2025 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Powertrain (other)266.7%
- Engine133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
2025 E-450 Safety Recalls* Main control valve body or transmission replacement Recall incomplete INVESTOR REPORTING FOR "amber alert" for all 2025 E-450, as this vin shows NO ACTIVE RECALLS. Yet our factory engineers have issued this RECALL. PLEASE BROADCAST.....
The component that failed was the driveline on our RV. Specifically, the driveline was installed at an incorrect angle, which caused excessive vibrations and loud noises while driving at highway speeds. The improper driveline angle posed a serious safety risk to my family and others on the road. The vibrations were severe enough to affect vehicle handling and stability, especially at higher speeds. There was also concern that the continued stress could lead to mechanical failure or component separation, which could result in loss of control or debris on the roadway. The issue has been confirmed by a Ford RV technician, who verified that the driveline angle was outside manufacturer specifications. The vibrations could be consistently reproduced during test drives. The vehicle has not been inspected by the manufacturer, police, or insurance representatives at this time. There were no warning lamps or dashboard messages, but noticeable symptoms—including a strong vibration through the floor and loud droning noises—began immediately upon first highway use and persisted until inspection revealed the driveline misalignment.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
2025 E-450 Safety Recalls* Main control valve body or transmission replacement Recall incomplete INVESTOR REPORTING FOR "amber alert" for all 2025 E-450, as this vin shows NO ACTIVE RECALLS. Yet our factory engineers have issued this RECALL. PLEASE BROADCAST.....
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .