2001 Ford Econoline Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Ford Econoline, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance930.0%
- Engine723.3%
- Tires & wheels310.0%
- Fuel system310.0%
- Transmission26.7%
- Suspension26.7%
- Steering13.3%
- Interior & seats13.3%
- Other / unspecified13.3%
- Powertrain (other)13.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
2001 FORD ECONOLINE TRUCK CRUISE CONTROL STOPPED WORKING AFTER THE BRAKE SWITCH RECALL WAS REPAIRED. *NJ THE CONSUMER STATED THERE WAS A RUMBLING/GRINDING NOISE COMING FROM THE VEHICLE. THE DEALER VERIFIED THE NOISE COMING FROM THE FRONT OF THE VEHICLE. THE WHEEL BEARING WAS LOOSE. *JB
I HAVE A 2001 FORD ECONOLINE WAGON VAN THAT WAS RECALLED ABOUT JUNE OF 2007 BECAUSE OF A DEFECT WITH THE CRUISE CONTROL. WHEN I TOOK IT TO THE FORD DEALERSHIP IN AMERICUS, GEORGIA, THEY SAID THEY DIDN'T HAVE ANY PARTS TO REPAIR THE CRUISE CONTROL. THAT IT WAS ON BACK ORDER. IT HAS BEEN ALMOST 1 YEAR AND STILL THEY HAVE NOT OFFERED TO REPAIR THE CRUISE CONTROL THEIR REASON IS THEY DON'T HAVE ANY PARTS. *TR
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
SPARKPLUG BLOWOUT
NUMBER 7 CYLINDER BLEW THE SPARK PLUG OUT. TOTAL LOSS OF POWER. FORTUNATELY TRAFFIC WAS LIGHT AND I WAS ABLE TO PULL INTO A PARKING LOT. ABSOLUTELY NO WARNING SIGNS AT ALL. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
NAR 02/10/2003. OHIO POLICE REPORT. TIRE BLEW OUT. VEHICLE SKIDDED OFF THE ROAD STRUCK A GUARDRAIL. THE REAR TIRE AND RIM WAS MISSING AND THE STUDS HAD BROKE OFF. TIRE BRAND, SIZE AND DOT # UNKNOWN. *TT *JB
TIRE WAS OUTER ON DUAL REAR WHEELS - THE INSIDE OF THIS TIRE BLEW OUT COMPLETELY. FORTUNATELY I WAS ABLE TO CONTROL TRUCK AND QUICKLY ACCESS THE SHOULDER, BUT IN HEAVY EVENING TRAFFIC. *AK (TIRESIZE: LT225/75RX)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
BUCKING, SHAKING, LOSS OF POWER. TIRES FELT OUT OF ALIGNMENT. STALLING AND ROUGH IDLE. LINING IN THE FUEL TANK PEELS OFF AND THE MATERIAL FROM THE LINING IS CLOGGING THE FUEL PUMP. THIS AFFECTS TRUCKS, VANS FROM THE YEARS 2000 UP. THIS HAPPENED AT HIGHWAY SPEEDS ON AN INTERSTATE HIGHWAY. THERE WAS .MUCH TRAFFIC TO BE NEGOTIATED UNTIL I FINALLY MADE IT TO THE SHOULDER OF THE ROAD.
TL* THE CONTACT OWNS A 2001 FORD ECONOLINE. WHILE DRIVING AT DIFFERENT SPEEDS, THE CONTACT NOTICED THAT THE VEHICLE WOULD LOSE POWER AND RESIST ACCELERATION. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE EXACT FAILURE. THE FUEL FILLER WAS REPLACED APPROXIMATELY TEN TIMES. THE FUEL INJECTORS WERE REPLACED TWICE. THE INDEPENDENT MECHANIC STATED THAT THE FUEL TANK WOULD HAVE TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
CONSUMER COMPLAINED ABOUT A TRANSMISSION PROBLEM. TRANSMISSION FAILED PREMATURELY. ALSO, CLUTCH MALFUNCTIONED. *AK
CONSUMER NOTICED WHILE TRAVELING 60 MPH VEHICLE DOWN SHIFTED VEHICLE WAS SERVICED, TECHNICIAN NOTICED THAT TRANSMISSION NEEDED TO BE REPLACED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
2001 FORD ECONOLINE TRUCK CRUISE CONTROL STOPPED WORKING AFTER THE BRAKE SWITCH RECALL WAS REPAIRED. *NJ THE CONSUMER STATED THERE WAS A RUMBLING/GRINDING NOISE COMING FROM THE VEHICLE. THE DEALER VERIFIED THE NOISE COMING FROM THE FRONT OF THE VEHICLE. THE WHEEL BEARING WAS LOOSE. *JB
REAR COIL SPRINGS ARE COMPRESSED TOO CLOSE TO VEHICLE. WHEN VEHICLE IS BEING DRIVEN IT IS HIGH ENOUGH FOR CONSUMER TO RETRO FIT VEHICLE FOR HANDICAP USE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
THERE IS A SMALL PLATE THAT HAS 2 ALLEN HEAD BOLTS HOLDING IT ON THE BOTTOM OF THE STEERING COLUMN SHAFT .THIS PLATE PUTS THE VEHICLE IN PARK. THE BOLTS CAME LOOSE AND THE VAN ROLLED BACKWARDS INTO THE GARAGE DOOR EVEN THOUGH IT WAS IN PARK AND THE DRIVER WAS STANDING OUTSIDE,NEXT TO THE VAN
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
WHILE VEHICLE WAS PARKED IN DRIVEWAY AND WITHOUT ANY INDICATION VEHICLE CAUGHT ON FIRE AROUND RADIO AREA, AND SPREAD TO ROOF/ BACK OF VEHICLE. FIRE DEPARTMENT WAS CALLED, AND PUT OUT FIRE. PLEASE PROVIDE FURTHER INFORMATION.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
CONSUMER WAS INVOLVED IN A FRONTAL COLLISION WITH AN ELECTRICAL POLE AND THE RIGHT FRONT WHELL CAME COMPLETELY OFF. CONSUMER STATED THE ENTIRE WHEEL ASSEMBLY CRACKED. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
THERE IS A SMALL PLATE THAT HAS 2 ALLEN HEAD BOLTS HOLDING IT ON THE BOTTOM OF THE STEERING COLUMN SHAFT .THIS PLATE PUTS THE VEHICLE IN PARK. THE BOLTS CAME LOOSE AND THE VAN ROLLED BACKWARDS INTO THE GARAGE DOOR EVEN THOUGH IT WAS IN PARK AND THE DRIVER WAS STANDING OUTSIDE,NEXT TO THE VAN
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .