1994 Dodge Ram 3500 Problems

IN A HARD RAIN OR EVEN WASHING UP UNDERNEATH THE TRUCK THE 4WD SERVICE LIGHT COMES ON AND IT WILL SAY IT'S TRYING TO TRANSFER OVER TO 4WD AND WHEN IT TRIED WITH ME I WAS RUNNING AROUND 55 MPH! IT JERKS THE [XXX] OUT OF THE TRUCK WITH A LOUD HAMMER NOISE! IT WILL CAUSE A PERSON TO WRECK IF YOU ARE NOT EXPECTING IT ! IT WAS BOUGHT NEW IN 2019 AND STARTED THE 4WD CRAP AT 4,500 MILES NOT TO MENTION THE TRAILER BRAKE CONTROLLER DOESN'T WORK EITHER NOW, FOUND THAT OUT THE HARD WAY WITH 22 ROLLS OF HAY AND NO IT'S NOT THE TRAILER MY FORD TRUCK HAS TRAILER BRAKES, SAME TRAILER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2 OUT OF THE 3 MAIN TRANSPIRATION AND DELIVERY SERVICE VEHICLES THAT I PERSONALLY USED TO GET TO THE JOB SITE AND TO DELIVER HEAVY METAL STRUCTURES ARE IN VERY BAD SHAPE, PARTICULARLY DODGE RUM 1994 PLATE NUMBER (74R 300). THE MAIN PROBLEMS ON THIS TRUCK ARE THE BAD BRAKES, ESPECIALLY WHEN CARRYING HEAVY METAL MATERIALS. ABS LIGHT ON, NO HORN, BROKEN SPEEDOMETER, AIR BAG LIGHT ON, BROKEN TURNING SIGNALS, SPECKS OF RED PAINT ON THE WINDSHIELD, WINDSHIELD WIPER FLUID NOT WORKING, NO A/C, TURNING SIGNALS NOT ALL WORKING, WEAR OUT TIRES, ETC. EVEN THOUGH I POINT OUT TO THEM THAT THE BREAKS WERE NOT GOOD, THEY STILL NEVER PAID ANY ATTENTION TO WHAT I SAID. THEY PROBABLY DID NOT PAY MUCH ATTENTION TO ME BECAUSE THEY NEVER EXPERIENCED ANY VEHICLE RELATED ACCIDENTS. BUT KNOWING THAT THEY AREA ALWAYS CARING HEAVY METALS, THEY SHOULD BE A LITTLE MORE CONCERN ABOUT THE SAFETY OF THEIR WORKERS IN GENERAL BUT CLEARLY THEY DO NOT CARE A BIT AND THAT REALLY BOTHERED ME VERY MUCH. IN THIS EMAIL, I AM MOSTLY POINTING OUT THE DODGE RUM 1994 PLATE NUMBER (74R-300), UNFORTUNATELY I DON'T HAVE THE EXACT PLATE NUMBER OF THE OTHER 2 VEHICLES. I AM SURE THAT IF SOMEONE WHO KNOWS ABOUT TRUCK SAFETY AND MECHANICS TAKES A LOOK AT ALL 3 VEHICLES, THEY WILL SE THAT WHAT I AM SAYING IS TRUE. I AM ALSO ATTACHING A FEW IMAGES TO BACKUP MY STATEMENT.

TL* THE CONTACT STATED WHILE DRIVING 60 MPH, THE FRONT END OF THE VEHICLE STARTED TO SHAKE. AS A RESULT OF THE FAILURE, THE TRANSFER CASE FAILED . THE CONTACT STATED HE HAD TO APPLY THE BREAKS AND TURN THE ENGINE OFF IN ORDER TO STOP THE VEHICLE FROM SHAKING . THE MANUFACTURER WAS NOTIFIED MANY TIMES.. UPDATED 05/12/2014*LJ

DT*: THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE HIT A BUMP, WHICH STARTED A VIOLENT SHAKING OR "DEATH WOBBLE" IN THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER REINFORCED THE SHOCK TOWER, AND DETERMINED THAT THE TRACK BAR WAS LOOSE. THERE IS A NHTSA RECALL # 94V097000 WHICH PERTAINS TO THE FRONT SUSPENSION. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

IN A HARD RAIN OR EVEN WASHING UP UNDERNEATH THE TRUCK THE 4WD SERVICE LIGHT COMES ON AND IT WILL SAY IT'S TRYING TO TRANSFER OVER TO 4WD AND WHEN IT TRIED WITH ME I WAS RUNNING AROUND 55 MPH! IT JERKS THE [XXX] OUT OF THE TRUCK WITH A LOUD HAMMER NOISE! IT WILL CAUSE A PERSON TO WRECK IF YOU ARE NOT EXPECTING IT ! IT WAS BOUGHT NEW IN 2019 AND STARTED THE 4WD CRAP AT 4,500 MILES NOT TO MENTION THE TRAILER BRAKE CONTROLLER DOESN'T WORK EITHER NOW, FOUND THAT OUT THE HARD WAY WITH 22 ROLLS OF HAY AND NO IT'S NOT THE TRAILER MY FORD TRUCK HAS TRAILER BRAKES, SAME TRAILER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 1994 DODGE RAM 3500. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BLOWER MOTOR AND WIRING HARNESS MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 00V135000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,639. UPDATED 6/18/15*CN UPDATED 10/05/2017*CN

NOTICED TRANSMISSION LEAKING UNDERNEATH. IT WAS LEAKING ONTO THE EXHAUST SYSTEM PIPE AND CATALYTIC CONVERTER, CLEARLY BACK TO THE BRAKES AND REAR BUMPER. CONTACTED DEALER WHO WAS NOT ABLE TO HELP DUE TO EXPIRED WARRANTY. TRANSMISSION COOLER LINES WERE CLAMPED TOGETHER WHERE THEY CAN RUBED EACH OTHER AND WORE OUT. *AK

TRUCK VIBRATES EXCESSIVELY ,THE DEALER HAS REPLACED TRANSMISSION/TORQUE CONVERTER AND THE PROBLEM STILL EXISTS. YH

TL* THE CONTACT STATED WHILE DRIVING 60 MPH, THE FRONT END OF THE VEHICLE STARTED TO SHAKE. AS A RESULT OF THE FAILURE, THE TRANSFER CASE FAILED . THE CONTACT STATED HE HAD TO APPLY THE BREAKS AND TURN THE ENGINE OFF IN ORDER TO STOP THE VEHICLE FROM SHAKING . THE MANUFACTURER WAS NOTIFIED MANY TIMES.. UPDATED 05/12/2014*LJ

STEERING COLUMN SHAFT FAILED PER RECALL NOTICE CAUSING IT TO COMPLETELY SEPARATE WHILE DRIVING. NLM (RECALL 96V230000)

PULLING INTO TRAFFIC VEHICLE SUDDENLY HAS NO POWER AND WILL NOT ACCELERATE NEARLY CAUSED A ACCIDENT. THROTTLE BECOMES UNRESPONSIVE. BROUGHT VEHICLE TO DODGE DEALER. DODGE SAYS THIS IS DUE TO A THROTTLE POSITION SENSOR WHICH HAS BEEN ON BACK-ORDER SINCE MAY. WE RECEIVE A E-MAIL FROM DODGE CORPORATE REPRESENTATIVE APPROXIMATELY EVERY 2 WEEKS SAYING THANKS FOR YOU PATIENCE BUT THERE STILL IS NO DELIVERY DATE FOR THIS PART. THIS VEHICLE HAS BEEN PARKED SINCE MAY BECAUSE IT IS UNSAFE TO DRIVE. I FEEL THIS IS UNACCEPTABLE TO EXPECT A VEHICLE TO BE PARKED FOR 4 MONTHS WITH NO SOLUTION FROM DEALER FOR A REPAIR PART.

CONSUMER NOTICED THE A FUEL LINE FITTING CONNECTOR, AND AUXILIARY COOLER ON TRANSMISSION IS NOT WORKING PROPERLY. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS

NHTSA RECALL CAMPAIGN 99V024000 HEADLAMP SWITCH; THE HEADLIGHT SWITCH FAILED SHORTING OUT WHICH CAUSED THE HEADLIGHTS TO GO OUT WHILE IN USE. THE SWITCH FAILED AGAIN BUT THIS TIME THE WIRING HARNESS UNDER THE DASH CAUGHT FIRE WHILE BEING DRIVEN. THERE WAS A RECALL ISSUED ON THE RAM 3500 FOR THIS PROBLEM BUT THE SAME FAILURE HAS OCCURED ON THIS RAM 2500 PICKUP. PLEASE DESCRIBE DETAILS TS

WHILE DRIVING HEADLIGHTS WILL GO OFF AND ON AT DIFFERENT TIMES, AND SOMETIMES WILL NOT WORK AT ALL. VEHICLE WAS RECALLED BEFORE FOR THIS PROBLEM UNDER RECALL 99V024000/ HEADLAMP SWITCH FAILURE. *AK

