1992 Ford E-150 Problems

I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR

AS I WAS WATCHING TV IN MY HOUSE WITH MY SON. I NOTICED SOME YELLOW FLICKERING LIGHTS THROUGH MY WINDOW SHADES. I THOUGHT THERE WAS A TOW TRUCK OUT FRONT. I OPENED THE SHADE AND IT WAS MY VAN ON FIRE. *TR

I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR

BRAKE LIGHTS AND HAZARD LIGHTS WENT OUT. MECHANIC FOUND BURNT OUT SWITCH IN STEERING COLUMN FOR HAZARD LIGHT. SYSTEM. REPLACED. (FRIDAY MAY 1, 09) SATURDAY AFTERNOON 5-02-09 VAN SITTING IN DRIVE, HAD NOT BEEN DRIVEN SINCE PRIOR DAY, A BURST OF SMOKE AND SOME FLAMES CAME OUT FROM UNDER THE HOOD. THEN IT STOPPED. CALLED DEALER FIRST THING MONDAY MORNING 5-04 TO SEE IF COULD BRING IN FOR RECALLED WIRING HARNESS AND CC SWITCH TO BE REPLACED. WHEN GOT THERE BRAKE AND ABS LIGHT ON DASH ALSO CAME ON. DEALER SUPPOSEDLY HAS REPLACED THE DEFECTED PARTS AND LIGHTS ON DASH WENT OUT. ( MAY 4, 09.) I HAD CONTACTED THE DEALER REPEATEDLY IN THE PAST FEW YEARS ABOUT THIS RECALL AND WAS PUT OFF EACH TIME WITH NO PARTS, TOO BUSY, WHEN ASKED IF THEY COULD SIMPLY DISCONNECT THE UNIT, I WAS TOLD NO. NOT UNTIL I HAD A FIRE DID THEY OFFER TO GET HER IN AND REPLACE THE PARTS. AND THEN THEY SAID THEY MAY NOT REPLACE BOTH, ONLY THE HARNESS, WHICH I WAS NEVER NOTIFIED ABOUT IN THE RECALL. ONLY THE SWITCH. 1992 FORD E150 ECONOLINE VAN THEY WOULD NOT GIVE ME THE OLD PARTS SAID THEY HAD TO SEND BACK TO THE COMPANY. I HOPE THIS SOLVES THE PROBLEM I DO NOT KNOW YET BUT THEY REFUSE TO HANDLE ANYTHING ELSE ONLY THE RECALLED ITEMS. *TR

I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR

WHEN BRAKES ARE APPLIED ON WET PAVEMENT FRONT BRAKES LOCKS UP, CAUSING EXTENDED STOPPING DISTANCE. VEHICLE SLID WHICH HAS NEARLY CAUSED COLLISIONS TO OCCUR ,CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS.*AK

1992 FORD E-150 VAN VEHICLE IS STORED WINTERS WITH STA-BIL IN THE GASOLINE, SELDOM DRIVEN AND ONLY HAS 37K MILES ON IT. THE FLEXIBLE RUBBER FUEL HOSE BETWEEN THE METAL GAS TANK FILLER NECK WHERE YOU PUT THE GASOLINE IN AND THE NIPPLE ON THE GAS TANK DEVELOPED MULTIPLE CRACKS AND WOULD LEAK GAS WHEN RE-FUELING THE VEHICLE. THE HOSE ITSELF STILL HAS THE OEM NUMBERS ON IT. F2UA-9034-AF. I REPLACED THE HOSE WITH AFTERMARKET 1.5" FUEL FILLER HOSE FROM A NAPA AUTO PARTS FOR LESS THAN $15 AS FORD HAS SUPERSEDED F2UA-9034-AF WITH AN ASSEMBLY AT A COST OF $218. OLD HOSE IS AVAILABLE. *JB

WHILE FUELING THE VEHICLE, FUEL BEGAN LEAKING ON GROUND FROM FUEL TANK/FILLER AREA. LEAK STOPPED WHEN FUELING WAS DISCONTINUED. TOOK VEHICLE TO REPAIR SHOP AND THEY FOUND SPLIT APPROXIMATELY 3 INCHES LONG IN RUBBER FILL HOSE WHICH IS PART OF THE FUEL FILLER NECK ASSEMBLY HAD TO REPLACE THIS ASSEMBLY (AT 134,088 MILES) . HAD REPLACED THIS ASSEMBLY PREVIOUSLY AT ABOUT 90,000 MILES TO CURE A STRONG FUEL ODOR COMPLAINT. THIS FUEL HOSE SHOULD LAST FOR THE LIFE OF THE VEHICLE. IT'S FAILURE MIGHT RESULT IN FIRE HAZARD, PERSONAL INJURY OR DEATH. *LA

TL*THE CONTACT OWNS A 1992 FORD E150. THE CONTACT STATED THAT THE WIRING HARNESS CAUSED A FIRE ON THE PASSENGER SIDE OF THE VEHICLE. THE AUTOMATIC TRANSMISSION WAS DAMAGED. THE FORD DEALER REPLACED THE SWITCH, BUT FAILED TO RECOGNIZE THAT THE WIRES WERE FAULTY. THEY STATED THAT THE SWITCH WAS ON THE DRIVER SIDE AND THE FIRE BEGAN ON THE PASSENGER SIDE; THEREFORE, THE SWITCH WAS UNRELATED TO THE FIRE. THE CONTACT STATED THAT THE FAULTY SWITCH THAT REACHED OVER TO THE PASSENGER SIDE WIRES EVENTUALLY LED TO THE FIRE. THE DEALER STATED THAT THEY WOULD REPAIR THE VEHICLE IF GIVEN PERMISSION BY THE MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER AND THEY HUNG UP ON HIM. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 100,000. UPDATED 3/18/08 *CN THE CONSUMER STATED THEIR MECHANIC OBTAINED THE DAMAGE WIRES AND REMOVED TO AVOID FURTHER DAMAGE. THE CONSUMER FURTHER STATED THE TRANSMISSION HAD ALREADY FAILED AND COULD ONLY BE REPAIRED OR REPLACED. UPDATED 03/18/08 *TR

LINE THAT CARRIES TRANSMISSION FLUID TO/FROM AUTOMATIC TRANSMISSION TO RADIATOR/TRANSMISSION FLUID COOLER WERE PLACED OVER A WIRE BUNDLE WRAPPED WITH A HARD RUBBER WRAP. AFTER 13 YEARS/93K MILES, THIS CONSTANT CONTACT/RUBBING BETWEEN THE WRAPPED WIRE BUNDLE AND THE AUTOMATIC TRANSMISSION FLUID LINE RESULTED IN A HOLE WEARING IN THE ATF LINE, AND SUBSEQUENT LOSS OF TRANSMISSION FLUID. ONLY BECAUSE THIS FAILURE WAS DETECTED EARLY WAS A CATASTROPHIC LOSS OF ATF FLUID AND FAILURE OF THE TRANSMISSION AVERTED. WITHOUT EARLY DETECTION, SEVERE LOSS OF ATF FLUID WOULD OCCUR, WITH SUBSEQUENT FAILURE OF THE AUTOMATIC TRANSMISSION. THIS FAILURE COULD LEAVE THE VEHICLE IN A HAZARDOUS POSITION, SINCE IT COULD OCCUR WITHOUT WARNING.

TL*THE CONTACT OWNS A 1992 FORD E150. THE CONTACT STATED THAT THE WIRING HARNESS CAUSED A FIRE ON THE PASSENGER SIDE OF THE VEHICLE. THE AUTOMATIC TRANSMISSION WAS DAMAGED. THE FORD DEALER REPLACED THE SWITCH, BUT FAILED TO RECOGNIZE THAT THE WIRES WERE FAULTY. THEY STATED THAT THE SWITCH WAS ON THE DRIVER SIDE AND THE FIRE BEGAN ON THE PASSENGER SIDE; THEREFORE, THE SWITCH WAS UNRELATED TO THE FIRE. THE CONTACT STATED THAT THE FAULTY SWITCH THAT REACHED OVER TO THE PASSENGER SIDE WIRES EVENTUALLY LED TO THE FIRE. THE DEALER STATED THAT THEY WOULD REPAIR THE VEHICLE IF GIVEN PERMISSION BY THE MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER AND THEY HUNG UP ON HIM. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 100,000. UPDATED 3/18/08 *CN THE CONSUMER STATED THEIR MECHANIC OBTAINED THE DAMAGE WIRES AND REMOVED TO AVOID FURTHER DAMAGE. THE CONSUMER FURTHER STATED THE TRANSMISSION HAD ALREADY FAILED AND COULD ONLY BE REPAIRED OR REPLACED. UPDATED 03/18/08 *TR

WHILE DRIVING AND WITH NO WARNING VEHICLE WILL STALL, AND IT WILL BE HARD FOR CONSUMER TO CONTROL VEHICLE. DEALER NOTIFIED.*AK

THIS 1992 FORD ECONOLINE VAN DISPLAYS A DRIVERS SIDE AIR BAG WARNING LIGHT ON THE MAIN INSTRUMENT PANEL.

AIR BAG LIGHT IS ILLUMINATING ON THE DASH DUE TO A MALFUNCTION WITHIN THE SYSTEM. CONSUMER HAS CONTACTED THE DEALER. PARTS HAS YET TO BE REPLACED. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

THIS COMPLAINT IS ABOUT MILESTONE TIRES, MANUFACTURED IN CHINA, MODEL NUMBER MILESTONE RL828, G104/101S, STANDARD RIM 61/2J, SIZE LT 235/75. THREE OF THE FOUR TIRES BY THIS MANUFACTURER THAT WERE INSTALLED ON MY FORD E150 CONVERSION VAN HAVE HAD BELT FAILURES. THE TIRE THAT FAILED ON JUNE 28 HAD APPROXIMATELY 5,000 MILES ON IT, AND THE TIRE HAD JUST BEEN INFLATED TO FULL PRESSURE DURING AN OIL CHANGE APPROXIMATELY 200 MILES PRIOR TO FAILURE. THE PROBLEM WITH THESE TIRES IS APPARENTLY A BELT SEPARATION. TWO TIRES WERE REPLACED BY MY MECHANIC UPON INSPECTION IN SEPTEMBER OF 2004 AFTER APPROXIMATELY 8,000 MILES, AND PARTIALLY WARRANTEED BY THE DISTRIBUTOR. THE DISTRIBUTOR AT THAT TIME ACKNOWLEDGED PROBLEMS WITH THESE TIRES, AND INDICATED THAT THESE PROBLEMS HAD BEEN SOLVED WITH THE REPLACEMENT TIRES. HOWEVER, ONE OF THE REPLACEMENT TIRES BLEW OUT ON JUNE 28, 2005. THE DISTRIBUTOR IS REQUESTING THAT I PROVIDE THE TIRE, WHICH WAS LOST, ALONG WITH THE RIM, WHEN IT DISINTEGRATED WHILE I WAS DRIVING AT APPROXIMATELY 50 MILES PER HOUR. TO DATE, MY MECHANIC IS RECEIVING VERY LITTLE COOPERATION FROM THE TIRE DISTRIBUTOR. MY MECHANIC IS HARRY'S SERVICE, 315 689-6448, LOCATED IN JORDAN, NEW YORK. DAMAGES INCLUDED LOSS OF THE TIRE, LOSS OF THE RIM, DESTRUCTION OF THE DRIVER SIDE BRAKE ROTOR, AND FRONT END DAMAGES. THE FACT THAT MY FAMILY AND I ARE STILL ALIVE HAS MORE TO DO WITH MY EXPERIENCE AS A DRIVER THAN WITH THE EXTENT OF THE FAILURE -- THE CONVERSION VAN COULD VERY EASILY HAVE ROLLED OVER, KILLING EVERYONE INSIDE. PLEASE STOP THE DISTRIBUTION OF THESE DANGEROUS TIRES IN THE UNITED STATES, AND FINE THE DISTRIBUTOR FOR KNOWINGLY CONTINUING DISTRIBUTION OF UNSAFE TIRES. PLEASE FEEL FREE TO CONTACT ME AT ANY TIME. THANK YOU. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ORGINIAL TIRES PURCHASED 10/13/98, FROM THEN UNTIL 10/31/00 TIRES WERE CHECKED ON SIX DIFFERENT TIMES BECAUSE OF VIBRATION. EACH TIME THE TIRES WERE EITHER ROTATED, BALANCED OR SHOCKS CHECKED. THEN ON 10/30 /00 THE LEFT REAR TIRE LOST A CHUNK OF THE TIRE WITH NO INJURY OR ACCIDENT, BUT WHEN IT WAS TAKEN IN TO RAPLACE THE TIRE, I WAS TOLD THAT THE OTHER TIRES WERE SEPARATING AND NEEDED REPLACING.*AK (DOT NUMBER: VDHLW02208 TIRESIZE: D235175R15)

ON BOTH SIDES OF THE VEHICLE, THERE ARE CRACKS IN THE STEEL FRAME. DEALER HAVE LOOKED AT THE PROBLEM, AND STATED THAT THE CRACKS WERE NORMAL. *AK

FIRE STARTED IN THE DOOR, APPEARED TO BE ELECTRICAL

LUG NUTS ON VEHICLE WERE OVER TIGHTENED AND BROKE OFF. *BF THE CONSUMER ALSO NOTICED THAT ONE OF THE TIRES WAS LEANING FORWARD AND THE REMAINING 2 LUG NUTS WERE CRACKED. *JB

RIGHT FRONT WHEEL CAME OFF CAUSING DAMAGE TO VEHICLE. (OHIO TRAFFIC CRASH REPORT).

WHILE DRIVING MY 1992 E-150 ECONOLINE FORD, SMOKE STARTED COMING FROM VEHICLE AIR VENTS AND UNDER DASH BOARD. I PULLED TO SIDE OF THE ROAD DISCONNECTED THE BATTERY. WITH THE HELP AND USE OF PASSING VEHICLE THAT STOPPED AND LET ME USE HIS CELL PHONE TO CALL THE FIRE DEPT, BY THIS TIME MY VEHICLE TOTALLY ON FIRE. *TR

WIRING FOR DRIVER'S POWER SEAT INCORRECTLY ROUTED, ALLOWING SEAT SPRINGS TO CUT INTO WIRING SHORTING, RESULTING IN FIRE.

LOSS OF STEERING CONTROL.

STEERING COLUMN LOCKS UP.

UPPER BALL JOINTS FAILED FOUR TIMES.

WHEN APPLYING THE BRAKES, THE VEHICLE PULLS TO THE RIGHT/REPLACED FRONT BRAKE ROTORS/ CALIPER PIN, ALSO POWER STEEERING BELT/ENGINE BELTS FAILED, CAUSING ENGINE NOISE/FRONT END MISALIGNMENT, RESULTING IN VEHICLE PULLING TO THE RIGHT. *AK

BRAKE LIGHTS AND HAZARD LIGHTS WENT OUT. MECHANIC FOUND BURNT OUT SWITCH IN STEERING COLUMN FOR HAZARD LIGHT. SYSTEM. REPLACED. (FRIDAY MAY 1, 09) SATURDAY AFTERNOON 5-02-09 VAN SITTING IN DRIVE, HAD NOT BEEN DRIVEN SINCE PRIOR DAY, A BURST OF SMOKE AND SOME FLAMES CAME OUT FROM UNDER THE HOOD. THEN IT STOPPED. CALLED DEALER FIRST THING MONDAY MORNING 5-04 TO SEE IF COULD BRING IN FOR RECALLED WIRING HARNESS AND CC SWITCH TO BE REPLACED. WHEN GOT THERE BRAKE AND ABS LIGHT ON DASH ALSO CAME ON. DEALER SUPPOSEDLY HAS REPLACED THE DEFECTED PARTS AND LIGHTS ON DASH WENT OUT. ( MAY 4, 09.) I HAD CONTACTED THE DEALER REPEATEDLY IN THE PAST FEW YEARS ABOUT THIS RECALL AND WAS PUT OFF EACH TIME WITH NO PARTS, TOO BUSY, WHEN ASKED IF THEY COULD SIMPLY DISCONNECT THE UNIT, I WAS TOLD NO. NOT UNTIL I HAD A FIRE DID THEY OFFER TO GET HER IN AND REPLACE THE PARTS. AND THEN THEY SAID THEY MAY NOT REPLACE BOTH, ONLY THE HARNESS, WHICH I WAS NEVER NOTIFIED ABOUT IN THE RECALL. ONLY THE SWITCH. 1992 FORD E150 ECONOLINE VAN THEY WOULD NOT GIVE ME THE OLD PARTS SAID THEY HAD TO SEND BACK TO THE COMPANY. I HOPE THIS SOLVES THE PROBLEM I DO NOT KNOW YET BUT THEY REFUSE TO HANDLE ANYTHING ELSE ONLY THE RECALLED ITEMS. *TR

GASOLINE LEAK DUE TO CAPTAINS CHAIR BOLT BEING DRIVEN INTO TANK, CAUSING HOLE.

THIS IS A DESIGN PROBLEM RELATING TO ALL VANS WITH REAR HEATERS MANUFACTURED FROM 1991 TO THE PRESENT. THE TUBING LEADING TO THE REAR HEATER HAS RUSTED OUT ON ALL 18 OF OUR FLEET VANS. WITHOUT CLOSE INSPECTION, TUBE COULD RUST COMPLETELY THROUGH, CAUSING LOSS OF ENGINE COOLANT. THE TUBES RUN UNDER THE BODY OF THE VAN AND THROUGH THE REAR WHEEL WELL, WHERE THEY ARE EXPOSED TO ROAD SALT AND OTHER ENVIRONMENTAL CONDITIONS. OUR NEWEST VAN HAS ONLY 12,000 MILES AND IS ALREADY SHOWING SIGNS OF RUST.