1989 Ford Econoline Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1989 Ford Econoline, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system718.4%
- Brakes615.8%
- Engine513.2%
- Electrical410.5%
- Transmission37.9%
- Driver assistance37.9%
- Heating & air conditioning37.9%
- Interior & seats25.3%
- Tires & wheels25.3%
- Visibility12.6%
- Other / unspecified12.6%
- Seat belts12.6%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
CONSUMER SMELLED GASOLINE. STARTED TO OPEN GAS CAP, AND GASOLINE STARTED GUSHING OUT. SINCE THEN GASOLINE MILEAGE HAS GONE DOWN. *AK *SLC
WHEN CONSUMER FILLS UP GAS TANK GASOLINE COMES OUT THROUGH THE FILLER CAP AND FALLS ONTO THE GROUND. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WHEN FIRST STARTING VEHICLE DEFECT WITHIN IGNITION SWITCH WILL CAUSE ENTIRE ELECTRICAL SYSTEM TO BECOME INOPERATIVE. THIS IS INTERMITTENT PROBLEM. *AK SOMETIMES VEHICLE WILL NOT SHIFT INTO OVERDRIVE OR WILL NOT WANT TO SHIFT OUT OF FIRST GEAR. AIR CONDITONER FAILED. POWER WINDOW MALFUNCTIONS. BRAKE LIGHT INOPERABLE. CRUISE CONTROL MALFUNCTIONS. *YH
BRAKE FLUID OVERHEATED, CAUSING THE BRAKES TO FAIL.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
CATALYTIC CONVERTER FAILED 3 OUT OF 4 TIMES. THREE OF THE FOUR TIMES THAT THIS PROBLEM HAS ACCURRED FORD HAS TAKEN REPLACE THE PART MOSTLY FREE OF CHARGE. THIS TIME IN 2001 FORD WILL NOT FIX THE PROBLEM AND TELLS US TO BAD. WE FILL THAT BEING A REPEATED PROBLEM FORD MOTOR COMPANY SHOULD IN GOOD FAITH TAKE CARE OF THIS PROBLEM COMPLETELY ONCE AND FOR ALL. WE WOULD LIKE TO BE REIMBURSED FOR OUR REPAIR COST. WE DID HAVE THIS PROBLEM FIXED AT OUR EXPENSE. WHEN WE WENT TO PICK UP OUR RV WILSON CORNELIUS FORD OF VALLEJO CA WHEN ASKED IF WE WOULD HAVE CONTINUIUS PROBLEMS TOLD US NOT TO USE THE GAS WHEN GONG UP HILL. THE ALSO CHARGED US FOR A REPAIR AND PERTS THAT WERE NOT COMPLETE AND REFUSED TO REFUND US THAT AMOUNT. WE HAVE HAD MORE THEN ENOUGH PROBLEM WITH FORD OUR RV AND THE SERVICE TECH NOT DOING THE REPAIRS PROPERLY. PLEASE HELP US..... ANY QUESTIONS PLEASE CALL. *AK
THE VEHICLE STALLS SUDDENLY AND UNEXPECTEDLY WHILE DRIVING IN HOT WEATHER, THE DEALER HAS REPLACED MANY CONPONENTS (AIR AND FUEL FILTER, TFI MODULE, VAPOR SEPARATOR AND CATALYTIC CONVERTER)BUT THE VEHICLE CONTINUES TO STALL. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
VAN CAUGHT FIRE AND WAS DESTROYED AFTER BEING PARKED TWO HOURS. FIRE INVESTIGATORS DETERMINED CAUSE WAS AN ELECTRICAL DEFECT IN ENGINE COMPARTMENT ON DRIVER'S SIDE. FIRE DAMAGED ADJACENT HOUSE AND NEARBY VEHICLE.*AK
WHEN FIRST STARTING VEHICLE DEFECT WITHIN IGNITION SWITCH WILL CAUSE ENTIRE ELECTRICAL SYSTEM TO BECOME INOPERATIVE. THIS IS INTERMITTENT PROBLEM. *AK SOMETIMES VEHICLE WILL NOT SHIFT INTO OVERDRIVE OR WILL NOT WANT TO SHIFT OUT OF FIRST GEAR. AIR CONDITONER FAILED. POWER WINDOW MALFUNCTIONS. BRAKE LIGHT INOPERABLE. CRUISE CONTROL MALFUNCTIONS. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS ENGAGED IN PARK, BUT THE VEHICLE STILL ROLLS AS IF NOT COMPLETELY IN GEAR. DLR HAS SEEN 4 TIMES, AND CANT FIND THE CAUSE. *AK
WHEN FIRST STARTING VEHICLE DEFECT WITHIN IGNITION SWITCH WILL CAUSE ENTIRE ELECTRICAL SYSTEM TO BECOME INOPERATIVE. THIS IS INTERMITTENT PROBLEM. *AK SOMETIMES VEHICLE WILL NOT SHIFT INTO OVERDRIVE OR WILL NOT WANT TO SHIFT OUT OF FIRST GEAR. AIR CONDITONER FAILED. POWER WINDOW MALFUNCTIONS. BRAKE LIGHT INOPERABLE. CRUISE CONTROL MALFUNCTIONS. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
DIFFCULTY SLOWING DOWN FROM HIGHWAY SPEED, HAD TO TURN OFF IGNITION TO STOP VEHICLE. DISCONNECTED CRUISE CONTROL, BUT THIS WAS NOT THE PROBLEM. DEALERSHIP SERVICE SAYS IT WAS THE ACCELEROMETER CABLE. DT
WHEN FIRST STARTING VEHICLE DEFECT WITHIN IGNITION SWITCH WILL CAUSE ENTIRE ELECTRICAL SYSTEM TO BECOME INOPERATIVE. THIS IS INTERMITTENT PROBLEM. *AK SOMETIMES VEHICLE WILL NOT SHIFT INTO OVERDRIVE OR WILL NOT WANT TO SHIFT OUT OF FIRST GEAR. AIR CONDITONER FAILED. POWER WINDOW MALFUNCTIONS. BRAKE LIGHT INOPERABLE. CRUISE CONTROL MALFUNCTIONS. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
THE AIR CONDITIONER COMPRESSOR WAS LEAKING FREEON. THIS WOULD CAUSE THE AIR CONDITIONER TO NOT COOL VEHICLE ONCE TURNED ON. HAS HAPPENED BEFORE, 2 YEARS AGO. WILL BE TAKING TO DEALER TO CHECK. *AK
I HAVE HEARD OF MANY COMPLAINTS ABOUT THE AIR CONDITIONER OF SUCH FORD VANS THAT THEY LEAK FREON.EVEN FROM A/C REPAIR SHOP THEY SAID THAT IT WAS VERY COMMON WITH FORD REGARDING THIS LEAK. I THINK FORD SHOULD FIX THIS TO SAVE OUR OZONE LAYER FROM FREON LEAK. I WISH FORD WOULD FIX MY A/C. THANKS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
SEAT TRACK FAILURE, SEAT BECAME DISLODGED FROM THE SEAT TRACKS AND THE SEAT TRACKS WERE DEFORMED AS A RESULT OF AN IMPACT WITH ANOTHER VEHICLE. (PLUM POLICE REPORT)
SEAT BACK BOLTS TOO LONG, PIERCING GAS TANK, CAUSING GAS TO LEAK INTO PASSENGER COMPARTMENT. *AW
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
FULLY TREADED TIRE THAT HAD BEEN MOUNTED AS A SPARE TIRE WAS USED AND LASTED FOR 2 WEEKS BEFORE THE TREAD COMPLETELY SEPARATED AT 55 MPH. TREAD DEPARTED TIRE CARCASS IN ONE PEICE, DAMAGING SEVERAL COMPONENTS IN THE LEFT REAR QUARTER OF MY VEHICLE. MY WIFE WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE OTHERWISE. I HAVE CONTACTED CONTINENTAL GENERAL TIRE. *AK (TIRESIZE: P235/75R15)
VEHICLE SPARE TIRE MOUNTED ON REAR DOOR FELL OFF DUE TO DEFECTIVE ALLUMINUN. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WHEN FIRST STARTING VEHICLE DEFECT WITHIN IGNITION SWITCH WILL CAUSE ENTIRE ELECTRICAL SYSTEM TO BECOME INOPERATIVE. THIS IS INTERMITTENT PROBLEM. *AK SOMETIMES VEHICLE WILL NOT SHIFT INTO OVERDRIVE OR WILL NOT WANT TO SHIFT OUT OF FIRST GEAR. AIR CONDITONER FAILED. POWER WINDOW MALFUNCTIONS. BRAKE LIGHT INOPERABLE. CRUISE CONTROL MALFUNCTIONS. *YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
WHILE DRIVING THE FRONT RIGHT WHEEL CAME OFF DUE TO BROKEN LUG NUTS. PLEASE DESCRIBE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
OWNER STATES THAT THE SEAT BELTS IN THE CAPTAIN'S CHAIR DO NOT HOLD KIDS IN PLACE, THEY ARE ABLE TO GET OUT OF THEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .