Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Fuel system reportsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
12
Latest Dec 6, 2022
Share of all reportsThis category as a share of every owner report on file for this model year. One report can name more than one component, so the categories overlap.
7%
of 164 total
Crash or fire reportedReports in this category whose submitter recorded that a crash or a fire occurred. The reporter's own answer on the NHTSA form, not a verified finding.
1
Injuries or deaths reportedTotals the submitters entered on their own reports in this category. Not verified by NHTSA and not a casualty statistic.
1
What this page shows
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2013 Fiat 500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 12 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Owner reports naming fuel system
Shown in the owner’s own words, exactly as filed
Fuel system
Filed Dec 6, 2022
In 2019 my 2013 500e wouldn't start/take a charge. I towed it to the dealer and after more than a month and $2250 they replaced the PIM module and HV battery pack. Fast forward to 2022 and I received the SERVICE ELECTRIC VEHICLE SYSTEM error. I drove the car to the dealer. They are claiming the failure is the HV battery cooling system is leaking coolant in to the battery itself and the only repair is full replacement. They are also claiming the battery is not under any warranty at this time. Any thoughts or advice on next steps would be appreciated. I cannot believe the HV battery would need to be replaced twice in 3 years.
NHTSA ID
11496179
Incident
Dec 2, 2022
Fuel system
Filed Apr 2, 2022
When putting gasoline at the gas pump, pump clicks off constantly. Makes you think the tank is full when it is not, Have to pump very slow. takes 10-15 mins to fill up and have to know how many gallons are needed.
NHTSA ID
11459309
Incident
Jan 1, 2020
ElectricalFuel systemExterior lighting
Filed Feb 22, 2022
Ed Payne Chrysler Dodge Jeep RAM 2101 E Expressway 83, Weslaco, TX 78599 +1 956-272-1902 For the past years, I have complained to the car dealer I take my vehicle into that there is an issue with the fuel tank. I have been told that other Fiat car owners have had the same issues as I. Issues, the 2013 - 2014 Fait Sport 500, tank issue, when filling up the tank, the tank does not fill up normal. When filling up the gas take, the gas handle stops every 10 sec, I have to keep clicking on the gas pump handle every 10 sec. To keep the flow of gas to fill the gas tank up. I was told by the car dealer that the issue was the gas tank on the Fait, not the gas pump machine. When adding a new gas tank to the vehicle, the problem stop, and the owners were able to fill the gas tank without any issues. I keep having headlights, blinkers, stop lights burn out all the time. I believe there's an issue with the wiring in the Fait Sport 500.
NHTSA ID
11453372
Incident
Mar 4, 2019
Fuel systemExterior lighting
Filed Dec 7, 2020
DEALRS ARE AWARE OF THE FUEL TANK ISSUES, IT REFUSE TO FILL THE TANK THE NORMAL WAY. YOU HAVE TO KEEP PUMPING EVER SECOND UNTIL THE FULE TANK IS FULL. DEAL ADVICE TO CORRCT THE ISSUE, THE FUL TANK WAS BE REPLACE A $1000 ? VALUE. I REPORTED THE ISSUE AUG 8,2020 CASE # 76990681 TO THE FCA/MOPAR 800-853-1403. NOTHING HAS BEEN CORRECTED ON THE ISSUE, IM STILL HAVING PROBLEMS FUELING MY CAR WITH GAS. ELECTRIC ISSUE AS WELL, FRONT AND REAR LIGHT BUBBLE KEEP BURING OUT. DEALER NAME ED PAYNE2101 E EXPRESSWAY 83, WESLACO, TX 78599 (956) 272-1902
NHTSA ID
11378251
Incident
Feb 3, 2020
EngineFuel systemPowertrain (other)
Filed May 2, 2020
HELLO, I BELIEVE I NEED AN ATTORNEY AND LEGAL ADVICE. I HAVE A DEFECTIVE CAR THAT SHOWS ON THE FIAT DEALERSHIP WEBSITE AS A RECALL. THE YEAR MAKE AND MODEL OF MY CAR HAS A RECALL (2/2013 RECALL N09 REPROGRAM POWERTRAIN CONTROL MODULE) I HAVE HAVE BEEN REPORTED MY ISSUE TO FIAT DEALERSHIP FOR THE LAST THREE YEARS AND WAS TOLD THAT BASED ON MY VIN NUMBER I DO NOT HAVE A RECALL. WHEN I SERVICE MY CAR AT DEALERSHIP THEY JUST TURN OFF MY ENGINE LIGHT. I HAVE NOT BEEN ABLE TO PASS INSPECTION OF MY VEHICLE IN OVER TWO YEARS. MY MECHANIC EXPLAINED TO ME THAT I HAVE A RECALL AND HE CANNOT PASS INSPECTION. I AM AFRAID TO DRIVE MY CAR, BUT CANNOT SELL IT OR TRADE IT IN DIE TO THE ENGINE LIGHT ERROR. I HAVE A RECORD OF ALL OF MY RECEIPTS. THIS STARTED IN JANUARY 2018. I BELIEVE THAT I SHOULD FILE CHARGES AGAINST FIAT AND WOULD NEED LEGAL ADVISE. THANK YOU.
NHTSA ID
11323015
Incident
May 1, 2020
Fuel system
Filed Dec 6, 2019
WHEN ATTEMPTING TO FILL UP GAS AT A FUEL FILLING STATION THE CAR WILL NOT TAKE IN ANY FUEL FROM THE GAS STATION PUMP. IT REACTS LIKE THE TANK IS FULL BUT IT IS NOT. A VERY SMALL STEADY FLOW OF FUEL WILL FLOW (APPROX 20CENTS) AND THEN OVERFLOW AS IF IT IS FULL. THIS IS A DANGEROUS PROBLEM AT THAT THE GAS PUMP AND HAS ALSO CAUSED ME TO RUN OUT OF FUEL ON THE FREEWAY AS WELL WHICH COULD CAUSE SERIOUS ACCIDENTS. FIAT DEALER SAYS THEY HAVE NOT HEARD OF THIS ISSUE, BUT I AM FINDING 1000'S OF OWNERS ONLINE WITH THE SAME ISSUE.
NHTSA ID
11287463
Incident
Dec 6, 2019
Mileage
81,000 mi
Fuel system
Filed Feb 1, 2019
FUEL TANK ROLL-OVER VALVE MALFUNCTION. IMPROPER FUELING OF VEHICLE RESULTING
NHTSA ID
11173454
Incident
Nov 2, 2017
Mileage
9,830 mi
ElectricalFuel systemPowertrain (other)
Filed Nov 19, 2018
LOSS OF MOTIVE POWER WHILE I DRIVE AND I HAVE TO PULL OVER ON THE HIGHWAY. THIS HAS HAPPENED MANY TIMES. I HAVE TAKEN THE CAR TO FIAT AND THEY HAVE NOT FIXED THE ISSUE. FIAT HAS A RECALL ON MY TYPE OF CAR EXCEPT FCA US LLC SAID MY VIN IS NOT INCLUDED. NHTSA CAMPAIGN ID # 16V302000. I DO NOT WANT PASSENGERS TO BE IN MY CAR BECAUSE OF THE RISK OF DEATH. THERE IS A SIGNIFICANT DANGER TO MYSELF AND OTHERS.
NHTSA ID
11152547
Incident
Nov 8, 2018
Mileage
21,000 mi
EngineFuel systemPowertrain (other)
Filed Jun 21, 2017
COMPLETE LOSS OF POWER WHEN DRIVING , I FILED FOR LEMON LAW. I WON. NOW THEY ARE GOING TO SELL THIS CAR ON THE INTERNET AS A BUY BACK.
NHTSA ID
11000504
Incident
Oct 30, 2016
Mileage
1,400 mi
Driver assistanceElectricalFuel system
Filed Apr 12, 2017
MY CAR CUTS OFF WHILE DRIVING OR BEING IDLED. I WOULD DRIVE IT IN THE CITY AND AFTER ABOUT 20-30 MINUTES OF DRIVING STOP AND GO. IT WOULD CUT OFF WHILE I'M STOPPED AT A LIGHT. THEN I WOULD PUT IT IN PARK AND IT WOULD RESTART. THEN AFTER THAT IT WOULD READ AS HIGH COOLANT. ALSO GOING UP STEEP HILLS IT WOULD CUT OFF WHEN I TURN IT AT THE TOP OF THE HILL AND READ NOTHING JUST COMPLETELY TURN OFF. I FINALLY GOT TO REPLICATE THE PROBLEM WITH FIAT SERVICE AND THEY ARE TRYING TO FIGURE OUT HOW TO STOP IT FROM CUTTING OFF. THIS SHOULD BE A RECALL AND REPLACE BY FIAT
NHTSA ID
10972136
Incident
Mar 28, 2017
Body & structureFuel system
Filed Jun 5, 2015
Crash reported1 injury reported
MY 2013 FIAT ABARTH WAS REAR ENDED. I WAS STOPPED. THE OTHER DRIVER, IN A GRAND CHEROKEE, REAR ENDED ME. HIS SPEED WAS APPROXIMATELY 20-30 MPH. I WAS KNOCKED UNCONSCIOUS BRIEFLY & HAD SEVERE HEAD PAIN. I AM STILL UNDERGOING TREATMENT. NONE OF MY CARS SAFETY FEATURES WORKED, INCLUDING THE FUEL PUMP SHUT OFF. I BELIEVE THE SEAT HIT ME IN THE HEAD. THE ABARTH HAS UNIQUE, HIGH BACKED SEATS WITH A FIXED / INTEGRATED HEAD REST WITH A HARD, PLASTIC INSERT. MY SEATBELTS FAILED TO TIGHTEN AND THE FUEL PUMP FAILED TO SHUT OFF. I WORKED FOR CHRYSLER FIAT AT THE TIME AND DID TELL PEOPLE IN ENGINEERING ABOUT THE CONCERN. I SUFFERED A CONCUSSION & NOW HAVE CONSTANT, DAILY HEADACHES AND MIGRAINES.
NHTSA ID
10723542
Incident
May 7, 2014
Mileage
12,000 mi
Fuel system
Filed Aug 6, 2014
TL* THE CONTACT OWNS A 2013 FIAT 500. THE CONTACT STATED THAT WHILE DRIVING 30 MPH ON THE HIGHWAY, THERE WAS A ROCK OR METAL PIECE THAT HIT THE FUEL TANK. THE FUEL FROM THE GAS TANK LEAKED OUT OF THE TANK AND ONTO THE ROAD. THE VEHICLE WAS PULLED OVER TO THE RIGHT. THE VEHICLE WAS TOWED TO A LOCAL DEALERSHIP. THE DIAGNOSIS ON THE VEHICLE WAS A FAULTY FUEL TANK. THERE WERE NO REPAIRS COMPLETED ON THE VEHICLE. THE FAILURE MILEAGE WAS 22,000.
NHTSA ID
10619350
Incident
Aug 4, 2014
Mileage
22,000 mi
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Other components reported on this vehicle
Categories with enough reports to have a page of their own