2005 Fleetwood Wilderness Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Fleetwood Wilderness, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified233.3%
- Body & structure116.7%
- Electrical116.7%
- Suspension116.7%
- Tires & wheels116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2005 FLEETWOOD WILDERNESS. SIX MONTHS AFTER PURCHASING THE VEHICLE, THE DOMETIC REFRIGERATOR FAILED AND ALMOST CAUSED A FIRE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06E076000 (EQUIPMENT:RECREATIONAL VEHICLE). THE CURRENT AND FAILURE MILEAGES WERE 5,400. NO ADDITIONAL INFORMATION WAS AVAILABLE FOR THE TRAILER.
TL*THE CONTACT OWNS A 2005 FLEETWOOD WILDERNESS. THE CONTACT STATED THAT THE BODY OF THE CAMPER WAS NOT LEVEL WITH THE BODY OF THE VEHICLE. HE NOTICED A CRACK ON THE C-CHANNEL FRAME, WHICH SHEARED THE BOLTS THAT HELD THE CAMPER. HE STATED THAT THE REAR LATCHES FOR THE REAR DOOR BENT AND HE BELIEVED THAT THE SHEARED BOLTS CAUSED THE FAILURE. AS OF SEPTEMBER 10, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE MILEAGE AND ENGINE INFORMATION WERE NOT APPLICABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
EVENTS: TOWED 27' FLEETWOOD TRAVEL TRAILER FROM HEWITT, TX TO RED RIVER, NM. FAILURE: STEEL FRAME WHICH HOLDS REAR BUMPER AND ALSO HOLDS SPARE TIRE BEGAN TEARING OFF FRAME OF TRAVEL TRAILER, EVENTUALLY IF NOT CAUGHT IN TIME BUMPER W/SPARE TIRE ATTACHED WOULD HAVE DETACHED FROM TRAILER. CORRECTIVE ACTION: TOOK TO DEALER, FLEETWOOD MOTOR HOMES CLAIMED IT WAS NOT A STRUCTURAL OR INSTALLATION DEFECT EVEN THOUGH ANCIRA DEALERSHIP ALSO AGREED THIS WAS FACTORY FLAW IN THE DESIGN/INSTALLATION. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
VEHICLE CAUGHT FIRE DURING DELIVERY. UPON FURTHER INVESTIGATION, IT WAS FOUND THAT THE MAIN WIRING HARNESS WAS INCORRECTLY ROUTED / CLAMPED BETWEEN CHASSIS AND FLOORING. THIS CAUSED THE HARNESS WIRING TO SHORT OUT AND CAUSE A FIRE IN THE FLOORING / INSULATION. DAMAGE INCLUDED SMOKE, REROUTING / REPAIR OF BURNT HARNESS, REPAIR OF SLIDE SWITCH, SLIDE SWITCH HARNESS, SLIDE SWITCH CONNECTOR, SLIDE SWITCH MOTOR, SEVERAL FUSES, INCLUDING THOSE ON THE TOW VEHICLE. HARNESS HAS BEEN REROUTED AND REPAIRED. FUSES HAVE BEEN REPLACED AS WELL. REMAINING PARTS HAVE NOT BEEN REPLACED PENDING AVAILABILITY FROM FLEETWOOD. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
MY HUSBAND AND I PURCHASED A 2005 5TH WHEEL FLEETWOOD GEARBOX. WE FILLED OUR WATER TANK AND IT CAUSED THE HOLDING BRACKETS AND THE FLOOR TO BEND. WE TOOK IT BACK TO EARNHARTS SERVICE DEPT AND THEY SAID THEY WOULD NOT WARRANTY THE BRACKETS OR FLOOR. MY CONCERN IS IF THEY ARE GOING TO ALLOW YOU TO FILL YOU TANK TO 120 GALLONS AND THE BRACKETS BEND THEN THAT IS A MAJOR PROBLEM. I THANK GOD THE BRACKETS DIDN'T BRAKE AND THE WATER TANK DIDN'T FALL OUT WHILE DRIVING AND KILL SOMEONE. I BELIEVE THIS IS A MANUFACTURE DEFECT THAT NEEDS TO BE FIXED. MAKE STRONGER BRACKETS FOR THE HOLDING TANK BEFORE SOMEONE IS KILLED OR INJURED. IF THEY MAKE THE TANK TO HOLD THAT MUCH WATER THE BRACKETS SHOULD NOT BEND THEY TO SHOULD HOLD THAT MUCH WEIGHT. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
PURCHASED NEW=OCT.2004.......... 2005 FLEETWOOD TRAVEL TRAILER 25RKS......... MFG. INSTALLED INADEQUATE TIRES............ VEH.GVWR= 7250 LB.... TIRES MAX= 7280 LB LOAD C......... THREE TIRES POP SIDEWALLS WITHIN 1 YR......... VERY DANGEROUS HIGHWAY POTENTIALS........ MFG. SHOULD USE LOAD D FOR GVWR 7250 LB...
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .