2004 Fleetwood Gear Box Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Fleetwood Gear Box, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure266.7%
- Other / unspecified133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
TONGUE WEIGHT AT THE PIN IS AT 1,860 POUNDS DRY. AMOUNT OF TONGUE FLEX HAS BENT THE PROTECTIVE DIAMOND PLATE AT FRONT OF TRAILER. REESE 1200 POUND HITCH AND DUAL CAM SWAY CONTROL IS ALREADY SHOWING SIGNS OF SEVERE WEAR AND FATIGUE. AFTER COMPLAINTS OF WEIGHT THE DIAMOND PLATE WAS TRIMMED UP AND MANUFACTURER HAS OFFERED TO WELD IN A BALLIST TUBE OR PLATE AT THE REAR OF TRAILER OF ABOUT 500 POUNDS. THIS TRAILER IS UNSAFE AND A TONGUE FAILURE CAN OCCUR AND KILL SOMEONE. THE TONGUE WEIGHT WHEN FULLY LOADED WITH FLUIDS, CARGO, ETC. EXCEEDS 2300 POUNDS AS A LARGE PORTION OF THE 120 GALLON FRESH WATER TANK IS LOCATED IN FRONT OF THE FORWARD AXLE. IT TOOK ABOUT 2500 POUNDS OF BALLAST TO GET THE TONGUE TO AN ACCEPTABLE WEIGHT. THE CONSUMER REQUESTED A FULL REFUND FROM THE MANUFACTURER. *NM *NM
EXCESSIVE TONGUE WEIGHT RESULTING IN THE BENDING OF THE TONGUE FRAMEWORK, DAMAGE TO FRONT OF VEHICLE AS WELL AS CAUSING UNSAFE TOWING CONDITIONS. UNLADEN DRY TONGUE WEIGHT IS 17%, @1390 #'S. WHEN LOADED AT MAXIMUM MANUFACTURERS RECOMMENDATION OF 11,700 #S, TONGUE WEIGHT WILL EXCEED 1700 #'S. BOTH WEIGHTS EXCEED MAX LOADS FOR FACTORY INSTALLED CLASS 5 HITCH ON FORD SUPER DUTY TRUCKS. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
EXCESSIVE TONGUE WEIGHT RESULTING IN THE BENDING OF THE TONGUE FRAMEWORK, DAMAGE TO FRONT OF VEHICLE AS WELL AS CAUSING UNSAFE TOWING CONDITIONS. UNLADEN DRY TONGUE WEIGHT IS 17%, @1390 #'S. WHEN LOADED AT MAXIMUM MANUFACTURERS RECOMMENDATION OF 11,700 #S, TONGUE WEIGHT WILL EXCEED 1700 #'S. BOTH WEIGHTS EXCEED MAX LOADS FOR FACTORY INSTALLED CLASS 5 HITCH ON FORD SUPER DUTY TRUCKS. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .