2008 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2008 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine222.2%
- Tires & wheels222.2%
- Driver assistance111.1%
- Other / unspecified111.1%
- Powertrain (other)111.1%
- Fuel system111.1%
- Electrical111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE DRIVING ON INTERSTATE HWY ENGINE LOSS POWER. TRUCK WOULD NOT GO OVER 35 MPG. APPROX THREE MONTHS LATER IT DONE IT AGAIN. ON TWO MORE TIMES IT SHUT OFF ON INTERSTATE . *TR
TL*THE CONTACT OWNS A 2008 FORD E450 HE PURCHASED IN 2007. HE STATED THAT THE VEHICLE WOULD LURCH FORWARD WHEN HE DEPRESSED THE BRAKE PEDAL. IN ADDITION, HE FELT THAT THE ACCELERATOR IS TOO CLOSE TO THE BRAKE PEDAL. THE DEALER REFUSED TO REPAIR THE VEHICLE IT IS A RECREATIONAL VEHICLE. THE FAILURE MILEAGE WAS 150 AND CURRENT MILEAGE IS 2,300.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
PURCHASED THIS MOTOR-HOME NEW IN 2009. DROVE THE MOTOR-HOME 4 YEARS APPROXIMATELY 25,000 MILES WITH NO PROBLEMS. IN MAY OF 2013, I PURCHASED 6 DELTA ESSENTIAL TIRES ( LT225/75R16 ) TO REPLACE THE OLD TIRES THAT WOULD NOT PASS STATE INSPECTION DUE TO CRACKS IN THE SIDE WALLS. THEN WE TOOK A 7500 MILE TRIP ACROSS THE COUNTRY AND BACK WITHOUT INCIDENT. WHEN WE RETURNED HOME UPON ROUTINE INSPECTION OF MY TIRES I FOUND A BUBBLE ON THE INSIDE SIDEWALL OF A REAR PASSENGER INSIDE DUAL TIRE. THE TIRE DEALER REPLACED THAT TIRE AT NO COST. ABOUT TWO MONTH LATER 10/09/2013, WE LEFT ON A TRIP TO DISNEY IN FLORIDA. ON 10/10/2013 WHILE ON I-95 SOUTH BOUND NEAR MIDWAY, GA. THE DRIVER'S SIDE OUTSIDE REAR DUAL TREAD SEPARATED AND THE TIRE BLEW OUT RESULTING IN DAMAGE TO 2 COMPARTMENTS ON THE DRIVERS SIDE. WE HAD THE TIRE REPLACED BY ROADSIDE ASSISTANCE ON THE SIDE OF THE ROAD ( I-95) WHERE IT HAD BLOWN AND THEN FOUND A PLACE TO STAY FOR THE NIGHT. THE NEXT MORNING 10/11/2013, BEFORE WE CONTINUED OUR TRIP I PERFORMED MY USUAL PRE-TRIP INSPECTION CONCENTRATING ON THE TIRES AND NOTICED NOTHING UNUSUAL. AFTER ABOUT 3 HOURS INTO THE TRIP NEAR ORMOND,FLORIDA THE PASSENGER SIDE OUTSIDE REAR DUAL TREAD SEPARATED AND BLEW OUT RESULTING IN DAMAGE TO 2 COMPARTMENT ON THAT SIDE. WE ALSO HAD TO PURCHASE A TIRE FROM ROAD SIDE ASSISTANCE TO REPLACE THAT TIRE DUE TO BEING OUT OF SPARES. WE FINISHED THE TRIP AND RETURNED HOME WITHOUT INCIDENT. WE ARE CURRENTLY WORKING WITH THE TIRE DEALER AND INSURANCE COMPANY IN MAKING REPAIRS TO OUR MOTOR-HOME. MY MAIN CONCERN IS 3 OUT OF 6 TIRES FAILED UNDER 10,000 MILES AND THESE TIRES SHOULD BE INVESTIGATED. AS A NOTE I DO CHECK MY TIRES ROUTINELY... *TR
2008 FORD E450, GULFSTREAM CLASS "C" MOTOR HOME. NO ACCIDENT. OBSERVED SEVERE CRACKING IN ALL TIRES, DRYROT. LATER QUESTION TO ID WHICH TIRE, LISTED RF. IT IS ALL 6 TIRES ON GROUND AND SPARE. 7 TOTAL. TOOK IN TO DEALER THIS DATE. THE CONTACTED MFG. MFG OK'ED REPLACEMENT HOWEVER REQUIRES 20% PAYMENT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
The component that failed was the transmission and transmission pump. We have receipts and digital verification of this situation as a common problem with this Ford model. Our safety was put at risk as the vehicle suddenly lost power on the highway in a rural area and we had to drift with what speed we had left to the right lane shoulder and hope there was a shoulder as we could not back up or go forward. The vehicle is in claims processing with insurance, however 3 experts in the auto industry reported this a common problem for this make/model of Ford. There were no warning lamps or messages prior to the failure--specifically there is not a dash gauge for the transmission temperature and there should be.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
PURCHASED THIS MOTOR-HOME NEW IN 2009. DROVE THE MOTOR-HOME 4 YEARS APPROXIMATELY 25,000 MILES WITH NO PROBLEMS. IN MAY OF 2013, I PURCHASED 6 DELTA ESSENTIAL TIRES ( LT225/75R16 ) TO REPLACE THE OLD TIRES THAT WOULD NOT PASS STATE INSPECTION DUE TO CRACKS IN THE SIDE WALLS. THEN WE TOOK A 7500 MILE TRIP ACROSS THE COUNTRY AND BACK WITHOUT INCIDENT. WHEN WE RETURNED HOME UPON ROUTINE INSPECTION OF MY TIRES I FOUND A BUBBLE ON THE INSIDE SIDEWALL OF A REAR PASSENGER INSIDE DUAL TIRE. THE TIRE DEALER REPLACED THAT TIRE AT NO COST. ABOUT TWO MONTH LATER 10/09/2013, WE LEFT ON A TRIP TO DISNEY IN FLORIDA. ON 10/10/2013 WHILE ON I-95 SOUTH BOUND NEAR MIDWAY, GA. THE DRIVER'S SIDE OUTSIDE REAR DUAL TREAD SEPARATED AND THE TIRE BLEW OUT RESULTING IN DAMAGE TO 2 COMPARTMENTS ON THE DRIVERS SIDE. WE HAD THE TIRE REPLACED BY ROADSIDE ASSISTANCE ON THE SIDE OF THE ROAD ( I-95) WHERE IT HAD BLOWN AND THEN FOUND A PLACE TO STAY FOR THE NIGHT. THE NEXT MORNING 10/11/2013, BEFORE WE CONTINUED OUR TRIP I PERFORMED MY USUAL PRE-TRIP INSPECTION CONCENTRATING ON THE TIRES AND NOTICED NOTHING UNUSUAL. AFTER ABOUT 3 HOURS INTO THE TRIP NEAR ORMOND,FLORIDA THE PASSENGER SIDE OUTSIDE REAR DUAL TREAD SEPARATED AND BLEW OUT RESULTING IN DAMAGE TO 2 COMPARTMENT ON THAT SIDE. WE ALSO HAD TO PURCHASE A TIRE FROM ROAD SIDE ASSISTANCE TO REPLACE THAT TIRE DUE TO BEING OUT OF SPARES. WE FINISHED THE TRIP AND RETURNED HOME WITHOUT INCIDENT. WE ARE CURRENTLY WORKING WITH THE TIRE DEALER AND INSURANCE COMPANY IN MAKING REPAIRS TO OUR MOTOR-HOME. MY MAIN CONCERN IS 3 OUT OF 6 TIRES FAILED UNDER 10,000 MILES AND THESE TIRES SHOULD BE INVESTIGATED. AS A NOTE I DO CHECK MY TIRES ROUTINELY... *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The component that failed was the transmission and transmission pump. We have receipts and digital verification of this situation as a common problem with this Ford model. Our safety was put at risk as the vehicle suddenly lost power on the highway in a rural area and we had to drift with what speed we had left to the right lane shoulder and hope there was a shoulder as we could not back up or go forward. The vehicle is in claims processing with insurance, however 3 experts in the auto industry reported this a common problem for this make/model of Ford. There were no warning lamps or messages prior to the failure--specifically there is not a dash gauge for the transmission temperature and there should be.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2008 FORD ECONOLINE E450. THE CONTACT STATED THAT HE SMELLED FUEL. HE ALSO CHECKED THE FUEL TANK AND FUEL LINES AND DIDN'T OBSERVED ANY DAMAGE TO THE FUEL TANK. THE DEALER CONFIRMED THAT THERE WAS A BAD SEAM WELD ON THE FUEL TANK. THE FUEL TANK WAS REPLACED ACCORDING TO THE WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS 7921 AND THE FAILURE MILEAGE WAS APPROXIMATELY 7852. UPDATED 12/22/09
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHILE DRIVING ON INTERSTATE HWY ENGINE LOSS POWER. TRUCK WOULD NOT GO OVER 35 MPG. APPROX THREE MONTHS LATER IT DONE IT AGAIN. ON TWO MORE TIMES IT SHUT OFF ON INTERSTATE . *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .