1998 Ford Contour Electrical Problems

"TAKARA RECALL" MY HEATER MOTOR IN MY 98 FORD CONTOUR SE JUST STOPPED WORKING.

NHTSA ID

11153253

Incident

Nov 21, 2018

WAS DRIVING DOWN ROUTE 322 ON DAY AND HAD TO HIT THE BREAK AND ALL OF A SUDDEN THEY WENT TO THE FLOOR. I PULLED OVER AND CHECKED MY BREAK FLUID RESIVOUR AND IT WAS EMPTY. I THINK THE PASSENGER SIDE DRUM BREAK IS LEAKING FLUID.

NHTSA ID

11153195

Incident

Jun 20, 2018

Mileage

147,000 mi

I JUST TRADED AND GOT THIS CAR, IT SEEMS TO SWAY IN THE BACK GOING OVER WET ROADS OR BUMPY ROADS NOT SURE WHAT IT IS, BUT I FEAR MY SAFETY AS THE PREVIOUS OWNER DID NOT TELL ME ABOUT THIS. I ALSO HAVE NOTICED THAT THE TEMPERATURE GAUGE DOES NOT WORK AND THE HEATER BLOWER ONLY WORKS ON HIGH. I CANNOT AFFORD TO GET THINGS FIXED IF THERE IS RECALLS ON THEM. *TR

NHTSA ID

10553556

Incident

Nov 2, 2013

Mileage

163,000 mi

I AM THE OWNER OF A 1998 FORD CONTOUR AND THE ENGINE HARNESS WIRE OVERHEATED OVER A LONG PERIOD OF TIME AND I WAS UNAWARE UNTIL I HAD TO CHANGE MY RADIATOR DUE TO A LEAK AND THE HARNESS WIRE HAD TO BE DISCONNECTED. THAT WAS WHEN WE FOUND THE WIRE MELTED AND CRACKED AND COULD NOT BE REUSED. THIS HARNESS CONNECTS TO VEHICLE MAIN SUPPLY. WITHOUT HARNESS VEHICLE IS NOT OPERABLE. FORD SHOULD BE RESPONSIBLE TO REPLACE DEFECTIVE HARNESS. *TR

NHTSA ID

10535001

Incident

Aug 8, 2013

THE ENGINE WIRING HARNESS WHICH CONNECTS TO THE VEHICLE'S MAIN POWER SUPPLY BOX HAS WIRING FOR WHICH THE INSULATION COMES OFF EXPOSING LIVE, BARE WIRES. THIS LEADS TO SHORTS IN THE ELECTRICAL SYSTEM WHICH AFFECTS DRIVABILITY (ENGINE RUNS ERRATICALLY AND AFFECTS THE ELECTRIC FUEL PUMPS OPERATION) AND COULD LEAD TO A VEHICLE FIRE IF THE WIRING SUFFERS CATASTROPHIC FAILURE. IT GOES WITHOUT SAYING THAT IF THE CAR'S FUEL SUPPLY OR ENGINE CONTROL SYSTEMS FAIL, THE DRIVER MAY LOSE CONTROL AND BECOME INVOLVED IN A CRASH OR COLLISION. FORD DOES NOT SALE REPLACEMENT PARTS NOR ARE PARTS AVAILABLE ON THE SECONDARY MARKET. THE PART NUMBER FOR THE WIRING HARNESS ON MY CAR IS F8RZ14289CA. FORD SHOULD BE REQUIRED TO REPLACE THESE DEFECTIVE HARNESSES. *TR

NHTSA ID

10422939

Incident

Aug 1, 2011

Mileage

140,000 mi

TL*THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS HIS TAIL LAMPS, PARKING LAMPS, AND THE INSTRUMENTAL PANEL MALFUNCTIONED. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.

NHTSA ID

10402220

Incident

Apr 10, 2011

Mileage

107,000 mi

MY 1998 FORD CONTOUR HAS THREE SAFETY RECALLS. HOWEVER, I'M HAVING A TERRIBLE TIME GETTING FORD TO PROVIDE THE PARTS NEEDED TO SERVICE THE VEHICLE. THE RECALLS ARE: (A) 01S22 - HEATER BLOWER RESISTOR AND CONNECTOR, (B) 99S14 - HEADLIGHT SWITCH CONNECTOR, AND (C) 99S23 - FRONT CRASH SENSORS. PRESENTLY MY AIRBAGS ARE OFFLINE AND OFFER NO CRASH PROTECTION. IT'S BEEN A LITTLE OVER A MONTH SINCE I BEGAN TRYING TO GET THIS RESOLVED (BASICALLY WHEN I BOUGHT THE CAR - THE SELLER DIDN'T DISCLOSE THE RECALLS WERE NOT FIXED TO ME). THE BLOWER STOPPED WORKING A FEW DAYS AGO AND IT SMELLED LIKE ELECTRICAL WIRES WERE PERHAPS BURNING. SO NOW I DON'T HAVE DEFROST/DEFOG CAPABILITY. THE DEALER IS TRYING TO GET THE PARTS, BUT FORD HASN'T SHIPPED THEM. *TR

NHTSA ID

10396745

Incident

Apr 4, 2011

Mileage

135,000 mi

I OWN A 1998 FORD CONTOUR SE V6 MANUAL TRANS VIN #[XXX] THE UNDER THE HOOD WIRING HARNESS IS FAILING THERE WAS A RECALL FOR THIS DEFECTIVE PART BUT FORD CONTINUES TO SAY THAT MY CAR IS NOT UNDER THE RECALL THE INSULATION ON THE WIRING HARNESS HAS COMPLETELY FLAKED OR CRUMBLED OFF CAUSING THE CAR NOT TO RUN OR POTENTIAL DEADLY FIRE NO HELP FROM FORD MOTOR COMPANY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10386023

Incident

Feb 23, 2011

Mileage

93,000 mi

TL* THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT STATED THAT THE DRIVER WAS DRIVING AT AN UNKNOWN SPEED WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT, WHO WAS A CERTIFIED INDEPENDENT MECHANIC, WHERE HE DISCOVERED THAT ALL OF THE WIRES UNDER THE HOOD WERE EXPOSED AND CORRODING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 284,371.

NHTSA ID

10355185

Incident

Jun 1, 2010

Mileage

284,371 mi

WIRING CONNECTOR THAT FEEDS THE HVAC SYSTEM BURNED AND MELTED THE CONNECTOR PLUG AND MAIN FUSE BLOCK AT THE POINT OF THE CONNECTOR. THIS WIRE WAS A SIZE 10 AWG AND IS OVERSIZED FOR THE CONNECTOR THAT IT IS USED FOR. THIS CAUSED A FIRE AT THE CONNECTOR. I HAVE PICTURE IS YOU WOULD LIKE A COPY. *TR

NHTSA ID

10345853

Incident

Jul 23, 2010

Mileage

195,000 mi

TL*THE CONTACT OWNS A 1998 FORD CONTOUR. WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE LOST ALL POWER. THE CONTACT WAS ABLE TO COAST ONTO THE EMERGENCY LANE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE VEHICLE HAD SEVERE ELECTRICAL PROBLEMS AND SUGGESTED THAT THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER. THE DEALER ADVISED THE CONTACT THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WERE 92,000.

NHTSA ID

10344054

Incident

Jul 5, 2010

Mileage

92,000 mi

I HEARD ABOUT THE FORD CONTOUR ENGINE WIRING HARNESS RECALL ONLY BY INTERNET. MY CAR IS A FORD CONTOUR SPORT 1998. THE WIRE INSULATION IS PEELING OFF IN THE WHOLE HARNESS, AND THE CAR IS STOPPED NOW. MILEAGE IS APPROX. 110000. I NEVER RECEIVED ANY MESSAGE FROM FORD. I AM THE ONLY OWNER OF THE CAR. *TR

NHTSA ID

10330421

Incident

Mar 22, 2010

THE WIRING INSULATION ON MY 1998 FORD CONTOUR IS LITERALLY FALLING OFF THE WIRES. I AM AFRAID TO TOUCH ANY WIRE BECAUSE THE INSULATION JUST FLAKES OFF LEAVING BARE WIRE. THIS HAS BEEN OCCURRING FOR QUITE SOME TIME AND APPARENTLY IS FAIRLY COMMON IN THIS MODEL. *TR

NHTSA ID

10325248

Incident

Mar 27, 2010

Mileage

80,000 mi

INSULATION ON WIRING HARNESS BREAKING AND FALLING OFF.

NHTSA ID

10323215

Incident

Mar 30, 2010

Mileage

190,000 mi

TL* THE CONTACT OWNS A 1998 FORD CONTOUR. WHILE DRIVING APPROXIMATELY 60 MPH THE ENTIRE INSTRUMENT PANEL AND RADIO FAILED, AND THEN THE ENGINE STALLED. THE DRIVER WAS ABLE TO JUMP START THE ENGINE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR FACILITY, AND THE MECHANIC CONCLUDED THAT THE WIRING HARNESS FAILED. HIS VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL# 01V230000 (ELECTRICAL SYSTEM). NO REPAIRS WERE MADE, AND THE VEHICLE WAS INOPERABLE. THE FAILURE AND CURRENT MILEAGES WERE 82,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.

NHTSA ID

10288677

Incident

Oct 12, 2009

Mileage

82,000 mi

TL*THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT STATED THAT THE WIRING HARNESS AND THE WIRING AROUND THE HEATING UNIT SENSORS HAVE DETERIORATED. THE CODING HAS CRACKED OFF THE OTHER WIRES, CAUSING THEM TO BE EXPOSED. THIS ALLOWS ALL OF THE WIRES TO TOUCH EACH OTHER, WHICH COULD CAUSE A SHORT IN THE VEHICLE. AS A RESULT, THE ENGINE TEMPERATURE GAUGE DOES NOT WORK. THE VEHICLE IS STILL OPERABLE, BUT THE COOLANT TEMPERATURE BECOMES EXTREMELY HIGH. IN ADDITION, THE VEHICLE STALLS WHILE TRAVELING AT LOW SPEEDS, SUCH AS 15 MPH. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 01V230000. THE CONTACT FEELS THAT THE VEHICLE SHOULD BE INCLUDED IN THE RECALL SINCE THE FAILURES WERE IDENTICAL. THE CURRENT AND FAILURE MILEAGES WERE 62,000.

NHTSA ID

10267628

Incident

Apr 29, 2009

Mileage

62,000 mi

I HAVE A 1998 FORD CONTOUR LX WITH ONLY APPROX. 53,000 MILES ON IT. I AM ON THE 4TH (FOURTH) ALTERNATOR REPLACEMENT: AUGUST 2004, OCTOBER 2005, AUGUST 2006 AND NOW, SEPTEMBER 2008. THERE IS DEFINITELY A PROBLEM WITH THIS CAR. I WOULD LIKE TO KNOW IF THERE HAS BEEN A RECALL ON THIS YEAR AND MODEL OF FORD VEHICLE. *TR

NHTSA ID

10242759

Incident

Sep 18, 2008

1. ALL ENGINE WIRE HARNESS INSULATION IS CRACKING AND FALLING OFF. BARE WIRE AT MOST OF THE ENGINE COMPARTMENT CONNECTORS. UNKNOWN DAMAGE UNDER WIRE WRAPPING. EXISTING FORD RECALL COVER 95-97 YEAR MODELS. SUBJECT VEHICLE IS A 98 MODEL YEAR. 2. STILL WAITING FOR THE FIRST MAJOR MELTDOWN. CONNECTOR WIRES ARE PHYSICALLY PULLED APART TO PREVENT ELECTRICAL SHORTAGE. 3. NO REPAIR WORK HAS BEEN DONE. *TR

NHTSA ID

10233494

Incident

Jul 1, 2002

Mileage

60,000 mi

TL*THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT TOOK HIS VEHICLE TO A MECHANIC TO HAVE THE GEAR SHIFTING SYSTEM REPAIRED, AND WAS INFORMED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE CURRENT MILEAGE WAS 97,000 AND FAILURE MILEAGE WAS 27,300.

NHTSA ID

10224197

Incident

Sep 15, 2007

Mileage

27,300 mi

ORIGINAL START DATE 1-12-07. TIMING BELT SHREDDED. HAD SHOP FIX THE PROBLEM. 4-2-07 BELT BROKE AGAIN REPLACED AGAIN. 10-18-07 TIMING BELT BROKE AGAIN. SHOP DID NOT WANT TO REPLACE AGAIN SAID IT IS DEALER PROBLEM. DEALER SAYS SHOP PROBLEM. SHOP SAYS IT WILL FIX ON 11-2-07. SHOP FINALLY FIXES ON 11-4-05. CAR NOT RUNNING RIGHT TAKE BACK TO DEALER ON 11-5-07. DEALER SAYS WASN'T FIXED PROPERLY. 11-8-07 PICK UP FROM DEALER AND THEY STATE WE SHOULD HAVE ANY MORE PROBLEMS. IF SO BRING BACK UNDER WARRANTY. 3-13-08 DEALER NOW STATES BELT BROKE AND NOT COVERED AND OTHER MAJOR PROBLEMS. ALMOST 1600 TO FIX. STILL CAN'T GIVE ME SPECIFIC REASON TO WHY BELT KEEPS SHREDDING. NOW WHAT IS ONE TO DO? I HAVE PUT ALOT OF MONEY INTO THIS AND CAN'T GET A REAL ANSWER. ALSO IN THE PAST SHOP PRINTED OUT OTHER REPORTS FROM NHTSA SIGHT ABOUT THE SAME PROBLEM WITH THIS SAME CAR IN DIFFERENT STATES. BUT YET DEALER SAYS DON'T KNOW OF ANY OTHER PROBLEM LIKE THIS WITH THIS KIND OF CAR. *TR

NHTSA ID

10221153

Incident

Jan 12, 2007

ENGINE WIRING HARNESS INSULATION IS CRUMBLING LEAVING EXPOSED WIRES. FOUND THAT THIS IS A COMMON PROBLEM FOR FORD CONTOURS (ALL YEARS), BUT THAT A RECALL HAS ONLY BEEN ISSUED FOR 1995-1997 VEHICLES. HAVE HAD MULTIPLE PROBLEMS WITH SENSORS NOT WORKING, SPEEDOMETER AND FUEL GAUGE INTERMITTENTLY STOPS FUNCTIONING. CHECK ENGINE LIGHT COMES ON RANDOMLY. MECHANIC HAS STATED THAT PROBLEMS ARE IN WIRING HARNESS. *TR

NHTSA ID

10213101

Incident

Dec 28, 2007

Mileage

97,000 mi

I AM THE OWNER OF A 1998 FORD CONTOUR. I BOUGHT IT USED, AND WITHIN A 1 YEAR REMAINDER OF A 3 YEAR WARRANTY. I WAS NEVER OFFICIALLY NOTIFIED OF SEVERAL DEFECTS AND NHTSA RECALLS THAT ARE STILL IN EFFECT FOR THIS CAR MODEL YEAR. ONE OF THE REPAIRS FOR THE BLOWER RESISTOR WAS PERFORMED TWICE, HOWEVER IT WAS NEVER DONE TO MY SATISFACTION AND IT DID NOT MEET THE STANDARDS OF QUALITY AS EXPECTED FOR THE RECALL. THERE ARE SEVERAL SAFETY ISSUES WITH THIS CAR, AND I AM NOW AFRAID TO KEEP DRIVING IT AFTER WHAT I HAVE READ. THE FORD MOTOR COMPANY IS VERY NEGLIGENT IN FOLLOWING UP WITH CONSUMERS ON THESE ISSUES, AND THEY KEEP AN OUTDATED DATABASE OF FORMER OWNERS WHICH THEY FAIL TO UPDATE WITH THE CURRENT OWNERS IN CASES WHERE THE CAR OWNERSHIP HAS CHANGED HANDS. I AM KIND OF CLOSE TO HIRING A LAWYER TO SUE THEM OVER THESE RECALL ISSUES. WHAT SHOULD I DO? ARE THEY STILL OBLIGATED TO FIX THE RECALL ISSUES AT THEIR EXPENSE? I AM CERTAINLY NOT ABOUT TO PUT ONE DIME OF MY OWN MONEY INTO THAT CAR TO FIX ISSUES COVERED BY RECALLS. AGAIN, I DO NOT WISH TO FIGHT OR WRANGLE WITH A COMPANY THAT IS SO AWFUL WHO PUTS OUT A TERRIBLE AND CHEAP PRODUCT LIKE THE FORD CONTOUR, THEN WON'T STAND BEHIND THEIR CAR. HOWEVER, IF THERE ARE FORMAL RESPONSIBILITIES WHICH THEY ARE LEGALLY BOUND TO, I WILL RESERVE MY RIGHT TO PURSUE THIS UNDER THE FULLEST EXTENT OF THE LAW. PLEASE ADVISE. SINCERELY, MR. MCDONOUGH *TR

NHTSA ID

10209371

Incident

Nov 19, 2007

TL*THE CONTACT OWNS A 1998 FORD CONTOUR. OPEN ELECTRICAL CIRCUITS AND MELTED HOUSING MATERIALS WERE FOUND UNDER THE HOOD OF THE VEHICLE. THE CONTACT NOTIFIED FORD WHO STATED THAT HER VIN WAS NOT INCLUDED IN RECALL # 01V230000 (ELECTRICAL SYSTEM). FORD STATED THAT NOTHING COULD BE DONE. THE DEALER STATED THAT THE REPAIR WAS NEVER PREVIOUSLY PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 115,000.

NHTSA ID

10194892

Incident

Jun 18, 2007

Mileage

115,000 mi

TL*- THE CONTACT'S VEHICLE STALLED WHILE DRIVING 35 MPH AND THE DRIVER WAS UNABLE TO MOVE THE CAR FROM THE MIDDLE OF THE ROAD. THE CONTACT TOOK THE CAR TO DEALER (MAROONE FORD) AND THEY TOLD HER THAT THE FAILURE WAS DUE TO A PROBLEM WITH THE ELECTRICAL SYSTEM AND THAT IT WAS UNDER WARRANTY BUT SHE WILL HAVE TO WAIT FOR THE REPAIRS.

NHTSA ID

10176557

Incident

Dec 2, 2006

Mileage

30,000 mi

I HAVE A 1998 FORD CONTOUR SVT, THIS IS MY THIRD ONE. EVERY ONE I PURCHASE HAS THE SAME PROBLEM, THE WIRES IN THE WIRE HARNESS FOR THE COMPUTER AND CAR CRACK AND THE COATING JUST FALLS RIGHT OFF, WHICH ALLOWS THE WIRES TO THE COMPUTER TO TOUCH WHICH SHORTS THE COMPUTER AND MAKES THE CAR NO LONGER START, IT WILL CRANK BUT IT WILL NOT START CAUSE THE COMPUTER IN SHORTED AND CONFUSED SO THERE IS NO FUEL AND NO SPARK GOING TO THE FUEL RAIL OR THE COIL PACK. AT THIS POINT THE CAR NEEDS A WIRE HARNESS AND A PCM AND THIS ALL COSTS CLOSE TO $3000 OF WHICH I DO NOT HAVE TO FIX IT. MY FRIEND WORKED FOR GENERAL ELECTRIC AND HE SAID HE HAS SEEN THIS BEFORE AT THE FACTORY WHEN THE COATING IS HEATED TO HIGH ONCE IT DRYS ITS ONLY A MATTER OF TIME BEFORE THE COATING CRACKS AND FLAKES OFF. FORD SAYS THEY WILL NOT HELP ME ALTHOUGH ITS A CONSISTENT PROBLEM WITH THESE SVT CONTOURS I AM HOPING THIS CAN HELP ALL US FORD LOVERS. *NM

NHTSA ID

10175661

Incident

Nov 30, 2006

Mileage

107,556 mi