2000 Fleetwood Discovery Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2000 Fleetwood Discovery, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure333.3%
- Tires & wheels333.3%
- Electrical111.1%
- Engine111.1%
- Fuel system111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
DT: CONTACT STATES WHILE DRIVING THE FRONT PASSENGER DOOR WHISTLES, WATER LEAKS IN, THE DOOR CAME OPENED. THE DOOR HAS BEEN REPLACED ONCE.
WHEN DRIVING DOWN THE HIGHWAY, THE DOOR INADVERTENLY OPENS, CONSUMER STATES THE DEAD BOLTS HAVE BEEN KNOWN TO FAIL, THE MOTORHOME HAS BEEN TO THE DEALER TWICE, THE FIRST TIME THEY REPLACED THE DOOR WITH ANOTHER BAD DOOR, THE SECOND TIME THEY ADJUSTED THE LOCK WHICH DID NOT HELP EITHER, AND IS SCHEDULED TO GO BACK FOR A 3RD TIME.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
MICHLIN 235-80-22.5 TIRE BLEW OUT (RIGHT INNER DUAL SIDE WALL).TRAVELING AT 60 MPH. JUST HAD MOTORHOME WEIGHED AT EACH CORNERAT RALLY IN TEXAS 2 DAYS BEFORE BLOWOUT AND IT WAS WITHIN WEIGHT AND TIRE PRESSURE LIMITS. 2000 DISCOVERY (36,000) MILES CAUSED $3100.00 DAMAGE TO BODY. 2 WEEKS LATER WHILE DOING MAINT. DISCOVERED MUNTIPLE BULGES IN BOTH FRONT TIRES. REPLACED THEM AND NOW AM REPLACING LEFT REAR DUALS FOR FEAR THEY WILL BLOW! THE DEALER TELLS ME THEY ARE ON BACK ORDER FROM MICHLIN AND THEY DON'T EVEN KNOW WHEN THEY CAN GET ANY. I THINK 6 TIRES AT 36,000 MILES IS A PROBLEM!! I HAVE PHOTOS OF BLOWN OUT TIRE AND DAMAGE. *AK
WHILE DRIVING, THE VEHICLE SUFFERED A BLOW OUT ON ONE OF THE TIRES. THE BLOWOUT CAUSED A 9 INCH TEAR IN THE SIDEWALL. MICHELIN HAS NOT RESPONDED TO CONSUEMRS REQUEST FOR A PRORATED ADJUSTMENT OF THE REPLACEMENT. THE TIRE IS A MICHELIN XRL 235/80R 22.5 *JG *DT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHEN DRIVING DOWN THE HIGHWAY, THE DOOR INADVERTENLY OPENS, CONSUMER STATES THE DEAD BOLTS HAVE BEEN KNOWN TO FAIL, THE MOTORHOME HAS BEEN TO THE DEALER TWICE, THE FIRST TIME THEY REPLACED THE DOOR WITH ANOTHER BAD DOOR, THE SECOND TIME THEY ADJUSTED THE LOCK WHICH DID NOT HELP EITHER, AND IS SCHEDULED TO GO BACK FOR A 3RD TIME.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
CONSUMER PURCHASED THE MOTORHOME WITH THE CUMMINS 1SB300 ENGINE, HOWEVER THE ENGINE HAS EXPERIENCED PROBLEMS, THE NEW UNITS WERE INSTALLED WITH FAULTY OIL PRESSURE SENSORS WHICH HAS TO BE REPLACED, THEN THE FUEL LINE BROKE LEAKING FUEL DUE TO A DEFECT WHICH WAS KNOWN BY THE MANUFACTURER. CONSUMER HAS INFORMATION RELATING TO 1SB DRAINLINE REPLACEMENT. *MJS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
CUMMINS 5.9 ISB LIFT PUMP FAILURE AT 40,000 MILES CAUSED ENGINE TO OVER HEAT AND STALL. A VEHICLE CRASH COULD HAVE OCCURRED. SIMILAR TO NHTSA #05E054000. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .