RoadVitals

1997 Ford E-450 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
18
Latest Jul 13, 2011
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Body & structure

Reports naming the vehicle structure, frame, body panels, doors, hood and trim.

10
reports

From owner reports, verbatim

THE FRONT CROSSMEMBER CRACKING AT MAIN FRAME, FORD HAS ISSUED A SERVICE BULLETIN #991411 TO ADDRESS THIS CONDITION. REWELDING OF CROSSMEMBER HAS NOT CORRECTED PROBLEM, WAS STILL CRACKING, REDONE WITH SUPPORT ADDED. *MJS

NHTSA ID 559842 · filed Feb 26, 2001

THE FRONT CROSSMEMBER CRACKING AT MAIN FRAME, FORD HAS ISSUED A SERVICE BULLETIN #991411 TO ADDRESS THIS CONDITION. REWELDING OF CROSSMEMBER HAS NOT CORRECTED PROBLEM, WAS STILL CRACKING, REDONE WITH SUPPORT ADDED. *MJS

NHTSA ID 559841 · filed Feb 26, 2001
All 10 reports naming body & structure →

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

7
reports

From owner reports, verbatim

THE 1997 TIRES WITH 18,000 MILES ON THEM HAVE LARGE CRACKS AROUND THE ENTIRE SIDEWALL OF ALL 6 TIRES (MOTORHOME). NOW AFRAID TO DRIVE BECAUSE OF ALL THE FIRESTONE RE-CALLS. WAS WONDERING IF THESE TIRES HAD A RE-CALL (FIRESTONE STEELTEX RADIAL R4S, LT225/75R16 M/S). NO "INCIDENT" AS OF YET... *LA

NHTSA ID 10065633 · filed Apr 6, 2004

TREAD SEPARATION, WOULD AVE CAUSED A SERIOUS ACCIDENT IF TIRE HAD BEEN LOCATED ON FRONT WHEEL. *AK

NHTSA ID 764770 · filed Jul 26, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

1
report

From owner reports, verbatim

TL* THE CONTACT OWNS A 1997 FORD E-450. THE CONTACT STATED THE HEATER CONTROL SWITCH FAILED TO FUNCTION; THEREFORE, ONLY COLD AIR EMITS FROM THE HEATER SYSTEM. THE CONTACT BELIEVED THE FAILURE WAS RELATED TO THE FAILURE DESCRIBED IN A MANUFACTURES RECALL . THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

NHTSA ID 10412171 · filed Jul 13, 2011

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .