RoadVitals

1994 Dodge Ram 2500 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Newest Mar 15, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
8 investigations on file

Recall campaigns

1 campaign cover this model year — what the defect is, what it could cause, and what the remedy is

06E024000

ENGINE AND ENGINE COOLING

Mar 15, 2006
44,386 units potentially affected
The defect: CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
The risk: A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
The remedy: K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
K&N ENGINEERING, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

DP03006ClosedDefect Petition

SEAT BACK FAILURE

Opened Sep 23, 2003
Closed Apr 8, 2004

ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.

SEATS
DP03002ClosedDefect Petition

STEERING COLUMN SEPARATION

Opened May 7, 2003
Closed Jul 22, 2003

MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.

STEERING:COLUMN
PE00048ClosedPreliminary Evaluation

LOSS OF THROTTLE CONTROL

Opened Dec 11, 2000
Closed Mar 7, 2001

ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.

VEHICLE SPEED CONTROL:LINKAGESLed to recall 01V037000
PE99026ClosedPreliminary Evaluation

FRONT SUSPENSION SPRING/SHOCK ABSORBER

Opened Apr 16, 1999
Closed Aug 31, 1999

ALLEGE FAILURE OF THE COIL SPRING/SHOCK ABSORBER BRACKET AT ITS ATTACHMENT TO THE VEHICLE FRAME MAY ALLOW COLLAPSE OF THE FRONT SUSPENSION, AND POTENTIALLY AFFECT STEERING OR BRAKING SYSTEM PERFORMANCE

SUSPENSIONLed to recall 99V214000
EA98010ClosedEngineering Analysis

HEADLIGHT CIRCUIT

Opened May 8, 1998
Closed Dec 10, 1999

THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOLD OF 100 DEGREES CENTIGRADE.WHEN THIS OCCURS, THE LUBRICANT SOLIDIFIES AND ADHERES TO THE SWITCH CONTACH SURFACES INCREASING INTERNAL RESISTANCE AND THERFORE, TEMPERATURE.DAIMLERCHRYSLER INFORMED THE NHTSA THAT IT WOULD INITIATE A RECALL OF 79,3665 MODEL YEAR 1994-1997 DODGE 3500 SERIES RAM TRUCKS ONLY BASED ON ADDITIONAL TESTING FROM WHICH IT DETERMINED THAT THE 1500/2500 SERIES VEHICLES NOMINALLY OPERATE SIGNIFICANTLY BELOW THE TEMPERATURE THRESHOLD OF THE SWITCH LUBRICANT.OWNERS OF 1500/2500 SERIES TRUCKS WERE SENT A NOTIFICATION LETTER ADVISING OF THE PROPER METHODS FOR ADDING AFTERMARKET LIGHTING ACCESSORIES.

EXTERIOR LIGHTINGLed to recall 99V024000
PE98002ClosedPreliminary Evaluation

HEADLIGHT CIRCUIT FAILURE

Opened Jan 14, 1998
Closed May 8, 1998

There is no summary currently available

EXTERIOR LIGHTING

Showing 6 of 8 inquiries on file for this model year, open ones first. Every one of them is listed on NHTSA.gov.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .