Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 21 NHTSA owner-reported complaints for the 2004 Fleetwood Prowler. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–21 of 21
TOWMAX ST225/75R-15/10 DOT NUMBERS ADB4GPB5014,JKLFID2613 AND 83B4GPB4011 700 TO 1000 MILES ON THE TIRES BELT SEPARATED AND TREAD LOSS 2 OF 4 TIRES 80 PSI IN TIRES AT ALL TIMES ACCORDING TO SIDEWALL REQUIREMENTS.
THIS IS A CONTINUATION OF EVENTS WHERE I HAVE FOUND LARGE STRUCTURAL CRACKS IN DIFFERENT PARTS OF THE 5TH WHEELS FRAME..PARTICULARLY THE FRONT PIN BOX FRAME AND LOWER FRONT SUPPORT FRAME. FROM WHAT MYSELF AND OTHERS HAVE OBSERVED, WE FEEL THAT BOTH POOR WELDS, LOW QUALITY STEEL, INSUFFICIENT CROSS BRACING, AND TOO LIGHT A GAUGE OF METAL TO PROPERLY SUPPORT THE ENTIRE WEIGHT OF THIS AND OTHER TYPES OF TRAILERS. MY FRAME HAS BEEN WELDED IN SEVERAL DIFFERENT PLACES OVER THE PAST 4 YEARS, I HAVE LOST AXLES FROM UNDER IT BECAUSE OF BROKEN OR INSUFFICIENT CROSS BRACING ON THE UNDER CARRIAGE, THE UPPER FRONT FRAME WAS RE WELDED AND SUPPOSEDLY RE BRACED A FEW YEARS BACK BY A FACTORY DEALER. WE JUST RETURNED FROM WHAT WAS TO BE OUR VACATION, AFTER PULLING OFF THE HIGHWAY TO TAKE A BREAK ON OUR TRIP WHEN I NOTICED THAT THE ENTIRE FRONT OF MY TRAILER HAD TORN LOSE AND WAS ABOUT TO COMPLETELY RIP FREE FROM MY TRUCK..AFTER LOOKING AT WHAT HAD TRANSPIRED I FEEL VERY FORTUNATE THAT WE STOPPED WHEN WE DID, THE METAL THAT HAD BEEN REPAIRED THE LAST TIME THIS HAPPENED WAS COMPLETELY TORN LIKE A SHEET OF PAPER, THE WELDS THAT WERE TO BE FIXED LAST TIME WERE LOOKED OVER AND NEVER RE BRACED OR WELDED.. THE FRAME MANUFACTURER I AM SURE YOU FOLKS HAVE HAD PLENTY OF COMPLAINTS ABOUT THIS COMPANY. THE NAME OF COMPANY IS LIPPERT FRAMES.. LIPPERT FRAMES AT ONE TIME AND STILL DOES MANUFACTURE FRAME FOR PROBABLY 60-75% OF 5TH WHEEL AND OTHER TRAILERS TODAY..OUR CONCERN IS THAT THEY AS A MANUFACTURER WILL NOT TAKE RESPONSIBILITY FOR POOR WORKMANSHIP, LOW QUALITY MATERIALS,OR STAND BEHIND WHAT THEY BUILD, WE HAVE BEEN EXTREMELY LUCKY THAT OURSELVES OR ANY OTHER MOTORIST HAS NOT BEEN KILLED OR SEVERELY INJURED IF ONE OF THESE FRAMES COMPLETELY LET LOSE. *TR
TL* THE CONTACT OWNS A 2004 FLEETWOOD PROWLER FIFTH WHEEL TRAILER. THE CONTACT STATED THAT THE WELDS OF THE CROSS MEMBERS ON THE CHASSIS WERE FRACTURED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V289000 (STRUCTURE) BUT THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS NOT AVAILABLE.
TL*THE CONTACT OWNS A 2004 FLEETWOOD PROWLER RV. THE VEHICLE WAS EQUIPPED WITH A DOMETIC REFRIGERATOR, MODEL NUMBER RM2652. THE REFRIGERATOR WAS NOT COOLING PROPERLY. ALSO, THERE WAS A STRONG ODOR OF AMMONIA AND YELLOW RESIDUE THAT WAS LOCATED ON THE BOTTOM BOILER TUBE IN THE BACK OF THE REFRIGERATOR. THE REFRIGERATOR WAS INCLUDED IN THE RECALL DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 08E032000 (EQUIPMENT). THE MANUFACTURER WAS NOTIFIED AND THEY STATED THE REMEDY CONSISTED OF A PROTECTION SHIELD. THE CONTACT WAS DISPLEASED WITH THE RECALL REMEDY DUE TO THE REFRIGERATOR BEING INOPERATIVE AND IT WOULD NOT CORRECT THE PROBLEM. THE REFRIGERATOR HAD NOT BEEN REPLACED AT THE TIME OF THE COMPLAINT. THE VIN AND FAILURE MILEAGE WERE UNAVAILABLE.
IM INFORMED OF A POSSIBLE FIRE HAZARD ON MY DOMETIC REFRIGERATOR AND IT IS THE WEEKEND AND I CANT GET ANY INFORMATION FROM ANYONE. TO ME THIS IS A CROCK. OUR BUSINESS HOURS OUR MON. THROUGH FRI.@#%&&^&(.ITS FILLED WITH FOOD THAT I CANT AFFORD TO WASTE. THEY SAY TO AT LEAST TURN OFF THE GAS PART OF IT BUT I DON'T KNOW HOW TO GET TO IT. *TR
2004 FLEETWOOD PROWLER FRONT FRAME AND PIN BOX FAILURE. RESULTING IN HAVING TO DISCONNECT 5TH WHEEL FROM TOW VEHICLE AND WAIT FOR REPAIR SERVICES. 5TH WHEEL HAS BEEN PARKED ON PROPERTY FOR OVER 2YEARS, HAS VERY LITTLE ACTUAL TOWING TIME, THE UNIT WAS NOT OVER LOADED. FRAME WELDS AND LAYUP WERE WHAT I CONSIDER ABSOLUTE GARBAGE. MY WIFE AND I WERE STRANDED AT THE LAKE ON OUR VACATION,AND ARE STILL WAITING FOR A SOLUTION ON HOW TO GET IT TO A REPAIR SHOP. IF I HAD CONTINUED TOWING THIS 5TH WHEEL , ESPECIALLY IN THE HILLS THAT WE WERE TRAVELING IN, I AM QUITE SURE I WOULD HAVE LOST IT OFF THE BACK OF MY TRUCK.. TO DATE I THINK I HAVE READ APPROX. 30 -50 COMPLAINTS SIMILAR TO MINE WITH NO RESPONSE FROM EITHER FLEETWOOD OR LIPPERT FRAMES. I WOULD HATE TO THINK THAT IT WOULD TAKE A SEVERE WRECK AND THE LOSS OF LIVES TO WAKE THESE MANUFACTURERS UP...I AM HOPING MY INSURANCE WILL TAKE CARE OF THE REPAIRS ON MY RIG ,I CAN GUARANTEE NEITHER FLEETWOOD OR LIPPERT WILL. *TR
TL*THE CONTACT OWNS A DOMETIC RM2652. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 06E076000 (EQUIPMENT:RECREATIONAL VEHICLE) IN JANUARY OF 2008. THE MANUFACTURER STATED THAT THE UNIT WAS INCLUDED IN THE RECALL, BUT THE REPAIR HAD PREVIOUSLY BEEN PERFORMED ON AUGUST 31, 2007. THE CONTACT DENIED ANY REPAIR WORK BECAUSE THERE WAS NO PRIOR FAILURE. THE MANUFACTURER REFUSED TO HONOR THE RECALL. THERE HAD BEEN NO FAILURE TO DATE. THE PART NUMBER AND LOCATION IN THE VEHICLE WERE UNAVAILABLE. UPDATED 02/15/08. *LJ
TL*THE CONTACT OWNS A 2004 FLEETWOOD PROWLER REGAL FIFTH WHEEL TRAILER. THE CONTACT STATED THAT THE FRONT OF THE UNIT IS CRACKING. A WELDER ARRIVED TO PLACE A TEMPORARY PATCH ON THE UNIT AND HE STATED THAT THE FACTORY WELDS WERE TOO COLD. WHEN THE UNIT SEPARATED, IT FELL DOWN ON TOP OF THE VEHICLE. THERE WERE NO INJURIES. NO OTHER VEHICLE INFORMATION WAS APPLICABLE.
RECALL OF DOMETIC REFRIGERATOR. CHARGED 60.00 IN ORDER TO HAVE DONE AND RELEASED. *TR
2004 PROWLER LYNX 5TH WHEEL, MANUFACTURED BY FLEETWOOD. WHILE ADJUSTING THE ELECTRIC BRAKES, I FOUND THAT ALL 4 BRAKE ASSEMBLIES HAD BEEN MOUNTED ON THE WRONG SIDES OF THE VEHICLE, I.E., THE ACTUATING ARMS FACED TOWARD THE REAR. THE PRIMARY SHOES FACED THE REAR OF THE VEHICLE. ASSEMBLIES MARKED L WERE ON THE RIGHT (PASSENGER) SIDE AND VICE VERSA. I CALLED FLEETWOOD AND THEY SAID THEY WOULD NOT BE RESPONSIBLE FOR FIXING THE PROBLEM. IF I HAD TO GUESS, IT APPEARS THE AXLES WITH BRAKES AND HUBS ALREADY MOUNTED WERE INSTALLED BACKWARD DURING MANUFACTURING. THIS ASSUMPTIONS IS SUPPORTED BY THE FACT THAT THE WIRE OPENINGS ARE IN THE FRONT OF THE AXLES. I'VE READ THAT THEY ARE NORMALLY IN THE REAR OF THE AXLE TO FACE AWAY FROM TRAFFIC DEBRIS. I'M IN THE PROCESS OF REPLACING ALL ASSEMBLIES, BUT THE ASSEMBLIES ON THE REAR AXLE HAVE NOT BEEN CHANGED AND WILL NOT TILL MID MAY. I'LL TAKE PICTURES TO DOCUMENT THE CURRENT CONDITION. THOUGHT OTHER VEHICLES MIGHT HAVE BRAKE ASSEMBLIES (AND PROBABLY THE AXLES ALSO) INSTALLED THE WRONG DIRECTION. THE FLEETWOOD REP (MONICA) I TALKED WITH SAID THE AXLES WERE MANUFACTURED BY QUALITY AXLES, 800-243-4883. *JB
TL* THE CONTACT OWNS A DOMETIC REFRIGERATOR. RECALL 06E076000 WAS RECEIVED FOR MODEL# 2652. THE LETTER INFORMED HIM TO CALL DOMETIC. THE CONTACT STATED THAT ONCE HE TYPED IN THE MODEL NUMBER THE INFORMATION SYSTEM WOULD NOT ACCEPT ANY ADDITIONAL INFORMATION, TO SPEAK WITH A REPRESENTATIVE, OR ALLOW AN OPTION TO LEAVE A MESSAGE. THE CONTACWAS UNCERTAIN WHAT TO DO WITH THE RECALL NOTICE OR THE REFRIGERATOR. THE CONTACT WAS ADVISED THAT THE RECALL BEGAN IN APRIL 2007.
TL* - THE CONTACT READ ABOUT A RECALL FOR THE DOMETIC REFRIGERATOR MODEL # RM2652. THE CONTACT WAS CONCERNED WITH THE SAFETY ISSUE OF WAITING TOO LONG TO HAVE REPAIRED. THE TRAILER IS THE CONTACT'S PRIMARY RESIDENCE. AK UPDATED 01/31/07.*JB
MY TRAILER SEWER DISCHARGE SYSTEM IS ALMOST TOUCHING THE GROUND. *JB
2004 PROWLER REGAL 270 SKY LIGHT OVER SHOWER LEAKED. PANEL ON REAR OF DINNETTE BOOTH CAME OFF, PANEL UNDER BED CAME OFF AND LATCH WILL NOT STAY FASTENED. *TS THERE WAS A LEAK FROM THE SLIDE OUT. THE BATTERY WAS DEAD. THE SHOWER DOOR DID NOT SLIDE. THE HITCH BALL WAS NOT TILTED CORRECTLY, THE STEEL RODS WERE BENT. *JB
NO FAILURE. THIS IS CONCERNING A 2004 FLEETWOOD PROWLER TRAVEL TRAILER WE BOUGHT NEW. I REMOVE THE ORIGINAL TIRES AND REPLACED WITH HEAVIER TIRES(C LOAD RATING). I DID THIS BECAUSE OF HANDLING PROBLEMS WHEN PULLING THE TRAILER. THE TRAILER WOULD SWAY EXCESSIVELY WHEN I WAS PASSED, ESPECIALLY BY BIG TRUCKS. CHANGING TO HEAVIER TIRES MADE A SOLVED THIS PROBLEM. THE TRAVEL TRAILER CAME WITH B LOAD RATED TIRES WHICH ACCORDING TO THE STICKER ON THE TRAILER ARE CAPABLE OF CARRYING 5920 LBS. MAXIMUM. THE STICKER STATES THE GVWR(GROSS VEHICLE WEIGH RATING) OF THE TRAVEL TRAILER IS 6600 LBS. ACCORDING TO FLEETWOODS' OWN DATA WITH A FULLY LOADED TRAILER THE TIRES THAT CAME ON THE TRAILER ARE OVERLOADED BY 680 LBS. THUS THE TIRES ARE NOT CAPABLE OF CARRYING A FULLY LOADED TRAILER. THE STICKER ON THE TRAILER STATES THAT THE DRY WEIGHT IS 4987 LBS.+384 LBS.(FRESH WATER TANK)+59 LBS.(PROPANE)=5430 LBS. THEN THE TRAILER HAS A 40 GAL. GREY WATER TANK(333.2 LBS. FULL) AND A 40 GAL. BLACKWATER TANK(333.3 LBS. FULL). ALL OF THIS ADDED TOGETHER(6096.4 LBS.) WHICH OVERLOADS THE ORIGINAL TIRES BEFORE WE LOAD ALL OF THE FOOD, CLOTHES, BOOKS, ETC. FLEETWOOD IS RECALLING(NHTSA #05V511000) SOME PROWLER TRAILERS AND REPLACING THE B LOAD RATED TIRES WITH C LOAD RATED TIRES. I WAS TOLD MY TT WAS NOT ON THE RECALL LIST. I DO STILL HAVE THE ORIGINAL TIRES TAKEN OFF OF THE TT AND THE ORIGINAL SPARE IS STILL ON THE TT. I FEEL MY TT SHOULD HAVE THE PROPER TIRES PUT ON IT BY FLEETWOOD OR THAT I BE REIMBURSED FOR THE TIRES I REPLACED. *NM
WE HAVE FOUR TIRES ON OUR 2004 REGAL PROWLER RV. WE FOUND A BUBBLE AND WHEN THE DEALER WE GOT THE TRAILER TO SAW THE TIRES, THEY ALL NEEDED REPLACED. THE RUBBER WAS ROTTEN AND COULD BE PULLED BY HAND OFF THE RIM ONCE UP ON A RACK. THE BUBBLES WERE EVIDENT ON ALL TIRES AND COULD HAVE CAUSED A SERIOUS ACCIDENT. THE RIG HAD NOT BEEN USED MANY TIMES AND THE TIRES WERE NOT OLD ENOUGH TO NEED REPLACED THIS SOON. THEY ARE GOODYEAR MARATHON RADIAL (S), PDHH MLOR 0203 SIZE ST 225/75R 15'S. I FEEL THAT SOMETHING WAS WAY WRONG WITH THESE TIRES AND I SHOULD NOT HAVE HAD TO REPLACE THEM THIS SOON. THEY WERE BASICALLY ROTTEN AND A SEVERE ACCIDENT COULD HAVE HAPPENED WHEN TOWING THIS VEHICLE. *NM
DT: WHILE DRIVING AT 75-80 MPH ON THE INTERSTATE A FRAME FAILED ON THE FIFTH WHEEL FLEETWOOD TRAVEL TRAILER. THE TRAILERS INSTABILITY CAUSED THE CONSUMER TO PULL OFF FROM THE INTERSTATE. THE FRAME BROKE APART WHILE STILL ATTACHED TO THE VEHICLE. FLEETWOOD SENT A WELDER TO WELD THE FRAME ENOUGH SO THE TRAILER COULD BE MOVED TO THE FLEETWOOD PLANT FOR FURTHER REPAIRS, FROM THERE IT WAS SENT TO LIPPERT FRAME MANUFACTURER FOR REPAIRS. THE TRAILER WAS TO BE GIVEN BACK TO THE CONSUMER. THE CONSUMER BROUGHT A FRAME SPECIALIST WITH HIM TO INSPECT THE TRAILER AND WAS WARNED NOT TO ACCEPT THE TRAILER. THE CONSUMER SAID THE TRAILER HAD BEEN BACK AND FORTH FOR FURTHER REPAIRS UP TO FOUR TIMES. THE CONSUMER CALLED THE DEALER, WHO ALSO INSPECTED THE VEHICLE. HE REFUSED TO TAKE THE TRAILER AS WELL. THE DEALER CALLED FLEETWOOD, AND THEY REFUSED A TRADE IN OR OFFER FOR A NEW ONE. A FEW MONTHS LATER, THERE WAS A RECALL NOTICE SENT ON FAILURE OF THE WELDING ON THIS PARTICULAR FRAME. THE CONSUMER DID NOT HAVE ANY FURTHER REPAIR WORK PERFORMED AS ADVISED BY THE RECALL. THE CONSUMER LEFT THE TRAILER AT THE FACTORY AND WISHED TO FILE A SAFETY COMPLAINT AT THIS TIME. *AK *JB
THE PIN BOX WHICH WAS WELDED ONTO THE 5TH WHEEL FRAME TO BE USED TO PULL THE TRAILER BROKE FROM THE WELD FOR THE SECOND TIME. *JB
WHILE DRIVING LOW SPEEDS FRONT SHOCKS PUNCTURED THE FRONT PASSENGER'S SIDE TIRE AND DAMAGED THE WHEEL WELL. CONSUMER HAD THE TIRE CHANGED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK THE SLIDEOUTS CAME OUT ABOUT 8 INCHED WHILE DRIVING DOWN THE FREEWAY. THE CONSUMER HAD TO EXIT THE VEHICLE AND PUSH THEM BACK IN BY HAND. *NM
CONSUMER STATED MICROWAVE IN MOTOR HOME WAS ON RECALL. HOWEVER, AFTER SEVERAL MONTHS OF TRYING TO CONTACT ASSISTANCE FOR HELP ON THIS MICROWAVE MANUFACTURER REFUSED TO TAKE RESPONSIBILITY, AND DID NOT HELP. CONSUMER WAS IRATE. *AK
WHILE DRIVING, THE RIGHT REAR WHEEL BROKE OFF FROM THE AXLE, DAMAGING THE RIGHT REAR SIDE OF THE 5TH WHEEL AND ALMOST CAUSING AN ACCIDENT. *AK DUE TO IMPROPER TORQUE, THE WHEEL AND LUG NUTS CAME OFF. *TS *JB
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .