1996 Ford Club Wagon Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Ford Club Wagon, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes630.0%
- Airbags210.0%
- Engine210.0%
- Fuel system210.0%
- Electrical15.0%
- Steering15.0%
- Suspension15.0%
- Interior & seats15.0%
- Other / unspecified15.0%
- Seat belts15.0%
- Heating & air conditioning15.0%
- Driver assistance15.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
FRONT BRAKE PADS AND ROTORS WORN PREMATURELY. NLM
EXPERIENCING ONGOING BRAKE FAILURE. WHENEVER VEHICLE IS DRIVEN IN WET CONDITIONS, THE BRAKE PEDAL WOULD GO ALL THE WAY TO THE FLOOR, NO MATTER WHAT THE SPEED MAY BE. VEHICLE HAVE BEEN INSPECTED/REPAIRED BY INDEPENDENT REPAIR SHOP, BUT CONDITION STILL OCCURS. DEALER/MFR. WAS NOT NOTIFIED AT THIS TIME. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
THE CONSUMER WAS DRIVING AT 50 MPH ON WET PAVEMENT, AND VEHICLE STARTED SLIDING, CONSUMER LOST CONTROL AND HIT A GUARDRAIL HEAD ON. THEN VEHICLE ROLLED DOWN A HILL. UPON IMPACT, DRIVER'S SIDE AIR BAG DIDN'T DEPLOY. *AK
MADE A LEFT HAND TURN INTO A VEHICLE AND THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY. THE REAR SEAT BELTS, THAT LOCK DOWN THE WHEEL CHAIRS, CAME UNLATCHED. PLEASE DESCRIBE DETAILS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE STALLS OCCASIONALLY WHEN IN DRIVE AND AT A STOP, AND SOMETIMES INSTEAD OF JUST DYING IT TRIES TO STAY RUNNING BY FLOORING THE ACCELERATOR CAUSING ME TO HIT CURBS AND MY GARAGE WALL. I CAN AVOID THIS BY PLACING IT IN NEUTRAL TEMPORARILY. I HAVE TAKEN IT TO FORD ABOUT THREE TIMES FOR THIS ALONE, BUT THEY CANNOT FIGURE IT OUT BECAUSE IT IS AN INTERMITTENT PROBLEM WHICH THEY COULD NOT REPRODUCE. ALSO THE REAR BLEND DOOR FLAP FOR REAR A/C DETERIORATES EVERY YEAR AND NEEDS REPLACING TO STAY COOL IN PHOENIX, AZ. *JB
RUSTING OUT OILPAN WITH ONLY 38K MILES ON IT. HAVE BEEN TOLD IT'S A REACURING PROBLEM, LOOKING FOR A RECALL NOTICE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL FILLER PIPE ON THIS VEHICLE HAS FAILED THREE TIMES (FIRST FAILURE MILEAGE IS LISTED BELOW). EACH TIME THE FIRST SYMPTOM IS THE SMELL OF FUEL OUTSIDE THE VEHICLE AFTER DRIVING, WHEN THE PROBLEM WORSENS, AT TIME OF FILL-UP GAS SPILLS ON THE GROUND. *TR
WHILE FUELING GAS CAME OUT FROM UNDER VAN, NOT AT THE FILL NECK. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHEN THE FAN SWITCH WAS TURNED TO THE FAST POSITION AND THE A/C WAS TURNED ON THE CONSUMER BEGAN TO SMELL SOMETHING BURNING. AFTER A FEW SECONDS ALOT OF SMOKE CAME FROM UNDER THE DASH AND A/C AREA. THE CONSUMER REMOVED THE KNOB AND SAW FLAMES. THE CONSUMER TURNED OFF THE ENTIRE SYSTEM AND REMOVED THE CABLE. NO DAMAGE WAS REPORTED. *AK *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
VEHICLE WANDERS FROM SIDE TO SIDE AT NORMAL HIGHWAY SPEED. ATTEMPTING TO REMEDY THE WANDERING CAUSES AT TIMES A SERIOUS OVERSTEER PROBLEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
VEHICLE WANDERS FROM SIDE TO SIDE AT NORMAL HIGHWAY SPEED. ATTEMPTING TO REMEDY THE WANDERING CAUSES AT TIMES A SERIOUS OVERSTEER PROBLEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
BUTTON LATCH ON PASSENGER SEAT FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
MADE A LEFT HAND TURN INTO A VEHICLE AND THE DRIVER'S SIDE AIRBAG DID NOT DEPLOY. THE REAR SEAT BELTS, THAT LOCK DOWN THE WHEEL CHAIRS, CAME UNLATCHED. PLEASE DESCRIBE DETAILS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
THE SHOULDER BELTS ARE HOOKED TO THE ROOF OF THE VEHICLE, CAUSING THE BELTS TO GO ACROSS THE NECK, IRRITATING THE DRIVER. DEALER HAS NOT SEEN. *AK CONSUMER STATES THAT WHEN THE BELT CROSSES THE BODY, IT IS AGAINST WHERE SAFETY REGULATIONS SAY SHOULDER BELT SHOULD GO. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
ENGINE STALLS OCCASIONALLY WHEN IN DRIVE AND AT A STOP, AND SOMETIMES INSTEAD OF JUST DYING IT TRIES TO STAY RUNNING BY FLOORING THE ACCELERATOR CAUSING ME TO HIT CURBS AND MY GARAGE WALL. I CAN AVOID THIS BY PLACING IT IN NEUTRAL TEMPORARILY. I HAVE TAKEN IT TO FORD ABOUT THREE TIMES FOR THIS ALONE, BUT THEY CANNOT FIGURE IT OUT BECAUSE IT IS AN INTERMITTENT PROBLEM WHICH THEY COULD NOT REPRODUCE. ALSO THE REAR BLEND DOOR FLAP FOR REAR A/C DETERIORATES EVERY YEAR AND NEEDS REPLACING TO STAY COOL IN PHOENIX, AZ. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
DT: CONTACT STATED THERE WAS A FIRE ON THE MASTER CYLINDER ON A 1996 FORD CLUB WAGON. THIS VEHICLE WAS OWNED BY HIS EMPLOYER. THE CONSUMER STATED WHILE THE VEHICLE WAS SITTING IN THE PARKING LOT SMOKE STARTED COMING FROM UNDERNEATH THE HOOD. UPON INSPECTION, IT WAS FOUND THAT THE MASTER CYLINDER WAS MELTED. THE VEHICLE WAS DROVE APPROXIMATELY 8 HOURS BEFORE THE INCIDENT OCCURRED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .