Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 13 NHTSA owner-reported complaints for the 2000 Fleetwood Bounder. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–13 of 13
TIRES ON OUR MOTORHOME ARE G159. WE HAVE HAD THREE SEPARATE INCIDENTS WHERE THE SIDEWALLS BLOW OUT. TWO INCIDENTS WHILE DRIVING THE MOTORHOME. THE LAST INCIDENT, THE TIRE WAS LEANING UP AGAINST A WALL AT THE LOCAL NAPA GARAGE AND THE TIRE BLEW. IT IS LUCKY NO ONE WAS INJURED. WE CONTACTED GOODYEAR WITH NO SATISFACTION/RESOLUTION TO OUR COMPLAINT.
FUEL INJECTION PUMP FAILURE DUE TO INADEQUATE FUEL DELIVERY. THIS PUMP IS A BOSCH VP44 PUMP AND ACCORDING TO THE CUMMINS BLOG WEBSITES AND THE FACTORY AUTHORIZED DEALER, THIS PART HAS A 100% FAILURE RATE. WHEN THE PUMP FAILS THE ENGINE SHUTS OFF AND DOESN'T RESTART. MY VEHICLE IS A 25000 POUND MOTOR HOME, AND WHEN IT DIES OUT AT FREEWAY SPEEDS CAN BE VERY DANGEROUS. BOSCH AND CUMMINS KNOW ABOUT THE PROBLEM, BUT ARE UNWILLING TO ASSIST THE CUSTOMER IN ANY WAY EVEN THOUGH THEY ADMIT THAT IT IS A DESIGN FAULT. IN THEIR WORDS "WE ADMIT THAT IT WASN'T OUR BEST DESIGN". ACCORDING TO THE BLOGS THIS IS THE ISSUE: THE MOST COMMON MECHANICAL FAILURE OF THE VP44 PUMP IS RUPTURING OF THE DIAPHRAGM IN THE FRONT OF THE INJECTION PUMP. THE DIAPHRAGM RUPTURES ALLOWING THE TIMING PISTON TO VIBRATE AND DAMAGE THE FRONT COVER UNTIL FUEL BYPASSES. THIS WILL CAUSE THE DREADED CHECK ENGINE TROUBLE CODE P0216. WHEN THIS OCCURS YOUR BOSCH VP44 INJECTION PUMP MUST BE REPLACED. THE RUPTURING OF THE DIAPHRAGM IS CAUSED BY A POORLY DESIGNED LIFT PUMP. WHEN THE LIFT PUMP DOES NOT SUPPLY THE INJECTION PUMP WITH THE CORRECT AMOUNT OF FUEL PRESSURE (A MINIMUM OF 5PSI UNDER LOAD AT WIDE OPEN THROTTLE) THE DIAPHRAGM THEN DOESN'T HAVE ENOUGH POSITIVE PRESSURE AND RUPTURES. DODGE HAS RECOGNIZED THIS PROBLEM AS THEY WILL NO LONGER EVEN SELL THE LIFT PUMP THAT GOES ON THE SIDE OF THE BLOCK, THEY REPLACE IT WITH A UNIT THAT IS NOW MOUNTED IN THE TANK. I HAVE ASKED FOR ASSISTANCE BUT WAS OFFERED NOTHING. THE COST TO CHANGE THIS PART IS OVER $3000.00 DOLLARS, BUT EVEN MORE IMPORTANT IS THE FACT THAT THEY HAVE A DESIGN WHICH IS INHERENTLY DANGEROUS. HAD THIS HAPPENED 10 MILES LATER, I WOULD HAVE BEEN HALF WAY UP A MOUNTAIN ROAD. ON A DIESEL MOTOR HOME WHEN THE ENGINE DIES, YOU LOOSE BRAKES, POWER EVERYTHING.
TL*THE CONTACT OWNS A 2000 FLEETWOOD BOUNDER. THE CONTACT RECEIVED A RECALL NOTICE IN SEPTEMBER OF 2007 FOR THE VEHICLE SPEED CONTROL. THE PARTS FOR THE RECALL REPAIR ARE UNAVAILABLE AND FORD DOES NOT KNOW WHEN THEY WILL ARRIVE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN.
DT*: THE CONTACT STATED THE MOTOR HOME HOUSING PART WAS BROKEN FROM THE FRAME CAUSING THE STEERING WHICH IS ALSO CONNECTED TO THE FRAME TO HAVE DIFFICULTY MAINTAINING STEERING. THE CONTACT STATED THE STEERING FELT AS IF IT WERE LOOSE, WHICH HAS BEEN A CONSISTENT PROBLEM, BUT THE MOTOR HOME HAS NOT BEEN TO A SERVICE DEALER. THE MOTOR HOME HAS NOT BEEN IN AN ACCIDENT.
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE SLOWS DOWN AS IF IT IS LOOSING POWER. THE DEALER WAS ALERTED. THEY HAVE REPLACED THE FUEL PUMP TWICE HOWEVER THIS DID NOT CORRECT THE PROBLEM. THE MANUFACTURER WAS ALERTED. *AK THE ENGINE STALLED. UPDATED 04/06/06
THE CONSUMER RECEIVED NHTSA RECALL #03V066000: MOTOR HOME CHASSIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD. THE DEALER TOLD THE CONSUMER TO THE TAKE RV SOMEWHERE ELSE BECAUSE THEY DID NOT HAVE A TECHNICIAN TO PERFORM THE WORK. *JB *NM
REAR SEAT IS MOUNTED INCORRECTLY WHICH ENABLES THE CHAIR TO FACE FORWARD.*AK
THE PROBLEM OF FAILED HEATER HOSE CLAMPS ON THE 6.8 L ENGINE WAS WELL KNOWN TO THE FORD AGENCY WHICH REPAIRED IT UNDER WARRANTY. THE PROBLEM HAS ALSO BEEN DISCUSSED IN THE TECHNICAL COLUMNS OF RV MAGAZINES. THE FAILED CLAMP WAS REPLACED BY ONE OF SIMILAR DESIGN AND OTHERS REMAIN ON THE ENGINE. OBVIOUS DANGEROUS SITUATIONS CAN ARISE WITH FAILED HOSE CLAMPS.
CONSUMER HAS ONLY FILLED TANK 3 TIMES SINCE OWNING IT. EVERY TIME HAS NOTICED GAS LEAKING. FLEETWOOD DEALER REPAIRED THE OVERFLO TUBE.*AK
COULD NOT FILL PROPANE TANK DUE TO IT BEING BURTED WHEN MOTORHOME WAS PURCHASE. WAS LEAKING INSIDE OF MOTORHOME. COULD SMELL PROPANE WHILE DRIVING MOTORHOME. CONTACTED FLEETWOOD. TOOK MOTORHOME BACK TO DEALER 2 OR 3 TIMES FOR REPLACEMENT. PROBLEM STILL EXISTS.*AK
MOTORHOME TIRE BALANCE/OVERHEAT PROBLEM. *AK
WHILE DRIVING AROUND 60 MPH, A SHEET OF METAL ABOUT 10 INCHES HIGH/5 FEET LONG/ 40 THOUSANDS OF AN INCH THICK, AND PAINTED BLACK, FELL OFF. OWNER BELIEVED THAT THE PIECE WAS A HEAT SHIELD. *AK THE HEAT SHIELD WAS POORLY ATTACHED TO THE CHASSIS BY SPOT WELDS INSTADE OF BOLTS. THE CONSTANT RIPPLING MOTION OF THIS THIN SHEET APPEARS TO HAVE CAUSED METAL FATIGUE TO ALL THE FAILED SPOT WELDS RESULTING TO FELL OFF. *YH
REPAIRED BY LOCAL DEALER. NO SAFETY DEFECT LISTED IN SUMMARY. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Data on this page last refreshed .