2012 Ford E-150 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2012 Ford E-150, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Powertrain (other)317.6%
- Seat belts211.8%
- Suspension211.8%
- Body & structure211.8%
- Engine15.9%
- Exterior lighting15.9%
- Other / unspecified15.9%
- Steering15.9%
- Tires & wheels15.9%
- Brakes15.9%
- Driver assistance15.9%
- Electrical15.9%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WAS DRIVING VEHICLE FELT JERKING AND HEARD GRINDING NOISE. PULLED OFF HIGHWAY INTO PARKING LOT. CHECK COULD NOT FIND ANYTHING WRONG. TRIED TO BACK UP VEHICLE JERK VERY BADLYWOULDNOTBACK-UP. VEHICLEWOULDDRIVEFORWARD. *TR
TL* THE CONTACT OWNS A 2012 FORD E-150. WHILE DRIVING 45 MPH, THE VEHICLE SHIFTED INTO FIRST AND SECOND GEARS, BUT COULD NOT SHIFT OUT OF SECOND GEAR. THE CONTACT STATED THAT AN UNKNOWN WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HOLMAN FORD LINCOLN MAPLE SHADE (571 NJ-38, MAPLE SHADE TOWNSHIP, NJ 08052, 888-722-6721) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WERE NO RECALLS AND THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
Passenger seat belt stopped working out of the blue. I've had tire sensor thing on my dash since I've bought it an I'm not sure what is happening. The horn stopped working recently. And the overhead dome light doesn't work.
UGA
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
DRIVING THIS VAN IS VERY DIFFICULT, IT WILL NOT HOLD A STRAIGHT LINE ,WHEN YOU PASS BIG TRUCKS GOING APPROXIMATELY 65 MPH ,THE VACUUM SUCKS IT UP ,AND IT GETS MORE UNCONTROLLABLE,CAUSING A MINOR FISH TALE. OF COURSE FORD CHECKED IT OUT AND FOUND NOTHING WRONG .M---KS COULD NOT DUPLICATE THE PROBLEM..DO NOT DRIVE THIS VAN IF IS AT ALL WINDY,COULD BECOME UNCONTROLLABLE AND UNSAFE . THE WANDERING IN THE STEERING IS NOT ACCEPTABLE .I WOULD NOT RECOMMEND THIS VAN FOR ANYONE. OR ANY BUSINESS. *TR
VEHICLE TRACKS DOWN ROAD SIDEWAYS BY 6 INCHES. THIS WILL CAUSE PREMATURE TIRE WEAR AND STEERING PROBLEMS. LOCAL DEALERSHIP SAID THERE WAS NOT A PROBLEM WITH THE VEHICLE AND FORD CUSTOMER CARE HAS NOT RETURNED CALLS SINCE INITIAL CONTACT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
UGA
MY 11 YEAR OLD DAUGHTER WAS ATTEMPTING TO CLOSE THE TAILGATE AND DIDN'T SEE THERE WAS SOMETHING LODGED IN THE CREVICE. THE TAILGATE POPPED OFF AND FELL ON HER KNEE. SHE IS IN EXCRUCIATING PAIN. WE ARE AT THE ER. THIS IS NOT SAFE. THERE HAS TO BE A BETTER SAFER WAY TO ATTACH THE GATE. I HAVE OWNED 3 F150S AND HAVE NEVER HAD THIS ISSUE. THANK GOD MY 6 YEAR OLD WAS OUT OF THE VECINITY. THIS COULD HAVE EASILY INJURED OR KILLED HIM AS WELL.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ON SUNDAY, AUGUST 20, DRIVING S81 JUST BEFORE THE SALEM EXIT, THE 2012 FORD E-150 WHITE CARGO VAN 4.6L ROMEO ENGINE BLEW A SPARK PLUG OUT OF THE #3 CYLINDER HEAD WHILE ACCELERATING FROM 40 MPH. THE PLANNED TRIP STARTED FROM HARRISBURG PA TO ANDREWS NC. TO WITNESS A SOLAR ECLIPSE. ENGINE FAILURE HAPPEN AT APPROXIMATELY 40MPH JUST NORTH OF THE SALEM EXIT OFF 81 SOUTH. THERE WAS NO SHOP AVAILABLE TILL NEXT DAY TO REPAIR DAMAGE.. DAMAGES INCLUDED A OVERNIGHT STAY, MISSING THE SOLAR ECLIPSE OF 2017 AND REPAIR AND PARTS COST OF OVER $300.00 SPARK PLUG WAS DESTROYED. THE COIL WAS DESTROYED AND THE CYLINDER HEAD WAS RENDER USELESS. AT THIS TIME A TEMPORARY TAP WAS MADE AND HELI COIL WAS INSERTED TO HOLD A NEW SPARK PLUG IN PLACE AND CONTINUE OUR TRIP THE NEXT DAY. SINCE THEN IT BLEW AGAIN AND I HAVE NO TRANSPORTATION FOR ME AND MY TOOLS. I HAVE REPORTED THIS COMPLAINT TO CORPORATE FORD FOR REVIEW. FORD STATED THEY WILL RESPOND BY EMAIL WEDNESDAY DECEMBER 27. TO DETERMINE CULPABILITY FOR MANUFACTURING FLAW WITH INFERIOR ALUMINUM HEAD DESIGN. TOTAL DAMAGES ESTIMATE $2500 TO $4000. SINCERELY OWNER 12/22/17 SUBMITTED TO CAS & NHTSA. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
Passenger seat belt stopped working out of the blue. I've had tire sensor thing on my dash since I've bought it an I'm not sure what is happening. The horn stopped working recently. And the overhead dome light doesn't work.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
DRIVING THIS VAN IS VERY DIFFICULT, IT WILL NOT HOLD A STRAIGHT LINE ,WHEN YOU PASS BIG TRUCKS GOING APPROXIMATELY 65 MPH ,THE VACUUM SUCKS IT UP ,AND IT GETS MORE UNCONTROLLABLE,CAUSING A MINOR FISH TALE. OF COURSE FORD CHECKED IT OUT AND FOUND NOTHING WRONG .M---KS COULD NOT DUPLICATE THE PROBLEM..DO NOT DRIVE THIS VAN IF IS AT ALL WINDY,COULD BECOME UNCONTROLLABLE AND UNSAFE . THE WANDERING IN THE STEERING IS NOT ACCEPTABLE .I WOULD NOT RECOMMEND THIS VAN FOR ANYONE. OR ANY BUSINESS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
DRIVING THIS VAN IS VERY DIFFICULT, IT WILL NOT HOLD A STRAIGHT LINE ,WHEN YOU PASS BIG TRUCKS GOING APPROXIMATELY 65 MPH ,THE VACUUM SUCKS IT UP ,AND IT GETS MORE UNCONTROLLABLE,CAUSING A MINOR FISH TALE. OF COURSE FORD CHECKED IT OUT AND FOUND NOTHING WRONG .M---KS COULD NOT DUPLICATE THE PROBLEM..DO NOT DRIVE THIS VAN IF IS AT ALL WINDY,COULD BECOME UNCONTROLLABLE AND UNSAFE . THE WANDERING IN THE STEERING IS NOT ACCEPTABLE .I WOULD NOT RECOMMEND THIS VAN FOR ANYONE. OR ANY BUSINESS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2012 FORD ECONOLINE E150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13T012000 (TIRES). THE DEALER WAS CONTACTED AND MADE HIM AWARE THAT THE MANUFACTURER DID NOT HAVE THE TIRES AVAILABLE FOR REPLACEMENT. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Passenger seat belt stopped working out of the blue. I've had tire sensor thing on my dash since I've bought it an I'm not sure what is happening. The horn stopped working recently. And the overhead dome light doesn't work.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
Is making a grinding noise and will jerk to the right. Will flash cruise control and traction control lights.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
UGA
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .