRAKE PADS WERE INSTALLED IN 2013. THE CAR MILEAGE IS 85241 MILES. THE WHEELS HAVE BEEN ROTATED, ALIGNED. THE CAR HAS REGULAR, ROUTINE MAINTAINANCE, THE BRAKES STILL SCRAPES AND WOBBLES THE STEERING WHEEL. THIS HAS BEEN A RECURRING INCIDENCE.

I TURNED INTO A DRIVE WAY AND THE CAR LOST CONTROL. BREAKS LOCKED AND I WOULDN'T STOP

VAN STALLS AFTER FILLING THE GRAND CARAVAN WITH FUEL. LOSES STEERING AND SPEED. *TR

TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE THE VEHICLE WAS STOPPED, THE VEHICLE WOULD NOT MOVE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT PRESSED HARDER BUT THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE FAILURE COULD NOT BE DIAGNOSED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM TO TAKE THE VEHICLE TO A LOCAL DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE OCCURRED THREE TIMES SINCE OCTOBER 2010. THE FAILURE MILEAGE WAS 68,000.

I HAVE BEEN TOLD BY A DODGE DEALERSHIP THAT THE FOLLOWING IS WRONG WITH MY CAR AND I NEED THE FOLLOWING: - ERG VALVE - WATER PUMP - POWER STEERING RACK - RACK & PINION EVEN THOUGH THE CAR RUNS FINE AND DOES NOT SHAKES OR ANYTHING. AFTER DOING SOME RESEARCH ONLINE I FOUND AT A WEBSITE, WWW.EDMUNDS.COM, REVIEWS FROM MANY OTHER OWNERS OF ALSO A 2006 DODGE GRAND CARAVAN TO BE HAVING THE SAME PROBLEMS THAT I AM HAVING. SOME OF THEM HAVE LOW MILEAGE ON THEIR CARS AND OTHERS HAVE HIGH MILEAGE. IT IS TOO MUCH OF A COINCIDENCE THAT SO MANY PEOPLE ARE HAVING THE SAME PROBLEMS ON THEIR 2006 G. CARAVAN. SEEMS TO ME THAT THERE IS A PROBLEM WITH THE 2006 LINE AND IF THIS IS THE CASE IS SOMETHING DODGE NEEDS TO FIX AND COVER THE REPAIR COSTS AND NOT THE OWNERS. ALSO THE REPAIRS TOTAL COST ARE TOO MUCH MONEY AT THIS MOMENT TO AFFORD. *TR

I HAD SUSPENSION WORK COMPLETED ON MY VEHICLE (INNER/OUTER TIE RODS, RACK AND PINION AND CONTROL ARMS REPLACED BY A SHOP) AFTER DRIVING BACK TO TEXAS I NOTICED BOTH FRONT TIRES WERE EXTREMELY WORN AND WAS CLOSE TO A BLOW OUT. I CONTACTED THE SHOP ABOUT IT AND THEY REFUSED TO WORK WITH ME. AFTER TAKING MY VEHICLE TO A LOCAL REPAIR SHOP THE MECHANIC STATED THAT THE ALIGNMENT APPEARED TO NOT HAVE BEEN DONE AND THAT THE SPECS WAS OFF THE CHARTS. THE MECHANIC CONTACTED THE SHOP THAT MADE THE INITIAL REPAIRS AND THEY DENIED NOT COMPLETING AN ALIGNMENT. I'VE HAD THIS VEHICLE FOR OVER 11 YEARS AND MY TIRES HAVE NEVER WORN THIS FAST AND IT DIDN'T HAPPEN UNTIL THIS REPAIR SHOP DID THE SUSPENSION WORK ON MY VEHICLE. THE SHOP NEEDS TO BE INVESTIGATED FOR UNSAFE MAINTENANCE PRACTICES. THEIR MAINTENANCE AND LACK OF SAFETY STANDARDS PUT THE SAFETY OF MY FAMILY IN JEOPARDY, AND THEY'RE STILL IN DENIAL OF ANY WRONG DOING NOR ARE THEY WILLING TO PROVIDE ME SPECS OF THE ALIGNMENT THEY SAID THEY DID. PHOTOS ARE ATTACHED.

WHILE DRIVING ON BUSY URBAN HIGHWAYS WITH LIMITED OR NO SHOULDER, THE VEHICLE STARTED MAKING CLUNKING NOISES, ORIGINATING FROM THE LEFT SIDE, WHEN DRIVING OVER BUMPS, POTHOLES AND OTHER ROAD IRREGULARITIES. NOT WANTING TO PULL OVER IN AN AREA WITH LIMITED SHOULDER LANES, I CONTINUED DRIVING, BUT THE NOISE BECAME PROGRESSIVELY WORSE OVER A PERIOD OF 50 MILES OR SO, TO THE POINT THAT I WAS ACTIVELY SEEKING A SAFE PLACE TO PULL OVER AND CHECK THE VEHICLE. BEFORE I HAD A (SAFE) OPPORTUNITY TO DO SO, A MUCH LARGER CLUNK WAS HEARD, AND THE VEHICLE INSTANTLY EXPERIENCED GREATLY IMPAIRED DIRECTIONAL CONTROL. I IMMEDIATELY SLOWED, AND WAS ABLE TO BRING THE VEHICLE TO A CONTROLLED STOP ON THE SHOULDER. VISUAL INSPECTION IMMEDIATELY SHOWED THAT THE FRONT DRIVER SIDE WHEEL HAD EXCESSIVE NEGATIVE CAMBER. THE STRUT SHAFT WAS ALSO NO LONGER MATED TO THE STEERING BEARING AT THE TOP OF THE STRUT TOWER, AND WAS RESTING AGAINST THE SIDE OF THE STRUT TOWER. THE TOP SURFACE OF THE STRUT SHAFT HAD AN IRREGULAR, ROUGH FEEL TO IT, SUGGESTIVE OF BRITTLE FAILURE. AFTER LIMPING THE VEHICLE DOWN THE NEAREST OFF-RAMP (APPROXIMATELY 1/2 MILE) AT LOW SPEED (10 MPH) I PARKED HE VEHICLE, AND HAD IT TOWED TO A LOCAL PEP BOYS, WHICH REPLACED BOTH FRONT STRUT ASSEMBLIES.

The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact stated that one of the windows failed to roll down. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

WHEN IT RAINS OR THE STREET IS WET THE POWER STEERING RANDOMLY GOES OUT. THE HAPPENS WHEN TURNING OUT OF A DRIVEWAY, TURNING A CURVE OR GETTING OUT OF A PARKING SPACE. IT HAS HAPPENED ON THE ROAD A FEW TIMES, BUT USUALLY HAPPENS JUST AFTER STARTING THE CAR AND BEGINNING TO MOVE. IT ONLY HAPPENS WHEN IT HAS BEEN RAINING OR I GO OVER A LARGE PUDDLE OF WATER. THE PROBLEM HAS BEEN CONSISTENT FOR ABOUT A YEAR. I HAVE DISCUSSED THE PROBLEM WITH THE DEALERSHIP WHERE I PURCHASED THE VAN, CARMAX. THEY HAVE NOT HEARD OF THIS PROBLEM, BUT DID REPLACE AN UNDERCARRIAGE SHIELD. THE PROBLEM CONTINUED AFTER THE SHIELD REPLACEMENT. CARMAX THEN DIRECTED ME TO THIS WEBSITE. *TR

I HAD SUSPENSION WORK COMPLETED ON MY VEHICLE (INNER/OUTER TIE RODS, RACK AND PINION AND CONTROL ARMS REPLACED BY A SHOP) AFTER DRIVING BACK TO TEXAS I NOTICED BOTH FRONT TIRES WERE EXTREMELY WORN AND WAS CLOSE TO A BLOW OUT. I CONTACTED THE SHOP ABOUT IT AND THEY REFUSED TO WORK WITH ME. AFTER TAKING MY VEHICLE TO A LOCAL REPAIR SHOP THE MECHANIC STATED THAT THE ALIGNMENT APPEARED TO NOT HAVE BEEN DONE AND THAT THE SPECS WAS OFF THE CHARTS. THE MECHANIC CONTACTED THE SHOP THAT MADE THE INITIAL REPAIRS AND THEY DENIED NOT COMPLETING AN ALIGNMENT. I'VE HAD THIS VEHICLE FOR OVER 11 YEARS AND MY TIRES HAVE NEVER WORN THIS FAST AND IT DIDN'T HAPPEN UNTIL THIS REPAIR SHOP DID THE SUSPENSION WORK ON MY VEHICLE. THE SHOP NEEDS TO BE INVESTIGATED FOR UNSAFE MAINTENANCE PRACTICES. THEIR MAINTENANCE AND LACK OF SAFETY STANDARDS PUT THE SAFETY OF MY FAMILY IN JEOPARDY, AND THEY'RE STILL IN DENIAL OF ANY WRONG DOING NOR ARE THEY WILLING TO PROVIDE ME SPECS OF THE ALIGNMENT THEY SAID THEY DID. PHOTOS ARE ATTACHED.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE STUDS ON THE WHEELS WERE FRACTURING. THE MECHANIC ADVISED THAT THE STUDS WERE FRACTURED BECAUSE THEY WERE TOO SOFT AND WEAKENED OVER TIME. THE CONTACT CALLED THE MANUFACTURER REGARDING THE STUDS AND THE MANUFACTURER ADVISED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST. THE FAILURE MILEAGE WAS 97,000.

2006 DODGE CARAVANS HAVE A DUMMY SPARE TIRE LOCATED NEAR THE GAS TANK SUBJECT TO ALL WEATHER CONDITIONS AND THEY BECOME DRY ROTTED AND CAN EXPLODE.THERE IS NO PROTECTION COVER THAT PREVIOUS DODGE CARS HAD. I HAD ONE BLOW AS I WAS ABOUT TO USE IT ON THE VAN. I SINCERELY NO ONE HAS ONE BLOW WHILE MOUNTED NEAR THE GAS TANK. *TR

1- PRIOR TO FAILURE WAS JUST DRIVING @ 65MPH ON INTERSTATE 89. CLEAR/CLEAN ROADS. CLEAR SUNNY DAY. THIS TIRE WAS FOUND TO HAVE LOST SOME AIR 2 WEEKS AFTER INSTALL BUT HAD MAINTAINED REGULAR PRESSURE SINCE THEN. PRIOR TO TRAVEL ON DATE OF FAILURE, ALL TIRES WERE INSPECTED AND PSI WAS CHECKED. 2- FAILURE WAS A REAR TIRE BLOW OUT. THIS TIRE WAS ONE OF A FULL SET RECENTLY INSTALLED APPROXIMATELY 3 MONTHS AND 445 MILES EARLIER. BLOWOUT WAS NOT THE RESULT OF RUNNING OVER ANY ROAD HAZARD, BUMP OR OBJECT. ALTHOUGH I UNDERSTAND THE NATURE OF TIRES THIS INCIDENT DISTURBS ME AND THE SAFETY OF THE TIRE IS SUSPECT. SINCE THE TIRE WAS DESTROYED, EVIDENCE OF SIDEWALL FAILURE WAS ABSENT, BUT THE TREADS WERE NOT PUNCTURED OR CUT AND WERE FREE OF ANY FOREIGN OBJECTS. THE BLOWOUT INFLICTED MINOR DAMAGE TO THE PLASTIC WHEEL WELL LINING BY CAUSING A CRACK AND A HOLE MEASURING APPROX 1' X 2". 3- THE TIRE WAS REPLACED WITH A NEW ONE OF THE SAME MODEL. COOPER TIRES REFUSED TO STAND BEHIND THEIR PRODUCT, POINTING OUT THAT THE SIDEWALLS WERE DESTROYED THEREFORE SO WAS ANY EVIDENCE. AFTER SOME RESEARCH I LEARNED THAT COOPER HAS HAD SOME HISTORY OF VERY SIMILAR FAILURES IN THE PAST AND THAT MAY EXPLAIN THE UNWILLINGNESS TO ACKNOWLEDGE THIS AS PREMATURE FAILURE OR TO OFFER ANY KIND OF FINANCIAL ADJUSTMENT OR CUSTOMER SATISFACTION. BESIDES THE LACK OF CONFIDENCE IN THE TIRE AND THE LACK OF CONCERN FROM THE MANUFACTURER, I WORRY THAT THERE IS A SAFETY ISSUE HERE. I AM THANKFUL THAT THERE WAS NO INJURY IN THIS INCIDENT. I AM HOPING THAT THIS COMPLAINT AND MY ADDITIONAL EFFORTS WILL RAISE AWARENESS OF THIS POTENTIAL DANGER AND PROMPT CONSUMERS TO CAREFULLY MONITOR ANY COOPER CS4 TIRES. I URGE ANY CONSUMER WHO MAY HAVE EXPERIENCED AN UNUSUAL OR PREMATURE FAILURE OF ANY COOPER CS4 TIRE TO FILE A COMPLAINT TO ASSIST IN DISCOVERING ANY TRENDS AND PERHAPS AVOID A SERIOUS ACCIDENT. THE TIRE INVOLVED IN THIS FAILURE WAS DISPOSED OF. *JS

TL* THE CONTACT OWNED A 2006 DODGE GRAND CARAVAN. WHILE THE CONTACT'S DAUGHTER WAS DRIVING 35 MPH, SHE CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY AND THE SEAT BELTS DID NOT RETRACT. AS A RESULT, THE CONTACT'S DAUGHTER STRUCK HER HEAD ON THE STEERING WHEEL. A POLICE REPORT WAS FILED. THE DAUGHTER SUSTAINED A HEAD INJURY AND WAS UNCONSCIOUS. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT ALL FOUR REAR SHOULDER SEAT BELTS WOULD NOT SECURE IN THE HOUSING LATCH. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A COMPLAINT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR CONDITIONER BECAME INOPERATIVE AND HAD TO BE REPLACED. THE POWER STEERING RACK ALSO HAD TO BE REPLACED DUE TO A LOUD GRINDING NOISE THAT WAS HEARD COMING FROM THE STEERING COLUMN. IN ADDITION, THE RADIATOR FANS WOULD OVERHEAT AND WERE REPLACED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 4,300 AND CURRENT MILEAGE WAS 58,000.