Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 1999 Ford E350 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 9 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
THE VEHICLE STALLS ON NUMEROUS OCCASIONS DUE TO LACK OF FUEL. INVESTIGATION PROVED THAT THE INTERIOR PAINT OF THE GAS TANK PEALS BLOCKING THE FUEL PUMP. RESEARCH SHOWS THAT DELAMINATION OF THE GAS TANK IS FREQUENT IN THIS MODEL CAUSING A VERY UNSAFE CONDITION AS THE VAN CAN STOP AT ANYTIME AS IT LOOSES POWER AND PROPULSION DUE TO THE PAINT FLAKES BLOCKING THE FUEL. *TR
TL* THE CONTACT OWNS A 1999 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE CONTACT NOTICED THAT THE FUEL TANK WAS DANGLING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL TANK SUPPORT STRAPS WERE RUSTED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
TL* THE CONTACT OWNS A 1999 FORD E350 VAN. THE CONTACT STATED THAT THE DIESEL FUEL TANK DEVELOPED CORROSION. THE CORROSION HAD FILTERED INTO THE ENGINE AND CAUSED THE ENGINE TO STALL WHILE THE CONTACT WAS DRIVING 65 MPH. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO ADVISED THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE REPLACED DUE TO THE CORROSION. THE CONTACT HAD THE FUEL TANK AND FUEL INJECTORS CLEANED PREVIOUSLY BUT THE CLEANING DID NOT REMEDY THE ISSUE. THE FAILURE MILEAGE WAS 285,000. THE VIN WAS NOT AVAILABLE.
RECALL 01V114000: POSSIBLE FUEL TANK CRACK. I TOOK MY VAN IN FOR BRAKE WORK. IT WAS DISCOVERED THAT THERE IS A FUEL TANK CRACK. I RECEIVED A RECALL REPORT FROM MY MECHANIC FROM ALLDATE ONLINE STATING THAT THIS IS AN ISSUE THAT HAPPENS TO MY TYPE OF VEHICLE. IT IS A VAN THAT I USE FOR WORK.*CW
MY E- 350 SUPER DUTY , 1999 BURN UP FOR NO APPARENT REASON. *JB
THE DIESEL FUEL TANK HAD RUSTED, AS A RESULT THE FUEL LINE CLOGGED. THE DEALER REPLACED THE FUEL TANK AND WITHIN ONE YEAR LATER THE TANK RUSTED OUT AGAIN. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB
DIESEL FUEL TANK FILLER NECK FAILURE. WHEN FILLING WITH FUEL FILLER NECK LEAKS FUEL. THIS WAS INITIALLY DIAGNOSED IN 2000. FILLER NECK REPLACED. SEPTEMBER 2001 TANK MOUNTS REPLACED IN RECALL. THIS IS THE SECOND FAILURE OF THE FUEL TANK FILLER NECK. FORD REFUSES TO MAKE REPAIRS UNDER WARRANTY.
FUEL TANK DEVELOPED CRACKS AT BOTTOM AND CAUSING FUEL LEAKAGES. DEALER NOTIFIED, AND DONE REPAIRS AT 30% OFF. *AK THE COMPANY OPERATES FLEET OF 52 VEHICLES. ELEVEN OF THESE VEHICLES DEVELOPED FUEL TANK CRACS AT LOW MILEAGE. *YH
BUILDING EXCESSIVE FUEL PRESSURE CAUSING THE SEAL FOR THE FUEL FILTER HOUSING TO FAIL, THIS CAUSING LARGE QUANTITIES OF FUEL TO SPRAY OVER THE ENGINE AND EXHAUST.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .