2019 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2019 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure250.0%
- Fuel system125.0%
- Tires & wheels125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2019 Ford E-450. The contact stated that the passenger's side rear door frame detached. The vehicle was taken to an independent mechanic who replaced the door rivets. The manufacturer was not made aware of the failure. The failure mileage was approximately 111,059.
The contact owns a 2019 Ford E-450. The contact stated that the passenger's side rear door frame had detached. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,533. The VIN was invalid.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
When refueling the gas pump clicks off after a few seconds. Sometimes it doesn't click off but back splashes fuel out the gas filler hole. I have had gas spray back several times, getting all over the RV, the ground, and my clothes. Repair places have said there is nothing they can do because it is a design flaw cause the fill tube is too flat. This seems like a huge fire risk to me.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
The contact owns a 2019 Entegra Odyssey RV constructed on a 2019 Ford E450 chassis equipped with Hankook Tires, Tire Line: Dynapro HT, Tire Size: LT225/75/R16, DOT Number: BCXEHUH. The contact stated that upon inflating the tires, his brother was informed that the tires needed to be replaced as they had dry rotted. Additionally, the contact stated that the tires were consistently becoming flat while driving. The Tire dealer and manufacturer were not made aware of the failure. The RV dealer and manufacturer were notified of the failure but provided no assistance. The tires were not replaced. The RV and tire failure mileage was 6,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .