2011 Dodge Ram 2500 Problems

The steering became uncontrollable and wobbled so violently I could not keep my hands on the wheel. It will be open for inspection at any time. The safety of all other road users and pedestrians were put in grave danger. Due to the complete loss of steering control. This has happened to other ram owners I have talked with as well. The problem was addressed by my local mechanic. He recommended replacing the entire front end steering and suspension components I agreed he did the work, he did the work. I also replaced all four tires with new and had them balanced. Within 2 weeks this death wobble happened. There are no warning lamps for this problem.

Yesterday, 3/22/2024, I was driving northbound on I-15, fat left lane, approx. 80 mph/posted highway speed. Suddenly lost steering control on my 2011 Dodge Ram 2500 Cummins diesel truck. Front end/tires began vibrating, all steering control lost, truck veered to the right across 3 lanes of traffic and off into the dirt/sage brush to the right of the highway. It almost rolled over, but I was able to slow it to a stop. My dogs & I could have been killed. I turned the truck off for a few minutes, then re-started the ignition. Was mid-trip with no other transportation option, so I drove the rest of the way at much slower speeds, was able to get the truck to our home. I am still shaken from what could have happened to me and our family. I have dash cam video of this incident.

Warped head / blown head gasket

Some electrical components became inoperative in the quick minute. Fuel pump was running continuedly till the battery was drained. Mechanic, I had used before told me that the TIPM Module was defective and needed replaced. Truck just before the battery died was that not all Eletronic's were working. Interior lights, horn, cruise control, FOBs not responding to the vehicle. Mechanic stated that the TPIM did need to be replaced. Contacted dealership were purchased and they told me that there have been recalls out on this particular part. I know that from 2009 to 2017 there have been several models that were impacted by this part being defective. I do have the invoice from the mechanic that took care of replacing the TIPM module.

DEATH WOBBLE - I WAS DRIVING IN HEAVY TRAFFIC ON A 4 LANE HIGHWAY. I DROVE OVER A BRIDGE EXPANSION JOINT AND SUDDENLY THE TRUCK BEGAN SHAKING VIOLENTLY. I COULD NOT STEER. I COULD NOT BRAKE. WE NEARLY COLLIDED WITH A HIGHWAY DIVIDER AND OTHER VEHICLES. I HAD TO COAST DOWN TO 30 MPH OR SO WHEN IT RESOLVED ITSELF.

TL* THE CONTACT OWNS A 2011 RAM 2500. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT HEARD A POP SOUND FROM THE FRONT END OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT EXITED THE VEHICLE AND NOTICED THAT THE FRONT DRIVER SIDE TIE ROD WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER. THE VEHICLE WAS REPAIRED PER A MANUFACTURER'S RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS REPAIRED LAST YEAR PER THE MANUFACTURER'S (N49) RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 174,650.

Approximatly 6 years ago My TIPM failed on my 2011 dodge ram 2500. It was not under warrenty so I replaced it myself not knowing this was an ongoing problem with dodge products. My TIPM is again failing. What can be done with it? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Some electrical components became inoperative in the quick minute. Fuel pump was running continuedly till the battery was drained. Mechanic, I had used before told me that the TIPM Module was defective and needed replaced. Truck just before the battery died was that not all Eletronic's were working. Interior lights, horn, cruise control, FOBs not responding to the vehicle. Mechanic stated that the TPIM did need to be replaced. Contacted dealership were purchased and they told me that there have been recalls out on this particular part. I know that from 2009 to 2017 there have been several models that were impacted by this part being defective. I do have the invoice from the mechanic that took care of replacing the TIPM module.

Some electrical components became inoperative in the quick minute. Fuel pump was running continuedly till the battery was drained. Mechanic, I had used before told me that the TIPM Module was defective and needed replaced. Truck just before the battery died was that not all Eletronic's were working. Interior lights, horn, cruise control, FOBs not responding to the vehicle. Mechanic stated that the TPIM did need to be replaced. Contacted dealership were purchased and they told me that there have been recalls out on this particular part. I know that from 2009 to 2017 there have been several models that were impacted by this part being defective. I do have the invoice from the mechanic that took care of replacing the TIPM module.

THERE ARE TWO ISSUES AT HAND HERE. ONE IS THE FUEL PUMP FUSE/RELAY. IT WENT OUT BUT CANT BE FIXED WITHOUT REPLACING THE ENTIRE FUSE BOX AS IT IS INTERNALLY WITHIN FUSE BOX. I DID A BYPASS AND REPLACED FUEL PUMP, BUT I STILL HAVE CODES RELATED TO FUEL SYSTEM HAVING A LEAK. WHEN THIS ISSUE HAPPENED, MY WIFE WAS LEFT STRANDED AS THE TRUCK WOULDN'T TURN ON. ALSO, ON A DIFFERENT NOTE, I NOTICED MY TRAILER BRAKE LIGHT COMING ON SAYING IT IS DISABLE AND FLASHES ON AND OFF AS I AM DRIVING. NOT SURE IF THIS IS RELATED TO THE ELECTRICAL ASPECT OF IT. THE OTHER WAS ON ENGINE. I HAVE A 2011 RAM 2500 5.7 4X4. IT STARTED WITH HAVING A CYLINDER 1 MISFIRE. I REPLACED SPARK PLUGS AND COILS. STILL HAD ISSUE AND AFTER SOME RESEARCH, I FOUND OUT THAT THE VALVE STEM/SPRING IN ENGINE HEAD BREAK AND CAUSE THE LIFTERS AND CAMSHAFT TO RUB AND RELEASE METAL SHAVINGS THROUGH OUT ENGINE. WHILE THIS WAS MESSED UP, I WOULD NOTICE THE TRUCK WOULD SHAKE VERY HARD AS I APPROACHED A CERTAIN SPEED LIMIT. I TOOK TRUCK TO DODGE DEALERSHIP TO VERIFY RESEARCH AND IT WAS CONFIRMED. I WAS TOLD I NEEDED A NEW ENGINE. SO I REPLACED ENGINE. TOTAL BILL WAS OVER 7500 FOR PARTS AND LABOR.

Warped head / blown head gasket

TRANSFER CASE EXPLODED WHILE DRIVING DOWN THE ROAD

TL* THE CONTACT OWNS A 2011 RAM 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH AND MAKING A LEFT TURN, THE BRAKING SYSTEM MALFUNCTIONED AND THE VEHICLE WOULD NOT IMMEDIATELY SLOW DOWN. ADDITIONALLY, THE POWER STEERING FAILED CAUSING THE STEERING WHEEL TO BECOME DIFFICULT TO TURN. THE CONTACT INDICATED THAT THE FAILURE HAD OCCURRED ON FOUR SEPARATE OCCASIONS AND OCCURRED WHILE THE RPM WAS BELOW 700 RPM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE. NO REPAIRS WERE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. A DEALER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 75,000.*DT FAILURE OCCURRED AFTER BRAKING AND GOING ABOUT 20 MPH AFTER THE RPM'S DROP TO ABOUT 700.*JB

INTEGRATED TRAILER BRAKE SYSTEM FAILED AND WILL NOT READ ANY TRAILER WHEN CONNECTED. STATES 'TRAILER DISCONNECTED'

TL* THE CONTACT OWNS A 2011 RAM 2500. THE CONTACT STATED THAT THE BOLTS THAT ATTACHED THE EXHAUST MANIFOLD TO THE VEHICLE HAD FRACTURED. AS A RESULT, THE EXHAUST MANIFOLD DETACHED FROM THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BOLTS NEEDED TO BE REPLACED, AND THE EXHAUST MANIFOLD MAY NEED TO BE REPLACED AS WELL. THIS WOULD NOT BE DETERMINED UNTIL THE REPLACEMENT OF THE BOLTS WAS COMPLETED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED THAT DUE TO THE FACT THAT A PLOW WAS PLACED ON THE TRUCK, THE REPAIR WAS NOT COVERED UNDER WARRANTY. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. ...UPDATED 03/13/17 *BF *CN

TL* THE CONTACT OWNS A 2011 DODGE RAM 2500. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 13V529000 (STEERING). THE DETAILS OF THE FAILURE WERE NOT AVAILABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVER SIDE TIE ROD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 81,000. THE VIN WAS NOT AVAILABLE.

POWER STEERING FAILED WHILE DRIVING. IT WILL GO IN AND OUT INTERMITTENTLY AND THEN WORK PERIODICALLY. OUR TIE ROD ALREADY SNAPPED AND WAS REPLACED UNDER RECALL, BUT NOW THE TRUCK HAS POWER STEERING ISSUES. A VIN CHECK SAYS ALL REPAIRS HAVE BEEN COMPLETED ON OUR TRUCK BUT WE ARE STILL HAVING STEERING ISSUES. WAS DRIVING AND MAKING A TURN WHEN THE STEERING WENT OUT INITIALLY AND WE COULD NOT TURN THE VEHICLE. ALSO, BRAKE CONTROL SYSTEM IS MALFUNCTIONING, CAUSING LOCKING TRAILER BRAKES, ROOF SUDDENLY BEGAN LEAKING AND FLOODED INTERIOR CAB, TIRE PRESSURE SENSORS ARE MALFUNCTIONING, HEATER FLAP IN DASH IS BAD AND BEEN IN FOR REPAIR 2 TIMES AND ITS NOT FIXED. AIR CONDITIONER IS NOT BLOWING COLD AND THE BACKUP CAMERA DOES NOT WORK. THE TRUCK HAS 60,000 MILES NOW AND IS STILL UNDER WARRANTY, BUT DODGE SAYS IT CAN'T FIX SOME OF THE PROBLEMS DUE TO NO WARRANTY OR NOT BEING ABLE TO LOCATE THE PROBLEM.

TL* THE CONTACT OWNS A 2011 DODGE RAM 2500. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE RELATED TO THE RECALL, BUT DID EXPERIENCE ACCELERATION FAILURES. THE SPECIFICS OF THE FAILURE WERE NOT AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 60,000.

MY SAFETY COMPLAINT ON OUR 2011 DODGE RAM 3500 TRUCK SHOULD ALREADY BE IN FILE! WE HAVE HAD SAFETY ISSUES WITH THIS TRUCK EVER SINCE PURCHASING IT AS A USED VEHICLE FROM RAMEY'S IN BECKLEY, WV. THERE ARE AT PRESENT THREE (3) RECALLS ON THIS VEHICLE, OF WHICH N49 APPEARS TO BE THE MOST LIFE-THREATENING, WHICH WE WERE NEVER NOTIFIED ABOUT, NOR WERE WE EVER NOTIFIED ABOUT THE BUYBACK ON THIS TRUCK. WE ACCIDENTALLY FOUND OUT. WE WERE NEVER NOTIFIED OF ANYTHING CONCERNING THESE PROBLEMS, PROBABLY BECAUSE WE PURCHASED IT USED. THE PROBLEM WITH THE TIE ROD, WHICH COULD CAUSE LOSS OF CONTROL AND A POSSIBLE CRASH IS NOT THE ONLY LIFE-THREATENING RECALL. THE RECALL WITH THE FUEL HEATER COULD POSSIBLY CAUSE A FIRE. WE HAVE, ON SEVERAL OCCASIONS, NOTICED SMOKE COMING OUT FROM UNDER THE HOOD WHILE REFUELING THE TRUCK, AS WELL AS A NOTICEABLE SHAKING AND VIBRATING IN THE FRONT OF THE TRUCK WHILE IN OPERATION. FCA US, LLC IS ATTEMPTING TO CIRCUMVENT THE "CONSENT ORDER" AGREED TO BY THEM WITH NHTSA. THEY HAVE AGREED TO REPURCHASE THESE DEFECTIVE VEHICLES FOR THE PURCHASE PRICE PAID BY THE "ORIGINAL" PURCHASER, MINUS A REASONABLE AMOUNT FOR DEPRECIATION, PLUS 10%! IT APPEARS THAT FCA IS MAKING THEIR OWN RULES TO REPURCHASE BY "LOW-BALLING" THE REPURCHASE PRICE! WHAT THEY ARE ATTEMPTING TO DO IS CALLED FRAUD! IT WOULD APPEAR THAT NHTSA IS ALLOWING IT! SHOULD A CRASH OR FIRE HAPPEN WHILE FCA DRAGS ITS FEET ON THE REPURCHASE OF THIS TRUCK, SOMEONE WILL BE HELD ACCOUNTABLE BY LAW!

AUGUST 2013 WE BOUGHT AFTERMARKET WHEELS FOR OUR 2011 DODGE RAM 2500. JULY 6, 2014 WHILE WASHING TRUCK, WE NOTICED SIX (6) LUG NUTS AND STEMS/BOLT MISSING. TWO MISSING ON REAR TIRE AND TWO MISSING ON BOTH FRONT TIRES. CONTACT OUR TIRE COMPANY TO GET THE PROBLEM REPAIRED AND HE STATED THAT CHRYSLER HAS THAT PART, THE LUG NUT BOLTS/STEMS, IS ON A NATIONWIDE BACK ORDER AND DID NOT HAVE AN ESTIMATE TO WHEN THEY WOULD BE AVAILABLE. NOW, I DON'T FEEL SAFE DRIVING A TRUCK WITH 6 LUG NUTS MISSING AND CANNOT GET IT REPAIRED. ALSO, WHEN I GET IT REPAIRED, WILL IT HAPPEN AGAIN? PROBABLY, THAT'S WHY THE PART IS ON BACK ORDER. *TR

I WAS DRIVING AT THE SPEED LIMIT ON THE HIGHWAY, NORMAL DAY, AND I NOTICE A SUDDEN VIBRATION STARTED TO FEEL WORST AND WORST, SO I GOT OUT OF THE HIGHWAY AND NOTICE ONE OF THE TIRES DEFORMED ON THE CONTACT PART OF THE TIRE, THE BELT IS COMING OFF , I DROVE HOME CITY ROADS AND NEXT DAY TOOK IT TO MY MECHANIC SHOP , THE ISSUE IS CONFIRMED , I TALKED TO MY THE TIRE WHOLESALER TO REPLACE THE TIRES , AND THEY SAID " I CAN ONLY GIVE YOU A PARTIAL COST OF THE OLD TIRE AND THE NEW TIRE COST EVEN MORE" NO COVERING THE WARRANTY AT ALL, AND TO BE HONEST I WILL NOT WANT TO DRIVE THIS CAR WITH THIS SET OF TIRES ANYMORE I DO NOT FEEL SAFE , TIRES GOT LESS THAN 10000 MILES, I WROTE AN EMAIL TO FALKEN COSTOMER SERVICES AFTER I TALKED TO THE WHOLESALER. IT REALLY BOTHERS ME NOW I CAN'T DRIVE THIS CAR UNTIL THEY ANSWER THIS IS UNSAFE AND CAN CAUSE A MAJOR ACCIDENT, THIS IS EXACTLY WHY I PURCHASE A NEW SET OF TIRES TO AVOID A REAL BAD ACCIDENT ..

TL * THE CONTACT OWNS A 2011 DODGE RAM 2500. WHILE DRIVING AT AN UNKNOWN SPEED, THE STEEL CABLE FAILED THAT SECURED THE SPARE TIRE UNDERNEATH THE VEHICLE. THE FAILURE CAUSED THE SPARE TIRE TO SEPARATE FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 54,000.

TRUCK WAS IDLING, JUST GOT HOME AND THE MASTER WINDOW SWITCH STARTED SMOKING AND AS THAT HAPPENED BOTH BACK WINDOWS ROLLED DOWN AND FIRE CAME OUT FROM WINDOW SWITCH. *TR

TL* THE CONTACT OWNS A 2011 DODGE RAM 2500. THE CONTACT STATED THAT THE FRONT PASSENGER WINDOW SHATTERED WHILE DRIVING 60 MPH. THE VEHICLE WAS NOT TAKEN TO A DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 6,900. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2011 DODGE RAM 2500. THE CONTACT STATED THAT A PASSENGER WAS RESTING THEIR ARM ON THE WINDOW SEAL WHEN THE AUTOMATIC LOCK ENGAGED INDEPENDENTLY, PINCHING THE PASSENGER ON THE ARM BETWEEN THE LOCK AND THE WINDOW. THE FAILURE CAUSED SEVERE BRUISING TO THE PASSENGER. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MECHANIC FOR DIAGNOSIS. THE MANUFACTURER HAD NOT YET BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 11,000.

TL* THE CONTACT OWNS A 2011 DODGE RAM 2500. THE CONTACT STATED THAT THE DESIGN OF THE FRONT DRIVER AND PASSENGER SIDE HEAD RESTS COULD POTENTIALLY BREAK HER NECK IF REAR ENDED BY ANOTHER VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS WAITING A CALL BACK FROM A REPRESENTATIVE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE CURRENT MILEAGE WAS 300.

UPON ACTIVATING THE HIGH BEAM HEAD LIGHTS, ENGINE WILL BEGIN MISSING AND EVENTUALLY STALL. HEADLIGHTS WILL BLINK OFF AND ON. ALL DASH LIGHTS AND ELECTRICAL SYSTEMS WILL ALSO FLUCTUATE POWER (RADIO, WIPERS, TAIL LIGHTS, HAZARDS, FRONT PARKING LIGHTS AND TURN SIGNALS). ALL GAUGES ON THE DASH WILL GO DEAD. WHILE DRIVING ON 7/22/2016 AT APPROXIMATELY 9:15 PM THE HIGH BEAM HEAD LIGHTS WERE ACTIVATED. THE ENGINE BEGAN TO MISS AND ALL ELECTRICAL SYSTEMS BEGAN TO TURN OFF, AND THEN BACK ON. THE ENGINE STALLED AT APPROX 65 MPH LEAVING NO POWER STEERING. TRUCK WAS ABLE TO BE RESTARTED ONCE IT WAS BROUGHT TO REST ON THE SHOULDER. HIGH BEAMS COULD NOT BE USED OR THE PROBLEM WOULD REPEAT. MAKE: RAM (DODGE) MODEL: 2500 YEAR: 2011 ENGINE/POWERTRAIN: 6.7L CUMMINS TURBO DIESEL W/ 6 SPEED AUTOMATIC.

TL* THE CONTACT OWNS A 2011 DODGE RAM 2500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH THE HEADLIGHTS WERE ACTIVATED AND THE ILLUMINATION WAS EXTREMELY DIM. THE FAILURE OCCURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOUR TIMES FOR THE SIMILAR DEFECT. THE CONTACT REPLACED BOTH HEADLIGHT BULBS WITH AN AFTER MARKET BULBS AND THE BRIGHTNESS IMPROVED; HOWEVER INADEQUATE FOR NIGHT DRIVING. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. UPDATED 12/28/12 *BF THE CONSUMER HAS SINCE TRADED THE VEHICLE. UPDATED 01/03/13

THE AIR CONDITIONING SYSTEM ONLY WORKS WHILE DRIVING DOWN THE ROAD. WHEN THE AMBIENT TEMPERATURE IS ABOVE 90 DEGREES AND THE VEHICLE IS STARTED AND WHILE THE AIR CONDITIONING IS ON THE INTERIOR CAB WILL NOT COOL DOWN. IT IS NOT UNTIL YOU START TO DRIVE THE VEHICLE THAT THE AIR CONDITIONING STARTS TO COOL AND WILL KEEP COOL UNLESS YOU STAY STATIONARY FOR A WHILE. I HAVE HAD THE DEALER INSPECT THE A/C UNIT MULTIPLE OCCASIONS AND THEY FIND NO PROBLEM. WHEN A BASIC INTERNET SEARCH IS PERFORMED I FIND MULTIPLE SOURCES INDICATING A DEFECTIVE FAN CLUTCH AND ONCE REPLACED THIS PROBLEM GOES AWAY. NORMALLY I WOULDN'T CARE BUT SINCE HAVING A 9 MONTH OLD WHILE LIVING IN OKLAHOMA ITS BECOME MORE OF A NECESSITY DURING THESE EXTREME SUMMER TEMPERATURES. *JS

I BECAME AWARE THAT THE TIPM MODULE IS DEFECTIVE. I NOTIFIED DODGE ON THIS PROBLEM AND EVEN REQUESTED ASSISTANCE ON REPAIR. ON 11/03/17, WAS TOLD DODGE DENIED CLAIM. IN MY OPINION THIS MAY BE A SAFETY CONCERN, SINCE THE TIPM MODULE CONTROLS FUEL SYSTEM, AIR BAG DEPLOYMENT, WIPER OPERATIONS AND A FEW OTHER SYSTEMS. I'VE NOTICED ON THE INTERNET FROM DOSGE FORUMS THAT ALOT OF DODGE AND CHRYSLER OWNERS ALSO HAD ISSUSES WITH THE TIPM MODULE. I WAS QUOTED FOR REPAIRS AROUND $1200.00 .