2005 Fleetwood Discovery Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Fleetwood Discovery, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Visibility1583.3%
- Body & structure211.1%
- Driver assistance15.6%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WINDOWS ARE FOGGED UP BETWEEN THE 2 PIECES OF GLASS. DRIVERS SIDE IS SO BAD YOU CAN NOT SEE THE MIRROR OUTSIDE. THIS IS VERY DANGEROUS AND COULD CAUSE DEATH. *TR
THERE WAS NO INCIDENT. MY HOPE IS TO REPORT THIS BEFORE THERE IS. MY MOTORHOME HAS WINDOWS WHICH ARE FOGGING UP VERY BADLY. THE DRIVERS SIDE AND PASSENGERS SIDE WINDOWS GET SO FOGGY THAT IT MAY BE CONSIDERED DANGEROUS. I HAVE TALKED WITH OTHER MOTORHOME OWNERS WHO ARE FACING THE SAME ISSUE. PLEASE ADVISE. *TR
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
ROOF WATER INTRUSION INTO INTERIOR OF RV REAR VIEW MIRROR CHROME FAILURE DRIVERS SIDE WINDOW SEALS FAILURE ALLOWING FOGGING TO OCCUR. *TR
FREIGHTLINER CHASSIS HAS RUST ALL OVER CHASSIS. CHASSIS IS PART OF A FLEETWOOD RV MOTORHOME. FLEETWOOD AND FREIGHTLINER KEEPS SAYING THIS IS NOT THEIR PROBLEM. WHY IS IT MY PROBLEM WHEN THIS WAS SUPPOSED TO BE A NEW MOTORHOME? I BELIEVE THIS UNIT WAS IN WATER. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
OUR WINDOWS ARE FOGGED VERY BAD. WHEN THE SUN IS OUT THE GLARE IS SO BAD THAT U CAN NOT SEE OUT TO SEE THE MIRRORS ,VERY DANGEROUS. WHEN I CALLED TO COMPLAIN THEY SAID I CALLED TO LATE FOR THEM TO BE REPAIRED,THEY DID NOT SEND A RECALL .CALLED FLEETWOOD A FEW TIMES AND THEY WOULD NOT STAND BEHIND IT NOR WOULD MY DEALER.THEY NEW THEY HAD A PROBLEM AND WOULD NOT FIX IT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .