2006 Dodge Sprinter 2500 Owner Complaints

The contact owns a 2006 Dodge Sprinter 2500. The contact received notification of Emissions Recall T21 Reprogram Engine Control Unit. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and carbon monoxide fumes were coming into the cabin of the travel trailer and setting off the carbon monoxide alarm. Police have also warned the contact that there would be a fine for black smoke coming out of the exhaust pipe. The vehicle was taken to the dealer, but the dealer informed the contact that they were not equipped with the tools or had technicians that could perform the recall repair. The dealer referred the contact to a Mercedes-Benz dealer. However, the Mercedes Benz dealer informed the contact that they only perform recall repairs on Mercedes-Benz vehicles. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case but could not get a dealer to perform the recall repair. The failure mileage was approximately 52,000.

NHTSA ID

11436413

Incident

Jul 12, 2021

Mileage

52,000 mi

Steering wheel is not too good and interior lighting lamp I have issues

NHTSA ID

11429784

Incident

Jun 7, 2021

T21 RECALL FOR EMISSIONS SYSTEM NOT LISTED ON YOUR SITE

NHTSA ID

11220657

Incident

Jun 15, 2019

Mileage

65,000 mi

VEHICLE WAS RECALLED FOR AN EMISSION CONTROL DEVISE ISSUE. I PHONED THE DODGE DEALER WHERE I HAD MY VAN SERVICED A FEW TIMES TO SCHEDULE THE RECALL WORK. THE SERVICE MANAGER SAID THEY NO LONGER SERVICE THE 2006 DODGE/MERCEDES SPRINTERS. I WENT AHEAD AND HAD MY VEHICLE SMOG TESTED. IT PASSED. I MAILED MY REGISTRATION AND PAYMENT. THIS IS NOT A SAFETY ISSUE. MY VEHICLE PASSED THE STRICT CA SMOG REQUIREMENTS. THERE IS NO REASON TO RECALL MY VAN OR HOLD UP MY REGISTRATION AS AN "INCOMPLETE RENEWAL".

NHTSA ID

11193637

Incident

Apr 1, 2019

2006 DODGE SPRINTER. CONSUMER WRITES IN REGARDS TO EMISSIONS SAFETY RECALL. *LD *JS

NHTSA ID

11074823

Incident

Jan 31, 2018

EMISSIONS RECALL. MANUFACTURER FCA TOTALLY UNRESPONSIVE. HOURS ON PHONE. DEALERS TOO CANNOT GET RESPONSE, VEHICLE COMPUTER SHUTS ENGINE OFF ON HIGHWAY AS ENGINE DETECTS PROBLEM. TRUCK CAN THEN BE RESTARTED USUALLY. FUMES BEGINNING. EUROPE SUING MANUFACTURER OVER THIS AND EPA MAY BE.FCA RECALL # IS T21

NHTSA ID

11053736

Incident

Nov 28, 2017

Mileage

44,000 mi

TL* THE CONTACT OWNS A 2006 DODGE SPRINTER 2500. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V833000 (SERVICE BRAKES); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

10967826

Incident

Dec 1, 2016

GEAR SHIFTER WAS ABLE TO BE MOVED FROM PARK TO NEUTRAL WITHOUT THE KEYS IN THE IGNITION OR THE "BYPASS" SWITCH BEING PRESSED. A 5 YEAR OLD WAS ABLE TO MOVE THE SHIFTER INTO NEUTRAL WITHOUT KEY IN THE IGNITION OR PRESSING THE BYPASS BUTTON WHICH ALLOWED THE VEHICLE TO ROLL DOWN A HILL.

NHTSA ID

10926223

Incident

Nov 15, 2016

Mileage

150,000 mi

THE LEFT DRIVERS SIDE ELECTRIC WINDOW HAS A BROKEN PIECE OF NYLON/PLASTIC THAT IS ABOUT 11/2" X 1/2", THAT IS HELD IN PLACE BY A RIVET THAT APPEARS TO LOOK LIKE A NAIL HEAD ON THE METAL WINDOW REGULATOR ARM. THIS FLIMSY PLASTIC PART BROKE INTO TWO PIECES WHICH ALLOWS THE ARM OF THE WINDOW REGULATOR TO POP OUT OF THE TRACK BELOW THE WINDOW, AND THE WINDOW FALLS DOWN AND STAYS OPEN. WHEN THIS HAPPENS IT CREATES NOISE, ALLOWS BAD WEATHER TO ENTER THE VEHICLE, AND CREATES A VERY DISTRACTING SITUATION FOR DRIVING, ESPECIALLY ON THE INTERSTATE HIGHWAY SYSTEM. THERE IS NO FIX FOR THIS SMALL PART ONLY A NEW REGULATOR WITH THE SAME FLIMSY PIECE OF PLASTIC. THE WINDOW REGULATOR COSTS BETWEEN $219 AND $224 PLUS TAX AND SHIPPING. THE COST TO INSTALL IT IS ANOTHER 200+ DOLLARS. THIS REGULATOR SUFFERS FROM POOR DESIGN AND SHOULD NOT BREAK ON A VEHICLE (RV) THAT IS NOT USED LIKE PERSONAL TRANSPORTATION VEHICLE. MY WINDOW OPENED SLOWLY AT 70MPH ON THE FREEWAY.

NHTSA ID

10821879

Incident

Dec 2, 2015

Mileage

54,000 mi

ON MORE THAN 1 OCCASION, MY VEHICLE DIED OUT WHILE TRAVELING ON EXPRESSWAYS. IN ALL INSTANCES, THE ENGINE STOPPED WORKING. FORTUNATELY NOBODY WAS INJURED. THE VEHICLE NEEDS AN ENGINE REPLACEMENT AGAIN AND HAS LESS THAN 69,000 MILES ON IT. *TR

NHTSA ID

10637980

Incident

Apr 8, 2011

Mileage

47,671 mi

I BOUGHT THIS VAN NEW IN APRIL 2006. THE VAN CAME WITH AN E.O.M. ROOF A/C WHICH IS THE CAUSE FOR THE VEHICLE STALLING WHEN DECELERATING. THE FIRST TIME THIS HAPPENED WAS ABOUT 2 MONTHS AFTER WE BOUGHT THE VAN. I REPORTED THIS INCIDENT TO THE DEALERSHIP AND WAS TOLD THAT DODGE WAS AWARE OF IT AND WOULD ISSUE A RECALL AS SOON AS IT HAS A FIX - IT NEVER DID. THE CURRENT ODOMETER READING IS 35,125 MILES. THE VAN WAS MOSTLY DRIVEN SHORT DISTANCES AS I USE IT MAINLY TO TRANSPORT MY WHEELCHAIR BOUND DAUGHTER TO AND FROM DOCTORS AND HOSPITALS VISITS.TIME WENT BY UNTIL IT HAPPENED AGAIN. IT APPEARED THAT THE STALLING, THE ENGINE SUDDENLY SHUT OFF WHEN THE ROOF A/C IS RUNNING WHILE THE ENGINE IS AT A CERTAIN TEMPERATURE. I CONTACTED DODGE WHICH TOLD ME THAT MY WARRANTY HAD EXPIRED. IT WOULD COST APPROXIMATELY $1000 TO INSTALL THE "REAR A/C IDLE CUTOUT MODULE". AFTER DOING SOME RESEARCHES, I FOUND OUT THAT THERE WAS A DODGE SERVICE BULLETIN # 24-001-2009 DATED APRIL 24, 2009 WITH SUBJECT: IDLE INSTABILITY - REAR A/C IDLE CUTOUT MODULE INSTALLATION. IN MY OPINION THE STALLING WAS CAUSED BY A DESIGN FLAW WHICH THE MANUFACTURER SHOULD FIX REGARDLESS OF THE WARRANTY TIME LIMIT. COULD YOU HELP US WITH THIS ISSUE? *JS

NHTSA ID

10585753

Incident

Jun 21, 2006

Mileage

1,200 mi

TL* THE CONTACT OWNS A 2006 DODGE SPRINTER 2500. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE BEGAN TO DECELERATE. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND SHUT OFF. UPON RESTART, THE VEHICLE OPERATED AS NORMAL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 48,500.

NHTSA ID

10427574

Incident

Sep 20, 2011

Mileage

48,500 mi

COMPLAINT FOR A 2006 DODGE SPRINTER DIESEL (MERCEDES BUILT) ENGINE TURBO RESONATOR. THIS PART HAS FAILED AND BEEN REPLACED THREE TIMES SINCE 2006. IT FAILS WITHOUT WARNING RESULTING IN A SHARP AND UNSAFE DROP IN UPHILL SPEED, PARTICULARLY IN INTERSTATE AND MOUNTAINOUS TRAVEL. *TR

NHTSA ID

10419384

Incident

Apr 20, 2007

I WAS DRIVING ON A RELATIVELY FLAT ROAD AND HEARD A POP NOISE FROM THE ENGINE AREA AND THE VEHICLE LOST APPROXIMATELY 40 TO 60% ENGINE POWER, I WAS ABLE TO GET IT TO MY HOME LESS THAN 5 MILES DISTANCE, I GOT IT INTO A SHOP FOR REPAIRS AND THEY WERE NOT AN AUTHORIZED WARRANTY REPAIR SHOP, WHICH COST ME $404. I THEN HAD THE VEHICLE TOWED TO AN AUTHORIZED REPAIR FACILITY APPROXIMATELY 35 MILES AWAY.

NHTSA ID

10411210

Incident

Mar 1, 2011

Mileage

10,590 mi

2006 DODGE SPRINTER 2500 DIESEL. PASSENGER VEHICLE. PURCHASED BRAND-NEW IN 2007. APPROXIMATELY 34,000 MILES. VEHICLE WENT INTO LIMP MODE 2 TIMES. WOULD NOT GO OUT OF SECOND GEAR. AFTER SHUT DOWN AND RESTART VEHICLE RAN NORMAL. ON NUMEROUS OTHER OCCASIONS RPMS WOULD RISE BUT VEHICLE DIDN'T SEEM TO BE MOVING ENOUGH TO WARRANT ALL THAT REV. AS IF TRANSMISSION SLIPPING. *TR

NHTSA ID

10397244

Incident

Apr 8, 2011

Mileage

34,000 mi

TL* THE CONTACT OWNS A 2006 DODGE SPRINTER WITH GOODYEAR WRANGLER SILENT ARMOR TIRES, LINE SIZE LT225/75/R16, THE CONTACT STATED THAT ALL FOUR TIRES EXPERIENCED SIDEWALL SEPARATION AND THEY WOULD BLOW UP INTO A BALL. THE VEHICLE WAS INSPECTED BY A TIRE DEALER AND THEY ADVISED HIM THAT THERE WERE NO DEFECTS WITH THE BRAND OR LINE OF TIRES. THE TIRES WERE REPLACED AS THE CONTACT STATED THAT WAS THE SECOND REPLACEMENT OF THE TIRES WITHIN SIX MONTHS. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.

NHTSA ID

10397047

Incident

Nov 18, 2010

Mileage

20,000 mi

TL* THE CONTACT OWNS A 2006 DODGE SPRINTER 2500. THE CONTACT STATED THAT THE VEHICLE WOULD INDEPENDENTLY DECELERATE FROM ANY SPEED WITHOUT WARNING. THE DEALER REPLACED THE TURBO RESONATOR YET THE FAILURE PERSISTED. THE DEALER ALSO REPLACED THE AIR FILTER TO NO AVAIL. THE DEALER ACKNOWLEDGED THAT THE VEHICLE WAS LOSING POWER ABNORMALLY BUT COULD NOT PROVIDE AN ADEQUATE REPAIR. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 60,000.

NHTSA ID

10360646

Incident

Aug 8, 2008

Mileage

30,000 mi

RESONATOR FAILURE ON A 2006 DODGE SPRINTER (WINNEBAGO VIEW). WHEN THE RESONATOR BREAKS, IT POSES A SIGNIFICANT DANGER OF AN ACCIDENT OCCURRING DUE TO THE SUDDEN AND COMPLETE LOSS OF ENGINE POWER. THIS SUDDEN RAPID DECELERATION WITHOUT ANY WARNING SIGN OF ANY KIND CAUSES A SERIOUS AND UNACCEPTABLE SAFETY HAZARD NOT ONLY TO US BUT ALSO TO ANY OTHER PERSON ON THE ROAD. IT HAS BROKEN DOWN ON MAY 17, 2007, MAY 27, 2009 AND AUGUST 17, 2010. REPAIR WAS MADE BY REPLACING THE RESONATOR. *TR

NHTSA ID

10356026

Incident

May 17, 2007

Mileage

2,890 mi

AUGUST 22, 2010, I WAS ON I 25 IN MY WINNEBAGO ITASCA NAVION TRAVELING AT 60 TO 70 MPH AND SUDDENLY LOST POWER. I STOPPED, GOT MORE DIESEL AND STARTED DRIVING AT LOWER SPEEDS BY STILL LOST POWER AND COULD BARELY CLIMB HILLS. I WAS JUST LIMPING ALONG WITH MY EMERGENCY FLASHERS ON HOPING I WOULDN'T BE REARENDED. THE MODEL IS 2006 WITH A MERCEDES/BENZ 5 CYLINDER TURBO ENGINE WITH 19,500 MILES ON IT. THIS IS REALLY DANGEROUS. IS THERE A RECALL ON THIS ENGINE? *TR

NHTSA ID

10351184

Incident

Aug 22, 2010

Mileage

19,500 mi

RESONATOR FAILED AT 15,200 MILES CAUSING A DANGEROUS SITUATION. MY SPRINTER WAS PURCHASED FROM MAXWELL DODGE IN AUSTIN TX ON MY BEHALF BY SPORTSMOBILE IN AUSTIN WHO DID AN RV CONVERSION ON IT. THE NEAREST AUTHORIZED DEALER FROM MY HOME IS MOSS BROTHERS DODGE IN SAN BERNARDINO CA THEY REPLACED THE RESONATOR ON 9/18/09 WITH MILEAGE AT L5,308. WITH REPORTS OF MULTIPLE FAILURES, INCLUDING FAILURES OF A NEWER REVISION, I AM CONCERNED FOR MY SAFETY AND OTHERS. MY VAN IS USED EXCLUSIVELY FOR CAMPING, USUALLY IN REMOTE MOUNTAIN AREAS WITH NARROW STEEP ROADS, OFTEN WITHOUT GUARD RAILS WHICH DO NOT HAVE AREAS TO PULL OVER OR PASS. THIS WOULD ENDANGER LIVES IN THE EVENT OF A RESONATOR FAILURE WHICH MAKES THE VEHICLE INCAPABLE OF MOVING ON AN INCLINE AS WELL AS DANGEROUS ON A FREEWAY WHEN IT SUDDENLY LOSES POWER. IN MY RESEARCH I FOUND AN ALUMINUM RESONATOR WHICH ELIMINATES THE PROBLEM. MOSS BROTHERS DODGE TOLD ME THEY HAVE INSTALLED THIS RESONATOR, HOWEVER THE CUSTOMER HAS TO PROVIDE IT AND SIGN A WAIVER BECAUSE IT DOES NOT HAVE A FILTER. IF A PROBLEM OCCURS WITH THE TURBO WHICH IS DETERMINED TO BE CAUSED BY PARTICLES THAT GOT THROUGH THE SYSTEM, IT WOULD NOT BE COVERED BY THE WARRANTY. PLEASE ADVISE ME ON HOW TO HANDLE THIS DANGEROUS SITUATION. UPDATED 10/26/10. *LJ UPDATED 10/26/10 *TR

NHTSA ID

10348580

Incident

Sep 17, 2009

Mileage

15,052 mi

SUDDEN SLOW DOWN DUE TO LOST OF POWER ON WINNEBAGE VIEW/DODGE SPRINTER. THIS HAS HAPPENED FOUR TIMES RESULTING IN HAZARD TO OTHER DRIVERS FROM SUDDEN REDUCTION IN SPEED WITH NO BRAKE LIGHTS. THREE REPAIRS MADE BY DEALERS FOR SAME PROBLEM (TURBIN RESONATOR) IN 24,000 MILES. THE VEHICLE WILL CONTINUE TO RUN BUT BARELY. THE FIRST INCIDENT WAS AT 7,000 MILES. THE LAST AT 24,000 MILES. *TR

NHTSA ID

10343488

Incident

Oct 21, 2007

Mileage

7,000 mi

MY DODGE SPRINTER, 2006, WINNEBAGO'S TURBO RESONATOR HAS FAILED ON ME TWICE, 11-5-2007 AND 5-28-2010. THE FAILURE IS FAST AND THE SPRINTER GOES DOWN TO 10 TO 40 MPH WHICH IS VERY DANGEROUS! CHRYSLER HAS REPLACED THE RESONATOR BOTH TIMES BUT OBVIOUSLY IT WILL FAIL AGAIN! *TR

NHTSA ID

10336609

Incident

May 28, 2010

Mileage

17,000 mi

THE SEAT BELT RETRACTOR AND SRS LOCKUP ASSEMBLY IN THE 2006 DODGE/ MERCEDES SPRINTER VAN IS PRONE TO COMPLETE FAILURE IN HOT CLIMATES. THE RETURN SPRING AND LOCKUP HOUSING IS MADE OF PLASTIC WHICH BECOMES DISFIGURED AND IS RENDERED INOPERABLE AND THEREFORE UNSAFE, LEAVING THE FRONT OCCUPANTS UNKNOWINGLY UNPROTECTED. MANY OWNERS HAVE REPLACED SRS RETRACTORS WITH AFTERMARKET BELTS. UNSUSPECTING OWNERS MUST BE NOTIFIED OF THIS IMPENDING FAILURE. *TR

NHTSA ID

10335513

Incident

May 27, 2010

Mileage

18,000 mi

TL*THE CONTACT OWNS A 2006 DODGE SPRINTER 2500. THE CONTACT STATED THAT WHEN HE ATTEMPTED TO USE THE VEHICLE, HE NOTICED A FIRE HAD TAKEN PLACE IN THE CABIN OF THE AROUND THE INSTRUMENT PANEL. THE CONTACT CALLED THE MANUFACTURER AND AN INVESTIGATOR WAS SENT OUT TO LOOK AT THE VEHICLE. THE CONTACT WAS INFORMED THAT THE FAILURE WAS AN ISOLATED INCIDENT AND THEY DID NOT KNOW WHAT CAUSED THE FIRE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 30,000.

NHTSA ID

10335073

Incident

Jun 1, 2010

Mileage

30,000 mi

FAULTY TURBO RESONATOR ON A MOTORHOME DODGE SPRINTER 2006 THE PROBLEM WITH THE POWER RESONATOR IS THAT THE SPEED IS SUDDENLY REDUCED AND OTHER VEHICLE BEHIND MUST BRAKE OR CHANGE IS SHORT NOTICE DUE TO THE REDUCED SPEED FORM AN AVERAGE OF 65 MILES TO 20 MILES IN NO TIME BECAUSE OF THE POWER FAILURE. THIS CONDITION HAPPENED TO ME E TIMES IN THE LAST 2 YEARS, FINALLY I CHANGED THE PLASTIC FAULTY RESONATOR FOR AN AFTERMARKET STRAIGHT ALUMINUM RESONATOR , BUT WITH THIS CHANGE NOW I HAVE MORE NOISE IN THE CABIN. *TR

NHTSA ID

10331261

Incident

May 7, 2010

Mileage

28,000 mi