2024 Ford Bronco Problems

Vehicle hands free for phone is not understandable to others after a software update over a year ago. After an automatic software update I made a phone call and the person called complained about me not being understandable. I disconnected and called again. Still unreadable. I tried calling someone else. Not readable. Was told I sounded like I had my head in a bucket of water. I called a third person. Not readable. All this happened immediately after the software update. I took my vehicle to the dealer the first opportunity I had time. The problem was verified by a service tech. He did a hard reboot of the system. The problem did not improve. I was asked to make an appointment. The vehicle has been back to the dealer many times since. The problem has not been resolved. The SAFETY PROBLEM is that I am not able to use my phone hands free. PA passed a law that touching a phone is a moving violation. The dealer said it was my phone. I have a Kyocera ruggedized phone. I replaced it with a newer version of the phone. Cost was over $800. FYI - I have used my phone on my wife's Bronco which has NEVER had a software update as the auto updates was turned off. I also own a Ford F-350 with Sync3 and the phone works fine. I was driving a Mack dump truck with hands free. No problem. I have checked it on 2 friends Honda cars. No problem. Apparently my phone works with everything but my Ford Bronco. Sometime during the last few months there was a safety recall for the same entertainment system that the phone uses going black. I never had this problem. Ford engineering still says the problem is my phone. I am not replacing my phone again to find that I still can't be understood. I have done some online research on this and found posts on multiple bulletin boards there seems to be the same problem with other owners of Ford Broncos and F-150s with Sync4. Not being able to use the hands free is a serious safety problem.

I notified the dealership where I bought the vehicle of the issue when it first happened in Feb 2025. I have since notified them 3 additional times and I have called Ford Motor Company, twice. The roof leaks in heavy rain while driving and when going through a car wash. The water streams inside and runs down onto the lighted vanity mirror which is connected to the electrical system of the vehicle and hits the driver in the face with water. The dealership said that they tried to reproduce the issue but couldn’t get it to leak. It’s because they aren’t using water at a high pressure and speed. I have since found that the issue is know as it is listed on the internet in multiple places.

I notified the dealership where I bought the vehicle of the issue when it first happened in Feb 2025. I have since notified them 3 additional times and I have called Ford Motor Company, twice. The roof leaks in heavy rain while driving and when going through a car wash. The water streams inside and runs down onto the lighted vanity mirror which is connected to the electrical system of the vehicle and hits the driver in the face with water. The dealership said that they tried to reproduce the issue but couldn’t get it to leak. It’s because they aren’t using water at a high pressure and speed. I have since found that the issue is know as it is listed on the internet in multiple places.

My MIC roof cracked, and I only have 6700 miles on the vehicle. I am now reading that my roof could blow off.

The contact owns a 2024 Ford Bronco. The contact stated that on several occasions, the APIM overheated, and the rearview camera was inoperable. The VIN was not included in NHTSA Campaign Number: 26V124000 (Back Over Prevention). Additionally, the power windows and AC were inoperable due to the failure. The contact stated that the vehicle stalled due to the APIM overheating. The dealer was contacted, and a repair of the vehicle was pending. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The following systems and features have been repeatedly failing in my vehicle, posing a safety hazard: 1) The side view mirrors change orientation automatically while driving. 2) The blind spot warning is inconsistent and is not trustworthy. 3) The infotainment display turns off erratically while crossing critical intersections where I am supposed to turn. This is extremely distracting and poses a severe safety risk. 4) The infotainment system’s audio volume, audio source and car play connection turns off randomly. This is extremely distracting and poses a severe accident risk. 5) The air conditioning strength and temperature changes automatically with the fan blowing extremely cold or extremely hot air. 6) The windshield wiper automatic speeds are mis-calibrated and gradation between the various levels is non-linear and erratic. This forces the driver to frequently adjust the wiper speed while driving, posing a distraction and accident risk. 7) The automatic high beam feature doesn’t work, or works erratically. This ambiguity causes distraction and dangerous night time driving situations. 8) With manual operation of high and low beams, there is a significant delay while switching from one to another, posing risk while night time driving. 9) The windshield cleaning feature with dispersal of the fluid works erratically. It works some of the time and doesn’t work other times. This ambiguity poses a severe risk while driving due to unclear windshield. 10) The tire pressure sensor displays inaccurate inflation pressure at times. This ambiguity can be catastrophic given the vehicle size and California’s mountain road driving under slick and snowy conditions. 11) The GPS directions displayed on phone and infotainment system are inaccurate and inconsistent, causing massive confusion while exiting. This is a new vehicle from 2024 and has been inspected and serviced at the dealership diligently. I have video evidence for some of the problems.

Brake system makes horrible noises, abs goes wild, brakes click from controller when pedal is pressed

There was a pot hold hole about 30 ft from a stop light. I was coming to a stop but once I hit the pot hole the breaks malfunctioned. I pumped the breaks 2-3 times. They did not reengage. This fault caused me to rear end the car in front of me at the stop light.

The contact owns a 2024 Ford Bronco. The contact stated that while coming to a stop, the vehicle would unexpectedly lunge forward and hesitate, with no warning lights illuminated. The contact also stated that a loud, abnormal rattling noise was coming from the soft top area of the vehicle. The vehicle was taken to the dealer; however, it was not diagnosed. The contact was informed that the transmission software needed to be reprogrammed. The dealer also stated that the soft top failure is a known issue with the vehicle. The vehicle was reprogrammed, but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 13,000.

The contact owns a 2024 Ford Bronco. The contact stated that while driving and coming to a stop, the Engine Auto Start-Stop system failed to engage, and the engine revved significantly, causing the vehicle to move forward unintendedly. The contact stated that the failure persisted while standing on the brake pedal, requiring the contact to shift to neutral(N) or to park(P) to stop the engine. The contact stated that the failure had occurred on two occasions. The contact stated that the vehicle nearly moved into oncoming traffic on the first occasion and the vehicle nearly crashed into the rear of another vehicle on the second occasion. The failure also required the contact to steer the vehicle away from another vehicle or to shut off the engine to avoid a crash. The vehicle was taken to the dealer, where it was determined that the failure might be related to a low battery. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 6,000.

The Sta-bar continues to disconnect. Had been in shop 5xs for same issue 2 weeks each time with hopes that they fixed it. Within 500miles after leaving shop it does it again and warning flashes to seek maintenance immediately. There is no obvious reason of why. It will donit when it's dry, when it's raining or snowing. It happens when I first turn car on or it could happen going 70mph on highway. Started within the first 1000 miles on car and has continued, currently at 18000miles. Car feels unsteady on every bump and ripple and with high winds when it occurs. It happens more times then I can count now, tired of paying high monthly payment for it to sit in shop.

Reservoir detached from right rear shock. Known problem. Recall 25V025. Dealer will not honor recall.

I was idling (foot on the brake) at a coffee drive thru when I started to smell smoke and suddenly a women ran up and told me my passenger side front tire was on fire.

The contact owns a 2024 Ford Bronco. The contact stated that while the vehicle was idling, a fire originated near the dashboard area without warning. The occupants inside the vehicle first noticed an abnormal smoke odor inside the vehicle. Shortly afterwards, the contact and passenger’s eyes started burning and their throats became irritated. The driver opened and then closed the windows and then safely pulled over. The heated seats were turned off during the failure. The passenger then observed flames coming from the passenger’s side air vent. The contact and passenger exited the vehicle with the engine still running. The windows blew out from the intense heat of the fire. The air bags did not deploy but started melting. The Fire Department arrived on the scene and extinguished the fire. No injuries were reported. A Police report was not filed, but the Police were directing traffic. The vehicle was towed to a collision center. The local dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a claim was opened. The manufacturer was contacted and referred the contact to the insurance company for assistance. The failure mileage was approximately 11,685.

The contact owns a 2024 Ford Bronco. The contact stated that while driving the vehicle at night, the headlights failed to provide adequate illumination and created a visibility hazard for the driver. While inspecting the vehicle, the contact discovered that there was condensation inside the front headlight assemblies, which caused the illumination from the headlights to be reduced. The contact indicated that the failure occurred while the temperature was below 50 degrees. The cause of the failures was not yet determined, and the vehicle was not repaired. The manufacturer and the local dealer were notified of the issue. The failure mileage was 3,500.

While driving on the interstate in light snow and mostly clear and semi dry roads, ice accumulates on both the head lights and the foglights to a degree that they no longer project enough light to see far enough ahead at even moderate speeds. When I pulled over to inspect them, the surface was coated with a mix of ice and dirt rendering them useless. Ambient temperatures were between 24 and 30 degrees. It seems that the LED lights lack enough heat to protect from ice accumulation and a heat element of some type should have been included given the placement of the lights being somewhat recessed and that allows for accumulation. Obviously in pre-dawn darkness this produced an unsafe operation of a vehicle at highway speeds due to not being able to see the road far enough in advance. As far as I know it has not been addressed or noticed by Ford since there is no information about this in their manual. I have seen aftermarket products that heat the light surface and prevent the accumulation of ice - Ford should retrofit something to prevent the accumulation of ice on light surfaces.

The Sta-bar continues to disconnect. Had been in shop 5xs for same issue 2 weeks each time with hopes that they fixed it. Within 500miles after leaving shop it does it again and warning flashes to seek maintenance immediately. There is no obvious reason of why. It will donit when it's dry, when it's raining or snowing. It happens when I first turn car on or it could happen going 70mph on highway. Started within the first 1000 miles on car and has continued, currently at 18000miles. Car feels unsteady on every bump and ripple and with high winds when it occurs. It happens more times then I can count now, tired of paying high monthly payment for it to sit in shop.

When turning right the left turn signal is triggered automatically 60-75% of the time. This mis direction signal has potential to cause confusion to surrounding drivers thus creating a potential driving hazard. The whole purpose of the turn signal is to declare driving intent to other drivers.

The following systems and features have been repeatedly failing in my vehicle, posing a safety hazard: 1) The side view mirrors change orientation automatically while driving. 2) The blind spot warning is inconsistent and is not trustworthy. 3) The infotainment display turns off erratically while crossing critical intersections where I am supposed to turn. This is extremely distracting and poses a severe safety risk. 4) The infotainment system’s audio volume, audio source and car play connection turns off randomly. This is extremely distracting and poses a severe accident risk. 5) The air conditioning strength and temperature changes automatically with the fan blowing extremely cold or extremely hot air. 6) The windshield wiper automatic speeds are mis-calibrated and gradation between the various levels is non-linear and erratic. This forces the driver to frequently adjust the wiper speed while driving, posing a distraction and accident risk. 7) The automatic high beam feature doesn’t work, or works erratically. This ambiguity causes distraction and dangerous night time driving situations. 8) With manual operation of high and low beams, there is a significant delay while switching from one to another, posing risk while night time driving. 9) The windshield cleaning feature with dispersal of the fluid works erratically. It works some of the time and doesn’t work other times. This ambiguity poses a severe risk while driving due to unclear windshield. 10) The tire pressure sensor displays inaccurate inflation pressure at times. This ambiguity can be catastrophic given the vehicle size and California’s mountain road driving under slick and snowy conditions. 11) The GPS directions displayed on phone and infotainment system are inaccurate and inconsistent, causing massive confusion while exiting. This is a new vehicle from 2024 and has been inspected and serviced at the dealership diligently. I have video evidence for some of the problems.

The contact owns a 2024 Ford Bronco. The contact stated that while the defroster was engaged, the windshield cracked on the driver’s side. The crack started at the bottom of the windshield and spread to approximately 7-inches. The contact had not taken the vehicle to a local dealer or a glass repair shop to be repaired. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to an issue with the OEM windshield. The manufacturer was not informed of the failure. The failure mileage was approximately 3,000.

I was idling (foot on the brake) at a coffee drive thru when I started to smell smoke and suddenly a women ran up and told me my passenger side front tire was on fire.

On Monday Jan 27 2025 i took my 2024 ford bronco in for routine maintenance and check up. Upon completion of these services my 2024 ford bronco was in terrific condition. Everything came back great they even coded it and it was good. By Wednesday [XXX] at [XXX] there was an issue with the Bronco it wouldn't detect the key fob it said no key detected on the dashboard. So I got my second key Fob and it also wasn't detected so then went to get new batteries for the key fob the car was not drivable at that time switched batteries twice still no detection. Called service at Rivertown ford to get assistance service person came to us because there was nowhere we could find the emergency fail safe that all the bronco of this year has since it's a push start button to start car. He did find the fail safe in the center console under the carpet and able to start car from there. Gary the service person told me it safe to drive back to rivertown service so they can find out what going on. Once in the service it was stated that it is radio transimission control module radio frequency failure. That it was ok to drive till they got part in. Didn't get half way home when a warning light came on that the tire pressure sensor failed so I took Bronco back immediately agian Gary service person told me it was safe to drive till they get the part ordered and in to service the Bronco. I called Ford corporation reported this issue with them Tei is the agent i spoke to from ford Corp. Case number is [XXX]. My concern is i have had plenty of vehicles in my lifetime and these services and mechanics tell you anything at times to justify the means a new car. I need to know it's safe to drive and if there is issues someone gonna pay attention take it seriously and fix it. There was no warning that fob was bad other than the no key detected and then later tire pressure sensor failure did come on. If this car is unsafe to drive or more of internal electric issue is coming address it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATI

On or about Feb10 2026 near [XXX] heading North I experienced an commanded accelerator input. I was stopping for a light on a section of the road where I always lose connection with the apple carplay in the vehicle. I suspect that there is an illegal radio jammer being used. On this particular occasion the traffic stopped at this location where I typically lose the connection from the phone to the infotainment system and the infotainment system resets. However this time the throttle advanced to almost full throttle without any input on the accelerator as my foot was on the brake in order to slow. I had to use full application of the brake in order to keep from hitting the car in front of me. Just as I started to shift the transmission to neutral the accelerator went back to idle. The event lasted about 5 seconds. My hypothesis is that some sort of radio interference is causing the system to reset and in this case it caused communication issues with the can bus or engine control module. I have not gone back to try and repeat the issue but the radio interference is still there in the same area. RF interference should not effect the function of the engine or vehicle controls. Feel free to contact me [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

There is an issue when I try to pump gas the pump repeatedly kicks off. It happens every time I put gas in my vehicle. It causes me to not know when the fuel is full. It’s not an issue with the gas pump because it happens at all different locations. It’s a problem with the vehicle itself.

The contact owns a 2024 Ford Bronco. The contact recieved notice of NHTSA Campaign Number: 26V268000 (Seats). The contact stated that the vehicle was taken in to a dealer where the failed the inspection and she was notified that the bolt could come loose. The manufacturer was not notified of the failure where she was notified that they did not have the part available at this time. The failure mileage was approximately 9,004.

Vehicle sustained significant front-end impact in a collision, but none of the airbags deployed. Front bumper, hood, and frame sustained visible damage. Concern that sensors or airbag system failed to activate during qualifying crash.