2005 Ford Escape Hybrid Brakes Problems

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 35 MPH, THE BRAKES FAILED. THE CONTACT HAD TO ENGAGE THE PARKING BRAKE TO STOP THE VEHICLE. ALSO, THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO JERRY'S FORD ALEXANDRIA (6510 LITTLE RIVER TURNPIKE, ALEXANDRIA, VA 22312, (703) 256-5000), BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 116,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

11217159

Incident

May 27, 2019

Mileage

116,000 mi

WHILE COMING UP TO A STOP SIGN THE BRAKES STOPPED WORKING. LUCKILY THERE WERE NO CARS IN FRONT OF ME AS THE CAR CONTINUED TO ROLL PASS THE STOP SIGN. FLOORING THE BRAKES CAUSED THE CAR TO SLOW DOWN SLOWLY. I ENDED UP PULLING OVER IMMEDIATELY, TURNING OFF THE VEHICLE AND INSPECTING THE VEHICLE. I SAW NO CLEAR INDICATION OF ANYTHING BEING WRONG. WHEN I TURNED BACK ON THE VEHICLE EVERYTHING WAS FINE, UNTIL THE SAME THING HAPPENED THE NEXT DAY. I TOOK THE CAR TO A FEW CAR SHOPS BUT NO ONE COULD FIND ANYTHING WRONG WITH IT. THE CAR WAS EVEN TAKEN FOR A TEST DRIVE BY THE MECHANIC BUT PERFORMED WITH NO PROBLEMS. ONE OF THE SHOPS RECOMMENDED I REPLACE THE MASTER CYLINDER OR THE HYDRAULIC CONTROL UNIT BUT COULD NOT GUARANTEE THE PROBLEM WOULD NEVER OCCUR AGAIN. I DON'T FEEL COMFORTABLE PAYING SO MUCH FOR A NON GUARANTEED JOB SO UNFORTUNATELY I AM STILL DRIVING THE VEHICLE AND THE BRAKES CONTINUES TO STOP WORKING AT RANDOM TIMES.

NHTSA ID

11172703

Incident

Jan 26, 2019

THE ABS CONTROL MODULE. NOTICED MANY COMPLAINTS. HAD 1700 DOLLARS OF WORK TO FIX THE ISSUE AND THE BRAKES WENT OUT ON ME YESTERDAY. THREE WEEKS AFTER THE WORK. THE ABS AND BRAKE LIGHT CAME ON AGAIN AND THE BRAKES FAILED ON HWY 19 FL. PULLED OVER ,TURNED THE CAR OFF LIKE WHAT I READ ONLINE ABOUT THIS TYPE A VEHICLE, STARTED UP AND THE BRAKES WERE BACK' TOOK IT HOME AND PARKED IT. WHEN IS FORD GOING TO PUT A RECALL ON THIS, WHEN SOMEONE DIES.OF COURSE HAD I KNOWN ABOUT THIS DEFECT I WOULD HAVE NEVER PURCHASED IT. I HAVE ONLY HAD IT FOR A LITTLE OVER A MONTH AND IT HAS LOW MILEAGE..

NHTSA ID

11164718

Incident

Jan 2, 2019

Mileage

45 mi

ABS LIGHT IS ON CONSTANTLY MY BRAKES ARENT WORKING PROPERLY TIMES WHEN IT DIDNT STOP HAD TO SHIFT INTO LOW GEAR AND PULL OFF TO SAFE SPIOT I WAS TRYING TO STOP

NHTSA ID

11153242

Incident

Nov 20, 2018

Mileage

122,000 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 30 MPH, THE "PULL OVER SAFELY NOW" WARNING INDICATOR ILLUMINATED AND THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT STATED THAT THE BRAKING SYSTEM FAILED TO OPERATE AS INTENDED. THE CRASH OCCURRED WHILE THE CONTACT WAS EN ROUTE TO COCCIA FORD LINCOLN INC (LOCATED AT 577 E MAIN ST, WILKES-BARRE, PA 18702, (570) 823-8888) TO HAVE THE VEHICLE REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ISSUED CASE NUMBER: CAS-14733790. THE APPROXIMATE FAILURE MILEAGE WAS 174,109.

NHTSA ID

11129880

Incident

May 3, 2018

Mileage

174,109 mi

ABS AND BRAKE LIGHT ILLUMINATE (WITH SERVICE BRAKE SYSTEM DISPLAYED) AND BRAKE PEDAL GOES ALL THE WAY TO THE FLOOR. BRAKES FAIL TO MANUAL BRAKES ONLY, VERY SENSITIVE AND WILL LOCK THE WHEELS UP; TOUCHY WITH NO REAL FEED BACK, JUST APPLIED OR OFF WITH SIGNIFICANT PRESSURE REQUIRED. HAPPENED WHEN PULLING INTO A GAS STATION AND NEARLY WENT PAST THE PUMP, BUT SKIDDED TO A STOP INSTEAD. SYSTEM RESETS WITH EACH KEY CYCLE ON/OFF. IT IS SOMEWHAT INTERMITTENT. WHILE WAITING FOR MY FORD APPOINTMENT (CAVALIER FORD IN CHESAPEAKE, VA), I DUPLICATED THE EVENT SEVERAL TIMES UNDER A CONTROLLED, OPEN PARKING LOT TEST AND DRIVE TO THE DEALERSHIP. DEALERSHIP RAN DIAGNOSTICS, AND COULD NOT DUPLICATE. THE RECOMMEND REPLACING BRAKE LINES, THEN MASTER CYLINDER, THEN HCU. REPAIRS IN ORDER ARE $615, $1400, AND OVER $4900. DIAGNOSTICS RAN $130...WITH NO DEFINITIVE ANSWER TO MY PROBLEM.