NHTSA RECALL CAMPAIGN 99V024000 HEADLAMP SWITCH; THE HEADLIGHT SWITCH FAILED SHORTING OUT WHICH CAUSED THE HEADLIGHTS TO GO OUT WHILE IN USE. THE SWITCH FAILED AGAIN BUT THIS TIME THE WIRING HARNESS UNDER THE DASH CAUGHT FIRE WHILE BEING DRIVEN. THERE WAS A RECALL ISSUED ON THE RAM 3500 FOR THIS PROBLEM BUT THE SAME FAILURE HAS OCCURED ON THIS RAM 2500 PICKUP. PLEASE DESCRIBE DETAILS TS

IT WAS RAINY DAY AND VEHICLE HAD BEEN DRIVEN ABOUT 2 HRS BEFORE INCIDENT. VEHICLE WAS PARKED AND CONSUMER NOTICED SMOKE INSIDE CAR. FIRE WAS COMING UP THROUGH THE DASHBOARD BETWEEN THE HEADLIGHT SWITCH AND VIN. CONTACTED DEALER AND MANUFACTURER. THEY INVESTIGATED, AND CLAIMED THEY WERE NOT RESPONSIBLE IF OVER 12 MONTHS. *AK

VEHICLE IS EXHIBITING POSSIBLE SUSPENSION PROBLEMS INCLUDING EXCESSIVE MOVEMENT BETWEEN THE PICKUP WHEN TOWING A CAMPER. THE TRUCK HAS SUDDENLY ROLLED TO THE RIGHT AS THOUGH A TIRE HAD ROLLED OOT OF THE RIM, THERE ARE CRACKS IN THE FRONT OF THE PICKUP BOX AND BOTTOM OF THE CAB. ALLOWING THE BOX TO TWIST IN RELATION TO THE FRAME AND THE HEIGHT OF THE CAMPER. THE MOTION IS EXTREME AND IS ACCOMPANIED BY CLICKS AND POPS OF THE SHEET METAL FROM THE AREA OF THE CRACKS. IT IS ALSO POSSIBLE THAT THE SUSPENSION PROBLEMS CAUSED THE DRIVER SIDE U BOLTS TO BE LOOSE. *TT

VEHICLE THAT WAS SOLD TO CONSUMER AS A SALVAGED VEHICLE INVOLVED IN AN ACCIDENT. FRONT AND CENTER PARTS OF FRAME WERE CRUSHED, AND PUT BACK TOGETHER. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK

DEFECTIVE FUEL PUMP. DEFECTIVE BRAKES.

AIR DUCT INTAKE LOCATED BETWEEN BATTERY AND LEFT FRONT HEADLIGHT IS NOT SCREENED TO PREVENT DEBRIS FROM BEING SUCKED INTO AIR FILTER CHAMBER.

TL-CONTACT OWNS A 1994 DODGE RAM PICKUP TRUCK.... INQUIRED ABOUT GENERAL RECALLS... CONTACT HAD VEHICLE TOWED TO DODGE DEALERSHIP AFTER CATCHING FIRE DUE TO RECALL... DASHBOARD CAUGHT ON FIRE WHILE DRIVING... DEALERSHIP HAD INVESTIGATIONS TEAM COME OUT TO INSPECT TRUCK AFTER FIRE... TRUCK HAD BEEN REPAIRED AFTER FIRE... DEALERSHIPHAS DEAD ENGINE CABLE ... THROTTLE OF TRUCK IS FAILING... DEALERSHIP IS REFUSING TO FIX RECALL DUE TO TRUCK BEING REPAIRED AFTER FIRE.... DEALERSHIP STATED INSPECTION NEEDS TO BE DONE BEFORE THROTTLE CAN BE FIXED.... CONTACT WAS GIVEN NUMBER TO FEDERAL TRADE COMMISSION AT 202-366-2222 MAY 10,2000 MANUFACTURER RECALL NUMBER875 NHTSA RECALL NUMBER00V-135 RECALL STATUSRECALL INCOMPLETE SUMMARYTHE AFFECTED VEHICLES WERE BUILT WITH AN IGNITION SWITCH AND WIRING THAT COULD OVERHEAT. 853-1403. PLEASE HAVE YOUR VIN READY WHEN CALLING.NHTSA. YOU CAN PROVE THE REPAIRS WERE MADE.) HOWEVER, IF THE COURT ULTIMATELY RULES THE DEFECT IS NOT SAFETY-RELATED, FEDERAL LAW DOES NOT REQUIRE THAT THE MANUFACTURER REIMBURSE YOU FOR THE REPAIR WORKCHAPTER 301 OF TITLE 49 OF THE UNITED STATES CODE (U.S.C.) REQUIRES A MANUFACTURER OF MOTOR VEHICLES OR ITEMS OF MOTOR VEHICLE EQUIPMENT THAT CONTAIN A DEFECT RELATING TO MOTOR VEHICLE SAFETY TO REMEDY THE DEFECT WITHOUT CHARGE.

THROTTLE LINKAGE CLIP FAILS, THE ABILITY TO ACCELERATE IS GONE AND IDLE SPEED AND RPM'S ARE ALL THAT IS AVAILABLE. MJS

VEHICLE OF WILL STALL INTERMITTENTLY. PROBLEM IS MORE FREQUENT DURING WARM WEATHER. DEALERSHIP HAS EXAMINED VEHICLE NUMEROUS TIMES, BUT COULD NOT DETERMINE CAUSE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / ATTACHMENTS.*AK

VAN EXPERIENCING FLOOR OVERHEATING, POSSIBLY DUE TO EXHAUST SYSTEM FAILURE. INSURANCE COMPANY REQUESTING INFORMATION. MJS

IN A HARD RAIN OR EVEN WASHING UP UNDERNEATH THE TRUCK THE 4WD SERVICE LIGHT COMES ON AND IT WILL SAY IT'S TRYING TO TRANSFER OVER TO 4WD AND WHEN IT TRIED WITH ME I WAS RUNNING AROUND 55 MPH! IT JERKS THE [XXX] OUT OF THE TRUCK WITH A LOUD HAMMER NOISE! IT WILL CAUSE A PERSON TO WRECK IF YOU ARE NOT EXPECTING IT ! IT WAS BOUGHT NEW IN 2019 AND STARTED THE 4WD CRAP AT 4,500 MILES NOT TO MENTION THE TRAILER BRAKE CONTROLLER DOESN'T WORK EITHER NOW, FOUND THAT OUT THE HARD WAY WITH 22 ROLLS OF HAY AND NO IT'S NOT THE TRAILER MY FORD TRUCK HAS TRAILER BRAKES, SAME TRAILER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT STATED WHILE DRIVING 60 MPH, THE FRONT END OF THE VEHICLE STARTED TO SHAKE. AS A RESULT OF THE FAILURE, THE TRANSFER CASE FAILED . THE CONTACT STATED HE HAD TO APPLY THE BREAKS AND TURN THE ENGINE OFF IN ORDER TO STOP THE VEHICLE FROM SHAKING . THE MANUFACTURER WAS NOTIFIED MANY TIMES.. UPDATED 05/12/2014*LJ

2 OUT OF THE 3 MAIN TRANSPIRATION AND DELIVERY SERVICE VEHICLES THAT I PERSONALLY USED TO GET TO THE JOB SITE AND TO DELIVER HEAVY METAL STRUCTURES ARE IN VERY BAD SHAPE, PARTICULARLY DODGE RUM 1994 PLATE NUMBER (74R 300). THE MAIN PROBLEMS ON THIS TRUCK ARE THE BAD BRAKES, ESPECIALLY WHEN CARRYING HEAVY METAL MATERIALS. ABS LIGHT ON, NO HORN, BROKEN SPEEDOMETER, AIR BAG LIGHT ON, BROKEN TURNING SIGNALS, SPECKS OF RED PAINT ON THE WINDSHIELD, WINDSHIELD WIPER FLUID NOT WORKING, NO A/C, TURNING SIGNALS NOT ALL WORKING, WEAR OUT TIRES, ETC. EVEN THOUGH I POINT OUT TO THEM THAT THE BREAKS WERE NOT GOOD, THEY STILL NEVER PAID ANY ATTENTION TO WHAT I SAID. THEY PROBABLY DID NOT PAY MUCH ATTENTION TO ME BECAUSE THEY NEVER EXPERIENCED ANY VEHICLE RELATED ACCIDENTS. BUT KNOWING THAT THEY AREA ALWAYS CARING HEAVY METALS, THEY SHOULD BE A LITTLE MORE CONCERN ABOUT THE SAFETY OF THEIR WORKERS IN GENERAL BUT CLEARLY THEY DO NOT CARE A BIT AND THAT REALLY BOTHERED ME VERY MUCH. IN THIS EMAIL, I AM MOSTLY POINTING OUT THE DODGE RUM 1994 PLATE NUMBER (74R-300), UNFORTUNATELY I DON'T HAVE THE EXACT PLATE NUMBER OF THE OTHER 2 VEHICLES. I AM SURE THAT IF SOMEONE WHO KNOWS ABOUT TRUCK SAFETY AND MECHANICS TAKES A LOOK AT ALL 3 VEHICLES, THEY WILL SE THAT WHAT I AM SAYING IS TRUE. I AM ALSO ATTACHING A FEW IMAGES TO BACKUP MY STATEMENT.

TLA* THE CONTACT OWNS A 1994 DODGE RAM 3500. THE CONTACT STATED THAT THE SEAT BELT RETRACTED, BUT FAILED TO STOP WHEN PULLED FORCEFULLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THREE POINT SEAT BELT SYSTEM IN THE FLOORBOARD WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THE PARTS NEEDED TO REPAIR THE VEHICLE WERE NO LONGER PRODUCED. THE VEHICLE COULD NOT BE REPAIRED. THE FAILURE MILEAGE WAS 120,000. UPDATED 7/16/15*CN THE CONSUMER STATED THE SEAT BELT WOULD NOT LOCK AND THE TENSION SPRING HAD BECOME VERY WEAK. . UPDATED 07/28/15

2 OUT OF THE 3 MAIN TRANSPIRATION AND DELIVERY SERVICE VEHICLES THAT I PERSONALLY USED TO GET TO THE JOB SITE AND TO DELIVER HEAVY METAL STRUCTURES ARE IN VERY BAD SHAPE, PARTICULARLY DODGE RUM 1994 PLATE NUMBER (74R 300). THE MAIN PROBLEMS ON THIS TRUCK ARE THE BAD BRAKES, ESPECIALLY WHEN CARRYING HEAVY METAL MATERIALS. ABS LIGHT ON, NO HORN, BROKEN SPEEDOMETER, AIR BAG LIGHT ON, BROKEN TURNING SIGNALS, SPECKS OF RED PAINT ON THE WINDSHIELD, WINDSHIELD WIPER FLUID NOT WORKING, NO A/C, TURNING SIGNALS NOT ALL WORKING, WEAR OUT TIRES, ETC. EVEN THOUGH I POINT OUT TO THEM THAT THE BREAKS WERE NOT GOOD, THEY STILL NEVER PAID ANY ATTENTION TO WHAT I SAID. THEY PROBABLY DID NOT PAY MUCH ATTENTION TO ME BECAUSE THEY NEVER EXPERIENCED ANY VEHICLE RELATED ACCIDENTS. BUT KNOWING THAT THEY AREA ALWAYS CARING HEAVY METALS, THEY SHOULD BE A LITTLE MORE CONCERN ABOUT THE SAFETY OF THEIR WORKERS IN GENERAL BUT CLEARLY THEY DO NOT CARE A BIT AND THAT REALLY BOTHERED ME VERY MUCH. IN THIS EMAIL, I AM MOSTLY POINTING OUT THE DODGE RUM 1994 PLATE NUMBER (74R-300), UNFORTUNATELY I DON'T HAVE THE EXACT PLATE NUMBER OF THE OTHER 2 VEHICLES. I AM SURE THAT IF SOMEONE WHO KNOWS ABOUT TRUCK SAFETY AND MECHANICS TAKES A LOOK AT ALL 3 VEHICLES, THEY WILL SE THAT WHAT I AM SAYING IS TRUE. I AM ALSO ATTACHING A FEW IMAGES TO BACKUP MY STATEMENT.

DRIVER SIDE AIRBAG DEPLOYED WITHOUT VEHICLE BEING IN AN ACCIDENT.*AK

TIRE HAS SEPARATED IN THE MIDDLE OF TREAD. STEEL BELTS HAVE COMPLETELY SEPARATED AND THE TREAD IS COMPLETELY OPENED UP. *AK (DOT NUMBER: VD1L1XA TIRESIZE: 225 75R16)

FAILURE OF TRAILER HITCH ON THE BACK OF THE 1994 DODGE PICKUP TRUCK.*MR THE TRUCK HITCH EXTENDED TOO FAR OUT FROM THE MOUNTS, PUTTING UNDUE LEVERAGE AND STRESS ON THE METAL WHICH RESULTED IN IT FAILING. A RECALL WAS ISSUED FOR MODEL YEAR 1998-2000 BUT NOT FOR EARLIER MODEL YEARS. THE CONSUMER HAD THE HITCHES REPLACED AT HIS EXPENSE AND REQUEST REIMBURSEMENT FROM THE MANUFACTURER. *NM