2012 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2012 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified240.0%
- Engine120.0%
- Powertrain (other)120.0%
- Tires & wheels120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2012 FORD E-450. THE CONTACT STATED THAT THE PASSENGER'S SIDE REAR LUG NUT LOOSENED CAUSING THE WHEEL HUB TO DETACH FROM THE VEHICLE. THE CONTACT STATED THAT THE WRONG TYPE OF WHEEL WAS INSTALLED ON THE VEHICLE. THE CONTACT STATED THAT AN ALUMINUM WHEEL WAS INSTALLED ON THE VEHICLE INSTEAD OF THE REQUIRED STEEL WHEEL. THE CONTACT STATED THAT VEHICLE SPECS CALLED FOR A HUB CENTRIC WHEEL. THE VEHICLE WAS TOWED TO AN RV CENTER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY THE INCORRECT WHEEL BEING INSTALLED ON THE VEHICLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE MANUFACTURER CONFIRMED THAT THE WRONG STYLE WHEEL WAS INSTALLED ON THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 16,600. *LN*JB*DT*JB
TL* THE CONTACT OWNS A 2012 FORD E-450 (N/A). THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE REAR TIRES WERE FLAT. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE FAILURE WAS DUE TO THE WHEEL SIMULATORS SEVERING THE VALVE STEMS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE DRIVING ON THE INTERSTATE THE MOTOR BLOCK BLEW. THERE WAS A LOUD, FAST CLICKING NOISE FOLLOWED BY CLUNKING AND SMOKE FROM UNDER THE VEHICLE. ALL FLUIDS WERE GOOD BUT THERE WAS A FEW DROPS OF OIL ON THE GROUND. THE MECHANIC SAID IT WAS A MANUFACTURE DEFECT THAT HE HAS PREVIOUSLY SEEN. THE VEHICLE WAS MAINTAINED AND THOROUGHLY CHECKED BEFORE THE ROAD TRIP.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WHILE DRIVING ON THE INTERSTATE THE MOTOR BLOCK BLEW. THERE WAS A LOUD, FAST CLICKING NOISE FOLLOWED BY CLUNKING AND SMOKE FROM UNDER THE VEHICLE. ALL FLUIDS WERE GOOD BUT THERE WAS A FEW DROPS OF OIL ON THE GROUND. THE MECHANIC SAID IT WAS A MANUFACTURE DEFECT THAT HE HAS PREVIOUSLY SEEN. THE VEHICLE WAS MAINTAINED AND THOROUGHLY CHECKED BEFORE THE ROAD TRIP.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
The contact owns a 2012 Forest River Sunseeker built on a 2012 Ford E-450 chassis, equipped with Michelin Tires, Tire Line: LTX MS2, Tire Size: LT225/75/R16. The contact stated while driving at an undisclosed speed, there was an abnormal vibration in the front end. The contact became aware that the driver’s side front tire belt was going through the side wall. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who changed another tire. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The tire failure mileage was approximately 13,000. The vehicle failure mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .