Owner-reported complaints naming the airbag system, filed with NHTSA
Data refreshed
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights. Every record below is an owner-reported complaint about the 2012 Dodge Grand Caravan submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 18 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
The driver's seat active headrest spontaneously deployed while my wife was operating the van. Luckily this did not cause an accident, but being hit in the back of the head by the headrest certainly can cause an accident in the future. Inspection shows the internal plastic latch mechanism broken, thus the spontaneous, unintentional deployment of the active headrest.
Greenway CDJR in Florence Alabama did the T33 airbag recall on my Grand Caravan. I recently found out while investigating another issue that they had taken a shortcut and the work wasn't properly or thoroughly done. The recall was to correct an issue with exposed wiring and the remedy was to install a protective sleeve. Rather than remove the retaining clip to install the whole length of sleeve they cut the sleeve to fit up to the clip leaving wiring unprotected. Greenway is under new ownership as Singing River CDJR. I contacted the general manager and sent pics and informed him I couldn't put the air bag assembly back in until the work was done. On October 31st this year he said he would have an advisor contact me to schedule an appointment. I haven't been scheduled nor heard back. I fear this has happened to more vehicles than just my own. In addition to not having a driver side airbag now I also don't have a horn as it is part of the assembly. The sleeve is supposed to be 6mm. It was cut short.
SEAT BELT WARNING CHIME IS PERIODICAL ACTIVATED WHILE VEHICLE IS IN MOTION AND SEAT BUCKLE IS ENGAGED.
THE AIR BAG ON THE RIGHT FRONT HAS CAME OUT AND THE FUEL PUMP RELAY IN THE FUSE BOX NEED TO BE UNDER WARRANTY FOR THE DEALER MAKING IT LIKE THAT
2012 DODGE GRAND CARAVAN FRONT PASSENGER HEADREST DEPLOYMENT 4 MONTHS AGO. VEHICLE UNOCCUPIED, IN DRIVEWAY. NO REAR-END IMPACT [OR ANY OTHER] IMPACT OF ANY KIND. DEALERSHIP QUOTES $822 TO REPLACE THE HEADREST, EST. $129 LABOR. I SEE CLASS ACTION LAWSUITS VS. CHRYSLER ALLEGING DEFECTIVE DESIGN OR MATERIALS. NHTSA SHOULD INVESTIGATE THIS SHODDY WORKMANSHIP AND CAVALIER ATTITUDE.
WE WERE DRIVING DOWN A CROWDED HIGHWAY WHEN EVERYTHING ON THE VEHICLE SHUT DOWN. ALL THE LIGHTS SHUT OFF AND WE LOST POWER STEERING. I HAD TO FIGHT MY WAY OVER THREE LANES OF TRAFFIC WITH NO TURN SIGNALS AND HAD NO POWER STEERING. WHEN THIS HAPPENED WE WERE GOING UPHILL AND AN 18 WHEELER WAS BEHIND US. WE WERE RAPIDLY SLOWING DOWN AND COULD HAVE BEEN HIT BY ANOTHER VEHICLE. WE CAME TO A STOP AND PUT THE VEHICLE IN PARK AND IT STARTED RIGHT BACK UP. A FEW DAYS LATER MY WIFE HAD THE SAME THING HAPPEN TO HER WHILE DRIVING ON A DARK ROADWAY. SHE WAS ABLE TO COME TO A STOP ON THE SIDE OF THE ROAD AND RESTART THE VEHICLE. THERE WERE NO OTHER CARS AROUND HER AT THAT TIME. R03/NHTSA 14V-373. RECALLS GRAND CARAVAN YEARS 2008 TO 2010. MY PROBLEMS SOUND AND LOOK EXACTLY LIKE THIS AND SEEING COMPLAINTS AROUND THE INTERNET IT LOOKS LIKE MANY OTHERS WITH MY YEAR MODEL ARE HAVING THE SAME ISSUES. I THINK THAT RECALL NEEDS TO BE EXTENDED TO INCLUDE THE 2012 MODEL YEAR AS WELL.
TL* THE CONTACT STATED THEIR DAUGHTER OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE HER DAUGHTER WAS DRIVING AT VARIOUS SPEEDS WHEN THE VEHICLE'S IGNITION INDEPENDENTLY SHIFTED TO THE OFF POSITION WHICH CAUSED THE VEHICLE TO TURN OFF. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC WHO REPLACED THE ALTERNATOR, STARTER, SENSOR REGULATING SYSTEM, AND BATTERY. THE FAILURE PERSISTED. THE CONTACT RETURNED THE VEHICLE TO THE CERTIFIED MECHANIC WHO DIAGNOSED THAT THE WIN MODULE FAILED AND NEEDED TO BE REPLACED. THE REPAIR WAS STILL PENDING. THE CONTACT WAS CONCERNED THAT THE FAILURE WAS DUE NHTSA CAMPAIGN NUMBER: 14V373000 (ELECTRICAL SYSTEM, AIRBAGS). THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. THE VIN WAS NOT AVAILABLE.
THE AIR BAG LIGHT WOULD GO ON AND OFF AS I TURNED THE WHEEL STARTED IN 2016 AND NOW DEC 2019 ITS ON ALL THE TIME AND MY HORN DOESN'T WORK AND THERES A CRACK IN THE INTERIOR WHERE THE HORN IS.MY FEAR IS WHAT COULD HAPPEN NEXT COULD THE AIRBAG GO OFF WHILE IM DRIVING ALSO I NEED MY HORN WHERE I WAS OUT DRIVING 35 MINS AGO IN MY CITY A CAR ALMOST SIDE SWEEP ME I TRIED TO HONK THE HORN AND NOTICE I HAD NO HORN I HAD TO THINK FAST AND WENT HALF WAYS INTO THE ON COMING TRAFIC LANE THANKFULY THE LANE WAS EMPTY I DONT BELIEVE THAT THIS SHOULDNT HAVE BROKEN
EVERY TIME WE START TO VEHICLE AND DRIVE IT FOR A LITTLE BIT THE AIRBAG LIGHT COMES ON DINGS MUST BE A MALFUNCTION USUALLY COMES ON LOW SPEED SOON AFTER WE START
TAKATA RECALL THE AIR BAG LIGHT IS ON ANY TIME
MY FAMILY AND I WERE INVOLVED IN A SIDE IMPACT COLLISION AFTER SLIDING ON BLACK ICE ON A HIGHWAY. WE WERE TRAVELING AT APPROXIMATELY 60-65 MPH AND SLID INTO THE GUARD RAIL, IMPACTING THE PASSENGER FRONT QUARTER PANEL, AND BOUNCED OFF. THE PASSENGER FRONT TIRE CAME OFF OF THE RIM FORCING US INTO THE GUARD RAIL A SECOND TIME IMPACTING THE REAR PASSENGER QUARTER PANEL OF THE VEHICLE. WE RICOCHETED OFF, CROSSED TRAFFIC AND CAME TO REST IN THE PASSING LANE BERM OF THE ROAD NEAR THE MEDIAN. WE DID NOT ROLL OVER, BUT BECAUSE OF THE FORCE OF IMPACT, SHOULDN'T THE AIR BAGS HAVE DEPLOYED? SOME OF THE PASSENGERS SUFFERED WHIPLASH AND BROKEN NOSES.
I SEND MY VEHICLE TO FREEHOLD DODGE DEALER AFTER MANY DAYS THE DEALER DIDN'T DO ANYTHING BECAUSE MY VEHICLE UNDER WARRANTY AND THE CORPORATE DOESN'T PAY WELL TO THE DEALER I DON'T KNOW WHERE I CAN FILE COMPLAIN
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO STOKES AUTOMOTIVE LOCATED AT 86 PEACH TOWER RD, CLANTON, AL 35045 (205) 351-4382 TO BE SERVICED UNDER NHTSA CAMPAIGN NUMBER: 17V376000 (AIR BAGS) BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED AFTER THE RECALL REPAIR. THE CONTACT SPOKE TO A THE SERVICE MANGER WHOM INFORMED HIM THAT THE AIR BAG WARNING LIGHT FAILURE WAS NOT A PART OF THE RECALL. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. ...UPDATED 10/23/17 *BF UPDATED 10/27/17*JS
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE HORN AND OTHER UNKNOWN FUNCTIONS OF THE STEERING COLUMN FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 34,115.
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V313000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. MA 10/16/15 THE CONSUMER STATED THE AIR BAF WAS REPLACED. UPDATED 12/09/15.*JB
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. AFTER THE VEHICLE WAS STARTED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR BAG CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 51,000. MA 10/22/2015 *CN
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 30 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V234000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000. MA 9/25
THIS MORNING THE FIRST THING I NOTICED WAS THAT THE CRUISE CONTROL WOULD NOT WORK. THIS AFTERNOON, I WENT TO A LOCAL HARDWARE STORE, PURCHASED SOME ITEMS THEN WENT TO MY VAN. WHEN OPENING THE DRIVER DOOR, THE DRIVER SIDE AIR BAG DEPLOYED FROM THE STEERING WHEEL. THERE IS NO SIGN OF ANY DAMAGE TO THE OUTSIDE OF THE CAR. I DID NOTICE THAT WHEN I STARTED THE VAN THE WINDSHIELD WIPERS BEGAN BUT I COULD NOT STOP THEM. WHEN THE WRECKER CAME AND THE CAR WAS STARTED, THE WIPERS DID NOT COME ON BY THEM SELVES AGAIN GLAD THAT THIS DID NOT HAPPEN WHEN THE CAR WAS MOVING.. *JS
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .