1989 Ford E350 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1989 Ford E350, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes1240.0%
- Body & structure516.7%
- Engine413.3%
- Fuel system310.0%
- Steering13.3%
- Tires & wheels13.3%
- Transmission13.3%
- Electrical13.3%
- Interior & seats13.3%
- Powertrain (other)13.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
INTERMITTENTLY VEHICLE LOSES BRAKE POWER WHEN THE BRAKE PEDAL IS DEPRESSED, BRAKE PEDAL GOES TO THE FLOOR AND FAILS TO STOP THE TRUCK. THE EMERGENCY BRAKES HAD TO BE ENGAGED TO STOP THE VEHICLE. MASTER BRAKE CYLINDER WAS REPLACED, BUT THE FAILURE OCCURRED WITH IN 400 MILES. DEALERSHIP REPLACED THE MASTER CYLINDER AGAIN, AND BLEED THE BRAKES. HOWEVER, FAILURE RECURRED WITHIN 1500 MILES. THEN, DEALERSHIP INDICATED THAT THIS FAILURE OCCURRED BECAUSE THE BRAKE LINE WAS ROUTED BEHIND THE ENGINE , WHICH GET HOT AND BOILED THE FLUID.*AK
BRAKE CALIPER FAILED TO RELEASE, BOILING THE BRAKE FLUID (UNBEKNOWNST TO ME UNTIL IT CAME TIME TO APPLY THE BRAKES). THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I LET IT UP COMPLETELY AND WHEN DEPRESSED, IT WENT TO THE FLOOR ONCE AGAIN. I USED THE TRANSMISSION (GEARING DOWN) AND THE EMERGENCY BRAKE TO BRING VEHICLE TO A STOP. THE MASTER CYLINDER BRAKE INDICATOR LIGHT NEVER ILLUMINATED. WHEN REPAIRS WERE COMPLETED, THE PRIMARY FAULT WAS IDENTIFIED AS EXTREMELY RUSTY FRONT BRAKE CALIPERS. ONE DID NOT RELEASE COMPLETELY AFTER A BRAKE APPLICATION, CAUSING SUFFICIENT HEAT BUILDUP TO BOIL THE BRAKE FLUID. MECHANIC SAID THE REAR BRAKES WERE BADLY OUT OF ADJUSTMENT, GIVING THE OPINION THAT WAS THE REASON THE MASTER CYLINDER INDICATOR LIGHT DID NOT ILLUMINATE. UNTIL THIS INCIDENT OCCURRED, I DID NOT KNOW THAT IT WAS INCUMBENT ON THE VEHICLE OPERATOR TO OCCASIONALLY MAKE REVERSE MOVES WITH AGGRESSIVE BRAKE APPLICATIONS (DONE SEVERAL TIMES) TO CINCH UP THE REAR BRAKE ADJUSTMENT. THUS, OVER TIME, THE FRONT BRAKES WERE BASICALLY DOING ALMOST ALL THE BRAKING EFFORT. IF I HAD HAD THE PRESENCE OF MIND TO PUMP THE BRAKE PEDAL REPEATEDLY, I PERHAPS COULD HAVE CAUSED THE REAR BRAKES TO ENGAGE, AND BRING THE VEHICLE TO A STOP WITHOUT DOWNGEARING AND USING THE EMERGENCY BRAKE.*AK
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
HAND RAIL FAILED ON BUS NUMBER 142. (NINTH VEHICLE ON 503019) *DSH
HAND RAIL FAILED ON BUS NUMBER 141. (EIGHTH VEHICLE ON 503019) *DSH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE CLIMBING HILLS ON VERY WARM DAYS, THE VEHICLE HAS EXPERIENCED STALLING, ON ONE OCCASION, THE VEHICLE STALLED AND THERE WAS A LOSS OF POWER STEERING AND BRAKES, THE PROBLEM WAS WITH THE TFI IGNITION MODULE AND DISTRIBUTOR. *SLC
CATALYTIC CONVERTER FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1989 FORD E-350. THE CONTACT STATED THAT WHILE EXITING FROM THE WHEEL CHAIR RAMP THAT WAS ATTACHED TO THE VEHICLE IN A WHEEL CHAIR, THE VEHICLE INDEPENDENTLY ROLLED AWAY AND CRASHED INTO A GATE. THE CONTACT WAS NOT INJURED. ADDITIONALLY, THE CONTACT WAS DRIVING 70 MPH AND SMELLED AN ABNORMAL AND PERSISTENT GASOLINE ODOR. THE CONTACT WAS ABLE TO SEE GASOLINE SPEWING FROM THE VEHICLE IN THE REAR-VIEW MIRROR. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INQUIRED WITH THE MANUFACTURER OF NHTSA CAMPAIGN NUMBERS: 90V101000 (POWER TRAIN) AND 91V146000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED IN EITHER RECALL. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE AND DECLINED TO PROVIDE A REMEDY TO REPAIR THE FAILURE. THE CONTACT STATED THAT HE HAD EXPERIENCED BOTH FAILURES. THE FAILURE MILEAGE WAS 103,000.
WHILE DRIVING FUEL WILL SPILL OUT FROM TANK ONTO GROUND, RECALL #93S68. *AK THE CONSUMER'S VEHICLE WAS NOT INCLUDED IN THE RECALL EVENTHOUGH THE PROBLELM IS IDENTICAL TO THAT STATED IN RECALL # 93S68. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
POWER STEERING GEAR BOX SEALS ARE LEAKING, CAUSING STEERING TO BE DIFFICULT. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
BRAKES FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
BRAKE CALIPER FAILED TO RELEASE, BOILING THE BRAKE FLUID (UNBEKNOWNST TO ME UNTIL IT CAME TIME TO APPLY THE BRAKES). THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I LET IT UP COMPLETELY AND WHEN DEPRESSED, IT WENT TO THE FLOOR ONCE AGAIN. I USED THE TRANSMISSION (GEARING DOWN) AND THE EMERGENCY BRAKE TO BRING VEHICLE TO A STOP. THE MASTER CYLINDER BRAKE INDICATOR LIGHT NEVER ILLUMINATED. WHEN REPAIRS WERE COMPLETED, THE PRIMARY FAULT WAS IDENTIFIED AS EXTREMELY RUSTY FRONT BRAKE CALIPERS. ONE DID NOT RELEASE COMPLETELY AFTER A BRAKE APPLICATION, CAUSING SUFFICIENT HEAT BUILDUP TO BOIL THE BRAKE FLUID. MECHANIC SAID THE REAR BRAKES WERE BADLY OUT OF ADJUSTMENT, GIVING THE OPINION THAT WAS THE REASON THE MASTER CYLINDER INDICATOR LIGHT DID NOT ILLUMINATE. UNTIL THIS INCIDENT OCCURRED, I DID NOT KNOW THAT IT WAS INCUMBENT ON THE VEHICLE OPERATOR TO OCCASIONALLY MAKE REVERSE MOVES WITH AGGRESSIVE BRAKE APPLICATIONS (DONE SEVERAL TIMES) TO CINCH UP THE REAR BRAKE ADJUSTMENT. THUS, OVER TIME, THE FRONT BRAKES WERE BASICALLY DOING ALMOST ALL THE BRAKING EFFORT. IF I HAD HAD THE PRESENCE OF MIND TO PUMP THE BRAKE PEDAL REPEATEDLY, I PERHAPS COULD HAVE CAUSED THE REAR BRAKES TO ENGAGE, AND BRING THE VEHICLE TO A STOP WITHOUT DOWNGEARING AND USING THE EMERGENCY BRAKE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHILE CLIMBING HILLS ON VERY WARM DAYS, THE VEHICLE HAS EXPERIENCED STALLING, ON ONE OCCASION, THE VEHICLE STALLED AND THERE WAS A LOSS OF POWER STEERING AND BRAKES, THE PROBLEM WAS WITH THE TFI IGNITION MODULE AND DISTRIBUTOR. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
BRAKES FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
TL* THE CONTACT OWNS A 1989 FORD E-350. THE CONTACT STATED THAT WHILE EXITING FROM THE WHEEL CHAIR RAMP THAT WAS ATTACHED TO THE VEHICLE IN A WHEEL CHAIR, THE VEHICLE INDEPENDENTLY ROLLED AWAY AND CRASHED INTO A GATE. THE CONTACT WAS NOT INJURED. ADDITIONALLY, THE CONTACT WAS DRIVING 70 MPH AND SMELLED AN ABNORMAL AND PERSISTENT GASOLINE ODOR. THE CONTACT WAS ABLE TO SEE GASOLINE SPEWING FROM THE VEHICLE IN THE REAR-VIEW MIRROR. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INQUIRED WITH THE MANUFACTURER OF NHTSA CAMPAIGN NUMBERS: 90V101000 (POWER TRAIN) AND 91V146000 (FUEL SYSTEM, GASOLINE) HOWEVER, THE VIN WAS NOT INCLUDED IN EITHER RECALL. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE AND DECLINED TO PROVIDE A REMEDY TO REPAIR THE FAILURE. THE CONTACT STATED THAT HE HAD EXPERIENCED BOTH FAILURES. THE FAILURE MILEAGE WAS 103,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .