2006 Dodge Sprinter 3500 Problems

2006 DODGE SPRINTER 3500. CONSUMER WRITES IN REGARD TO EGR VALVE FAILURE. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR. THE PARTS WERE UNAVAILABLE.

I HAVE TWO RECALLS THAT NEEDS TO BE DONE BY A DODGE DEALER WHICH I TRIED TWO YEARS AGO WITH NO SUCCESS, THE FIRST ONE IS BRAKE LIGHT RECALL NONE OF THE DODGE DEALERS IN MY AREA UP TO 50 MILES RADIUS WERE ABLE TO FIX THE RECALL. NOW I AM TRYING TO REGISTER MY VEHICLE WITH DMV AND I WAS TOLD ABOUT THE PROOF OF CORRECTION THAT I NEED TO PROVIDE FOR AN EMISSION RECALL. I CALLED MULTIPLE DODGE DEALERS WITH NO SUCCESS TO HAVE IT WORKED ON PLUS I WAS SUGGESTED TO CALL MERCEDES BENZ SINCE IT IS A MERCEDES ENGINEERED VEHICLE AND SINCE ITS A DODGE THEY WON'T DO THE RECALL. NOW I AM STUCK WITH A VEHICLE I CAN GET FIXED AND REGISTERED. THE VEHICLE IS MY WORK VEHICLE AND I CAN'T DO ANY WORK/INCOME BECAUSE IT CAN'T BE REGISTERED.PLEASE ADVICE

The contact owns a 2006. Dodge Sprinter 3500. The contact received notification of NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic), and Emissions Recall T21 Reprogram Engine Control Unit however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Dodge Sprinter 3500. The contact received a recall notification for NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic) and for an unknown Manufacturer recall for the engine control unit failure however, the dealer informed the contact that the parts for the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and advised the contact that they would assist with locating a dealer who could complete the recall repairs. A case was opened. The contact was awaiting a call back from the manufacturer. The contact had not experienced a failure. Parts distribution disconnect. Consumer stated the recall items were issued sometime early on (2006) and the timeline for repairing the recall items is 2006-Dec 2021. 12 dealers were contacted and none could work on it and consumer still has two recall items pending.

The contact owns a 2006. Dodge Sprinter 3500. The contact received notification of NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic), and Emissions Recall T21 Reprogram Engine Control Unit however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2006 Dodge Sprinter 3500. The contact received a recall notification for NHTSA Campaign Number: 16V833000 (Electrical System, Service Brakes, Hydraulic) and for an unknown Manufacturer recall for the engine control unit failure however, the dealer informed the contact that the parts for the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and advised the contact that they would assist with locating a dealer who could complete the recall repairs. A case was opened. The contact was awaiting a call back from the manufacturer. The contact had not experienced a failure. Parts distribution disconnect. Consumer stated the recall items were issued sometime early on (2006) and the timeline for repairing the recall items is 2006-Dec 2021. 12 dealers were contacted and none could work on it and consumer still has two recall items pending.

THE NEXT TIME OUR HEADLIGHTS FAILED WAS ABOUT 30,000 MILES LATER. THE BRIGHTS STILL WORKED AND ALSO THE RUNNING LIGHTS BUT THE REGULAR HL DID NOT. ON INTERSTATES THIS WAS NOT TOO MUCH TROUBLE BUT I'M SURE WE WERE AN AGGRAVATION TO A FEW DRIVERS COMING OUR WAY. WE WENT TO A DODGE DEALER (CAMPED IN HIS DRIVEWAY) AND ASKED FOR TROUBLESHOOTING THE NEXT MORNING. THEY FOUND NO PROBLEM, BUT AGAIN, THE NEXT NIGHT, WE HAD THE SAME PROBLEM, BEFORE WE GOT HOME TO NW FLORIDA WHERE OUR LOCAL DEALER AGAIN FOUND NO PROBLEM. I THINK THERE IS AN INADEQUATE GROUND TO THE MAIN HEADLIGHT CIRCUIT. THERE ARE SEPARATE FUSES FOR THE HEADLIGHTS, RUNNING LIGHTS AND BRIGHT LIGHTS, ON EACH SIDE OF THE VEHICLE (6 IN ALL). THE FUSES ARE ALL ALRIGHT. WHEN I CHECK THE LIGHTS IN OUR DRIVEWAY THEY SEEM TO WORK FINE NOW.... *TR

WHILE DRIVING, ON HIGHWAY SAW SMOKE COMING FROM RIGHT SIDE OF DASH, PULLED OVER, FLAMES OBSERVED, USED FIRE EXTINGUISHER TO PUT OUT FIRE UNDER DASH. ENTIRE WIRING LOOM FOR DASH AND ENGINE WERE DESTROYED. $16000+ DAMAGE, MANUFACTURER TOOK 3+ MONTHS TO PROVIDE HARNESS. *TR

WE HAVE HAD THREE VACATIONS THAT HAVE BEEN RUINED DUE TO THE FAILURE OF THE TURBO RESONATOR IN OUR 2006 WINNEBEGO VIEW WITH A 2005 SPRINTER ENGINE. WE HAVE HAD FAILURE GOING OVER THE LOS ANGLES GRAPVINE GRADE, THE NORTHERN CALIFORNIA, 101 CORRIDOR AND JUST THIS PAST WEEK, THE SIERRA MT. RANGE GOING INTO RENO, NV. ON OUR WAY TO YELLOWSTONE. THREE VACATIONS RUINED, THREE TURBO RESONATORS LATER AND LOTS OF MONEY, TIME AND STRESS. NOT SURE WHY WE HAVE NOT RECEIVED A RECALL ON THIS PLASTIC PIECE OF JUNK THAT HAS PUT OUR LIVES IN DANGER??? *TR

2006 DODGE SPRINTER TRUCK. CONSUMER STATES SEVERAL ISSUES WITH VEHICLE LEADING TO BREAK DOWNS *TGW THE DEALER NOTED THE VEHICLE LACKED POWER AND WOULD NOT ACCELERATE PROPERLY. THE VEHICLE WOULD ESPECIALLY LOOSE POWER WHILE DRIVING ON AN INCLINE. ONE YEAR LATER, THE RESONATOR WAS REPLACED. THE VEHICLE BROKE DOWN AGAIN ON MARCH 27, 2009. THE CONSUMER WAS INFORMED THE LOCK WASHER ON THE LUG NUT FOR THE DRIVERS SIDE FRONT TIRE HAD BEEN IMPROPERLY PUT ON THE TIRE. THE BRAKE LIGHT AND TAIL LIGHT BULBS WERE REPLACED. THE EGR VALVE WAS STICKING, THE BATTERY WAS REPLACED, THE TURBO WAS LEAKING OIL IN THE INTAKE TRACK, THE TRANSMISSION ADAPTER PLUG WAS LEAKING, THE CHECK ENGINE LIGHT ILLUMINATED, THE HARMONIC BALANCER AND WATER PUMP WERE REPLACED.*JB

2006 DODGE SPRINTER TRUCK. CONSUMER STATES SEVERAL ISSUES WITH VEHICLE LEADING TO BREAK DOWNS *TGW THE DEALER NOTED THE VEHICLE LACKED POWER AND WOULD NOT ACCELERATE PROPERLY. THE VEHICLE WOULD ESPECIALLY LOOSE POWER WHILE DRIVING ON AN INCLINE. ONE YEAR LATER, THE RESONATOR WAS REPLACED. THE VEHICLE BROKE DOWN AGAIN ON MARCH 27, 2009. THE CONSUMER WAS INFORMED THE LOCK WASHER ON THE LUG NUT FOR THE DRIVERS SIDE FRONT TIRE HAD BEEN IMPROPERLY PUT ON THE TIRE. THE BRAKE LIGHT AND TAIL LIGHT BULBS WERE REPLACED. THE EGR VALVE WAS STICKING, THE BATTERY WAS REPLACED, THE TURBO WAS LEAKING OIL IN THE INTAKE TRACK, THE TRANSMISSION ADAPTER PLUG WAS LEAKING, THE CHECK ENGINE LIGHT ILLUMINATED, THE HARMONIC BALANCER AND WATER PUMP WERE REPLACED.*JB

WE HAVE HAD THREE VACATIONS THAT HAVE BEEN RUINED DUE TO THE FAILURE OF THE TURBO RESONATOR IN OUR 2006 WINNEBEGO VIEW WITH A 2005 SPRINTER ENGINE. WE HAVE HAD FAILURE GOING OVER THE LOS ANGLES GRAPVINE GRADE, THE NORTHERN CALIFORNIA, 101 CORRIDOR AND JUST THIS PAST WEEK, THE SIERRA MT. RANGE GOING INTO RENO, NV. ON OUR WAY TO YELLOWSTONE. THREE VACATIONS RUINED, THREE TURBO RESONATORS LATER AND LOTS OF MONEY, TIME AND STRESS. NOT SURE WHY WE HAVE NOT RECEIVED A RECALL ON THIS PLASTIC PIECE OF JUNK THAT HAS PUT OUR LIVES IN DANGER??? *TR

MY 2006 SPRINTER DIESEL HAS HAD A RESONATOR FAILURE WHICH CAUSED A SUDDEN LOSS OF POWER - IF THIS HAD HAPPENED AT THE WRONG TIME IT COULD HAVE BEEN DEADLY. THE FAILURE HAPPENED WITHIN A FEW THOUSAND MILES AND WAS REPAIRED BY THE MANUFACTURER UNDER WARRANTY. HOWEVER, THERE HAS NOT BEEN ANY RECALL THAT I AM AWARE OF AND AFTER A WEB SEARCH IT APPEARS THERE SHOULD BE - THE REPLACEMENT PARTS ARE NOT AN IMPROVEMENT AND AS A RESULT THE FAILURE HAS OCCURRED MORE THAN ONCE FOR MANY OWNERS. IT IS CLEARLY A SAFETY ISSUE GIVEN THE SUDDEN NATURE OF THE LOSS OF POWER AND THE POTENTIAL FOR IT TO HAPPEN WHEN PULLING INTO TRAFFIC OR PASSING ANOTHER VEHICLE ETC. *TR