2018 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified133.3%
- Steering133.3%
- Suspension133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact owns a 2019 Jayco Redhawk built on a 2018 Ford E-450 chassis. The contact received notification of NHTSA Campaign Number: 21V204000 (Equipment) however, the part to do the recall repair was not yet available. The contact took the RV to the local dealer and it was confirmed that the part was not available. The mechanic disconnected the gas line. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The RV manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The contact owns a 2019 Nexus Viper built on a 2018 Ford E-450 chassis. The contact stated while driving 30 MPH, the steering wheel felt loose, and the vehicle would not drive in a straight line. The contact stated no warning light was illuminated. The contact took the RV to an independent mechanic and was informed that the cam bushing was detached from the RV. The vehicle was not repaired. The manufacturer had been informed of the failure and informed the contact that they would tow the RV to a local dealer. The contact stated that when he contacted the local dealer, he was informed that there was no space to repair the RV at their location. The manufacturer had been informed about the issue and had the RV towed back to the independent mechanic. The vehicle was repaired. The failure mileage was approximately 3,514.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2019 (NA) FORD E-450. WHILE DRIVING APPROXIMATELY 60 MPH, A POPPING SOUND WAS HEARD FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS PULLED OVER AND TOWED TO A TOW YARD. THE FOLLOWING DAY, THE VEHICLE WAS TOWED TO MAGIC CITY FORD LINCOLN (540-345-0911, LOCATED AT 809 WILLIAMSON RD NE, ROANOKE, VA 24016) WHERE IT WAS DIAGNOSED THAT THE FAILURE WAS DUE TO A MANUFACTURER DEFECT. THE TECHNICIAN DIAGNOSED THAT THE FRONT DRIVER'S SIDE WHEEL WAS ABOUT TO DETACH DUE TO THE OUTER WHEEL BEARING FALLING APART. THE TECHNICIAN REPLACED THE BEARINGS, BRAKE PADS, SPINDLE, AND WHEEL HUB. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 5,004.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .