2014 Fiat 500E Electrical Problems

I RECEIVED RECALL ET189675 U69 IN THE MAIL. I THEN SETUP AN APPOINTMENT WITH OUR LOCAL FIAT DEALER TO HAVE THE SOFTWARE UPDATE DONE. THEY TOLD ME THEY DO NOT DO SERVICE ON ELECTRIC MODELS AND I SHOULD GO TO THE CLOSEST DEALER 112 MILE AWAY. I EXPLAINED MY RANGE IS 87 MILES ON A FULL CHARGE. SO I CALLED THE MANUFACTURER BUT THEY WOULD NOT COVER TOWING AND WERE UNABLE TO MAKE THE LOCAL DEALER DO THE SOFTWARE UPDATE. THIS DEALER DID A PREVIOUS RECALL UPDATE BATTERY VENT PLUGS ON MY CAR. THIS UPDATE PROTECT THE MAIL BATTERY AGAINST DAMAGE. THE CAR IS STILL FULLY FUNCTIONAL WITHOUT THE UPDATE BUT I'M OUT OF WARRANTY EXCEPT FOR THE BATTERY , I ASSUME?

NHTSA ID

11192770

Incident

Mar 26, 2019

Mileage

21,000 mi

IT'S A PURE ELECTRIC CAR. THE PLUG ON THE 110V CHARGER OFTEN HEATS UP. IT BURNED/BLACKENED TWO OF THE OUTLETS WHERE I NORMALLY CHARGE THE CAR IN TWO DIFFERENT HOMES. IT GOT TO THE POINT WHERE ONE OF THE PRONGS OF THE CHARGER PLUG WAS FALLING OUT. I FELT THERE WAS A SAFETY HAZARD OF EITHER THE PRONG GETTING STUCK IN THE OUTLET OR A POSSIBLE FIRE. THE DEALER IS FAR AWAY SO I HESITATED IN BRINGING IT IN. BUT I BEGAN TO BE WORRIED AS I SMELLED THE BURNING PLASTIC IN THE MORNING WHEN I CAME TO UNPLUG THE CAR. WHEN I FINALLY BROUGHT THE CAR IN, THE SERVICE MANAGER ORIGINALLY TOLD ME IT WAS MY FAULT AND TO GO HOME WITH THE BROKEN CHARGER AS I WAS REQUIRED TO HAVE A 30AMP, 110V OUTLET. IN REALITY THERE ARE NO 110V 30AMP OUTLETS AND THE CHARGER IS RATED AT 12AMPS AND THE MANUAL SAYS 15 AMP OUTLET (WHICH IS THE STANDARD OUTLET). AFTER I INSISTED, THEY FINALLY DECIDED TO CHANGE THE CHARGER BUT TOLD ME THEY WOULDN'T DO IT AGAIN. ON THE INVOICE THEY STATED THE CHARGER WAS DEFECTIVE. I HAVE INCLUDED A COPY OF TEXT MESSAGES BETWEEN MYSELF AND THE SERVICE MANAGER AS WELL AS INVOICE FOR THE REPAIR WHERE THEY STATE THE CHARGER WAS DEFECTIVE.

NHTSA ID

10875706

Incident

May 27, 2016

Mileage

20,722 mi

I HAVE TWO OPEN RECALLS (14V-235:P23) AND (15V-179:R15) THAT MY DEALER AND MANUFACTURER HAVE SO FAR BEEN UNABLE TO PERFORM REPAIRS TO CORRECT. I HAVE BEEN WAITING 21 MONTHS FOR ONE OF THE RECALLS AND 10 MONTHS FOR THE SECOND WITH NO COMMUNICATION FROM DEALER AND NO HELP FROM FIAT. I AM NOW UNABLE TO RENEW MY REGISTRATION DUE TO THESE RECALLS NOT BEING PERFORMED. I WOULD LIKE TO KNOW HOW TO PROCEED SINCE I AM NOW PAYING A LEASE PAYMENT FOR A CAR I AM UNABLE TO DRIVE LEGALLY ON THE ROAD SINCE MY REGISTRATION HAS EXPIRED AND I AM UNABLE TO RENEW IT BEFORE THE RECALL IS COMPLETED.

NHTSA ID

10861607

Incident

Jul 3, 2014

DEC. 2015 CAR WAS INVOLVED IN A HEAD ON COLLISION ESTIMATED 30MPH. NO AIRBAGS DEPLOYED. FRONT OF CAR SMASHED IN, HOOD FOLDED IN A 45 DEGREE ANGLE, FRONT WINDSHIELD CRACKED AND SIDE FINDER SMASHED. CAR WAS LOCKED IN DRIVE AND REQUIRED A FLAT BED TRUCK TO TOW IT AWAY. OTHER VEHICLE IN THE ACCIDENT WAS A TRUCK WHICH THEIR AIRBAGS DEPLOYED AND THAT TRUCK HAD TO BE TOWED AWAY DUE TO THE SIGNIFICANT DAMAGE. NO AIRBAGS DEPLOYED ON FIAT.

NHTSA ID

10812002

Incident

Dec 21, 2015

Mileage

22,000 mi

2014 FIAT 500E. CONSUMER WRITES IN REGARDS TO THE POWER INVERTER MODULE RECALL NOTICE ISSUES. *SMD THE CONSUMER RELOCATED AFTER LEASING THE VEHICLE. THE LOCAL DEALERS IN HIS CURRENT STATED INFORMED HIM, THEY WERE NOT FAMILIAR WITH HIS MODEL AND THEREFORE, COULD NOT REPLACE THE POWER INVERTER MODULE AS DESCRIBED BY THE RECALL. THE CONSUMER SENT IN RECALL # 14V235000. *JB

NHTSA ID

10689358

Incident

Dec 1, 2015

POWER CUT OUT AND CAR STALLED IN TRAFFIC FOUR TIMES IN ONE DAY AS I WAS DRIVING IN SAN FRANCISCO. CAR HAD TO BE TOWED TO DEALER FOR REPAIR. THE CAR ONLY HAD 4,900 MILES ON IT. THE DEALER WAS ABLE TO DUPLICATE MY COMPLAINTS ABOUT STALLING. I HAD PREVIOUSLY HAD A RECALL COMPUTER SERVICE UPDATE REPAIR DONE TO THE CAR IN JUNE 2015. THE DEALER REPLACED THE CAPACITOR 08035025, AND OTHER WIRING. AND THE CAR SEEMS TO BE WORKING NOW, BUT FEAR OTHERS MIGHT NOT BE AS LUCKY IF THIS HAPPENS ON A HIGHWAY.

NHTSA ID

10781130

Incident

Sep 28, 2015

Mileage

4,900 mi

TL* THE CONTACT OWNS A 2014 FIAT 500E. THE CONTACT STATED THAT THE VEHICLE WOULD NOT CHARGE THE BATTERY USING A 240 POWER CORD. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INFORMED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V179000 (ELECTRICAL SYSTEM). THE VEHICLE WAS SERVICED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN. BOTH THE DEALER AND THE MANUFACTURER CONFIRMED THAT THEY WERE MADE AWARE OF THE SITUATION; HOWEVER, THEY HAD YET TO DETERMINE A REMEDY FOR THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 8,000.

NHTSA ID

10721699

Incident

May 22, 2015

Mileage

8,000 mi

RECEIVED 2ND RECALL NOTICE TODAY FOR POWER INVERTER MODULE. FIRST RECALL NOTICE WAS IN MAY 2014. CALLED DEALERSHIP TO GET PART REPLACED ON JULY 7/21/14 AS INSTRUCTED AND WAS TOLD I WAS ON A WAITING LIST. PART IS STILL NOT REPLACED ON 2/17/14. NO COMMUNICATION HAS BEEN MADE FROM FIAT SINCE 7/21/14. *TR

NHTSA ID

10683903

Incident

Feb 17, 2015

Mileage

6,500 mi

I LEASED THIS CAR ON AUGUST 2014 AND HAVE HAD THREE INCIDENT, FIRST ONE ON NOVEMBER 13,2014 WITH ELECTRICAL WARNING "SERVICE ELECTRIC VEHICLE SYSTEM" NEEDS SERVICING. THE FIRST TIME WAS TOLD CAR NEEDED SOFTWARE UPDATE IT TOOK 3-4 DAYS TO GET THE CAR BACK. THE SECOND INCIDENT ON JANUARY 7, 2015 THE CAR COMPLETELY STOPPED WHILE I WAS DRIVING. IT STOPPED RIGHT AFTER A STOP SIGN, THE WARNING SIGN SHOWED THE SAME "SERVICE ELECTRIC VEHICLE SYSTEM" AND ANOTHER WARNING THAT I MAY LOSE POWER IN A SHORT TIME WHICH WAS THE CASE. I WAS TOLD THERE MUST BE A PROBLEM WITH MY CHARGER I CHECKED AND THERE WAS NONE. IT TOOK 2 DAYS TO GET THE CAR BACK. LAST INCIDENT WAS ON FEBRUARY 8 WITH MESSAGES "SERVICE ELECTRIC VEHICLE SYSTEM" "SERVICE PROPULSION SYSTEM" "12 V BATTERY ISSUE FINAL WARNING" AND "SERVICE 12 V BATTERY". THERE HAD BEEN A RECALL FOR 2014 OF THIS MODEL REGARDING EXACT SAME PROBLEMS. THIS MAKES THE CAR VERY DANGEROUS SHOULD THE PROBLEM OCCUR WHILE TRAVELING AT A HIGHWAY SPEED OR NORMAL STREET SPEED WHEN THE CAR LOSSES POWER AND EVERYTHING SHUTS DOWN. *TR

NHTSA ID

10682377

Incident

Feb 8, 2015

Mileage

3,859 mi

I RECEIVED A RECALL NOTICE FROM FIAT REGARDING THE INVERTER THAT PROVIDES POWER TO THE MOTOR OF THE CAR. I MOVED FROM CA TO SC AND FIAT REFUSES TO REPAIR MY CAR. *TR

NHTSA ID

10652808

Incident

Sep 16, 2014

Mileage

2,542 mi

TL* THE CONTACT OWNS A 2014 FIAT 500E. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V235000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART WAS AVAILABLE HOWEVER THE DEALER WAS ONLY ABLE TO SERVICE TWO VEHICLES PER DAY. THE DEALER WAS UNCERTAIN WHEN THEY WOULD BE ABLE TO REMEDY THE VEHICLE UNDER THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND HAD ADVISED THE CONTACT GO TO ANOTHER DEALER AN HOUR AWAY TO REMEDY THE RECALL. THE CONTACT HAD NOT EXPERIENCE A FAILURE.

NHTSA ID

10618154

Incident

Aug 1, 2014