NHTSA ID

11063598

Incident

Jan 14, 2018

Mileage

160,000 mi

SHOCK TOWER ON BACK PASSENGER SIDE RUSTING OUT. LEARNED OF THIS FROM DEALERSHIP 2 WEEKS AGO.

NHTSA ID

11034305

Incident

Oct 5, 2017

Mileage

185,000 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER (TOMMIE VAUGHN FORD, 1201 N SHEPHERD DR, HOUSTON, TX 77008, (713) 869-4661) SEVERAL TIMES AND THEY WERE UNABLE TO PROVIDE A SOLUTION. THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND A MULTI-POINT INSPECTION WAS PERFORMED. THE DEALER DETERMINED THAT THE BRAKE MASTER CYLINDER AND THE HCU NEEDED TO BE REPLACED. THE MANUFACTURER HAD EIGHT TSBS FOR THE SERVICE BRAKES, HYDRAULICS AND ONE FOR THE SERVICE BRAKES, AIR. THERE WAS NO RECALL CAMPAIGN. THE VEHICLE WAS STILL AT THE DEALER TO BE SERVICED WITH NO SOLUTION OTHER THAN REPLACING THE PARTS. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

11031925

Incident

Feb 1, 2010

BRAKE LIGHT BEEPS AND THE BRAKES SUDDENLY GO OUT SO THAT YOU CAN BARELY STOP THE CAR.

NHTSA ID

10994608

Incident

Jun 7, 2017

Mileage

96,000 mi

WHILE DRIVING DOWN THE ROAD, I HEAR AN ALARM FOR "SERVICE BRAKE SYSTEM", AND LOSE ALL POWER TO MY BRAKES. PEDAL IS DEPRESSED TO THE FLOOR WITH MINIMAL ABILITY TO STOP.

NHTSA ID

10983132

Incident

May 2, 2017

Mileage

137,000 mi

WHEN BRAKE PEDAL IS APPLIED WITH CONSTANT PRESSURE, BRAKES WOULD ENGAGE THEN FAIL TO ENGAGE FOR SHORT SECONDS, THEN ENGAGE AGAIN, SYMPTOMS ARE INTERMITTENT. SOME TIMES IT WOULD TRIGGER A BRAKE RELATED DTC. TECHNICIAN DETERMINED IT WAS A FAILED HYDRAULIC CONTROL UNIT IN THE BRAKE SYSTEM AND WAS TOLD IT WAS COMMON AND OCCURRED ON A NUMBER OF THE SAME MODEL VEHICLES FROM 2005 TO 2012.

NHTSA ID

10969937

Incident

Mar 1, 2017

Mileage

130,000 mi

THE BRAKES ARE HARD, RUNS ALL THE WAY TO STOP THIS HARD .EL WHEEL CAN NOT TURN EASILY TO THE SIDES. IT GIVES ME THE CODE U0418, U0413. IS IS NOT DUE TO WEAR IS A MANUFACTURER FAILS

NHTSA ID

10894271

Incident

Jun 25, 2016

Mileage

40 mi

BRAKES GO STIFF AT RANDOM TIMES WHILE DRIVING FOR NO PRESENTED REASON AND CAUSE A SHOCK TO DRIVER AND HAVE TO LET GO OF BRAKES THEN PRESS DOWN TO SEE IF THEY WILL WORK. HAPPENS IN MOST IF NOT ALL KIDS OF CONDITIONS, NOT JUST ONE SPECIFIC KIND OF SITUATION. HAS HAPPENED AT LEAST 10 TIMES IN THE PAST 6 MONTHS.

NHTSA ID

10883540

Incident

Jul 7, 2016

Mileage

130,000 mi

INTERMITTENT LOSS OF BRAKING OVER THE PAST 12 MONTHS, WITH THE 3RD OCCURRENCE RESULTING IN A COLLISION ON JUNE 28, 2016 ON A CITY STREET. VEHICLE HAS HAD INTERMITTENT BRAKE AND ABS WARNING LIGHTS WITH NO DIAGNOSTIC CODES, AND WARNING LIGHTS EVENTUALLY RESET WITH NO ADDITIONAL ACTION TAKEN. BRAKE SYSTEM HAS BEEN SERVICED SEVERAL TIMES WITHOUT RESOLUTION.

NHTSA ID

10881510

Incident

Jun 28, 2016

Mileage

181,000 mi

BOTH FRONT BRAKE CALIPER FLEXIBLE BRAKE LINES FAILED AT THE SAME TIME. I WAS FORTUNATE THAT I WAS AT LOW SPEED, HOOKING UP MY TRAILER AT THE TIME. NO ACCIDENT OCCURRED. THE BRAKE FLUID DUMPED ON THE INSIDE OF BOTH FRONT TIRES.

NHTSA ID

10872949

Incident

May 28, 2016

Mileage

130,000 mi

IN NORMAL DRIVING, WITH NO WARNING, "BRAKE" AND "ABS" WARNING LIGHTS ILLUMINATE ALONG WITH "SERVICE BRAKE SYSTEM" DISPLAY. CONSIDERABLE EFFORT IS REQUIRED TO SLOW THE VEHICLE AND STOPPING DISTANCE IS 2-3 TIMES NORMAL. I ENDED UP IN A DITCH BECAUSE I COULD NOT STOP IN TIME.

NHTSA ID

10872499

Incident

Jun 4, 2016

Mileage

139,352 mi

BRAKE ABS BRAKE LIGHT ON AND BRAKES DO WORK RIGHT, I TOOK IT TO A DEALER AND THEY SAID SOME KIND OF PUMP IS BAD AND IT COST $5000 TO FIT IT. LOTS OF PEOPLE HAVING THE SAME PROBLEM. I THINK FORD SHOULD RECALL THOSE CARS FOR SAFETY. I DON'T THINK NO BRAKES SHOULD COST $5000 TO FIT. I M SCARE TO DRIVE IT.

NHTSA ID

10862104

Incident

Jan 2, 2015

COMPUTER CONTROLLING THE BRAKES MALFUNCTION. I WAS ON A STATE HYWAY WHEN THE DASH LIGHT CAME ON TO WARN OF BRAKE FAILURE, AND A COUPLE OF SECONDS LATER I HAD NO BRAKES. I TURNED THE MOTOR OFF AND BACK ON, AND I HAD BRAKES. THIS HAPPENED OFF AND ON UNTIL I WAS ON LADSON ROAD GOING TO A FRIENDS HOUSE AND THE BRAKES WOULD NOT WORK AND I HAD TO CALL A TOW TRUCK AND BE TOWED HOME. THIS SCARES ME AND I WILL NOT DRIVE THE CAR UNTIL IT IS FIXED. FORD SAYS IT WILL COST 5000.00 TO FIX IT. I HAVE TO GET MY SON TO CARRY EVERYWHERE. I AM 82 YEARS OLD AND NEED MY CAR !!!!....UPDATED 06/15/16 *BF

NHTSA ID

10852751

Incident

Jan 15, 2016

Mileage

63,000 mi

ON LADSON, SC ROAD MY BRAKE LIGHT WARNING CAME ON AND I HAD NO BRAKES. THIS HAPPENED THREE TIMES BEFORE, BUT I PULLED OFF THE ROAD AND TURNED THE ENGINE OFF THEN TURNED BACK ON AND BRAKES WORKED. THIS TIME ON LADSON ROAD, I COULD NOT GET THE BRAKES TO WORK, AND I HAD TO CALL A TOW TRUCK TO TAKE THE CAR HOME. I CANNOT DRIVE THE CAR, AND FEEL STRANDED AT HOME. I AM AN 82 YEAR OLD WIDOW. I HAVE TO GET MY SON TO TAKE ME WHERE I NEED TO GO. HE HAS TO GET OFF WORK TO DO THIS. I NEED MY CAR. PLEASE HELP. ACCORDING TO THE FORD COMPANY IT COSTS $5000.00 TO FIX. I DO NOT HAVE $5000.00. I LIVE ON A FIXED INCOME.

NHTSA ID

10818699

Incident

Dec 29, 2015

Mileage

62,987 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE PEDAL WAS APPLIED AND DID NOT RESPOND. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) AND WAS UNABLE TO DETERMINE WHEN THE REMEDY AND PART WOULD BECOME AVAILABLE TO COMPLETE THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 172,912. UPDATED 11/19/15*LJ

NHTSA ID

10763515

Incident

Sep 1, 2015

Mileage

172,912 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING AT ANY SPEED, THE CONTACT WOULD EXPERIENCE A SPORADIC LOSS OF BRAKE CONTROL. THE ABS AND THE BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE MASTER CYLINDER FAILED. THE VEHICLE WAS REPAIRED HOWEVER THE WARNING LIGHTS CONTINUED TO ILLUMINATED . THE MECHANIC THEN STATED THE HYDRAULIC CONTROL UNIT WOULD ALSO HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 200,000.

NHTSA ID

10715330

Incident

Apr 24, 2015

Mileage

200,000 mi

FIRST, SPORADIC LOSS OF BRAKE CONTROL; VERY BRIEF; THEN, ABS AND BRAKES LIGHTS CAME ON. DASH SAID "SERVICE BRAKE SYSTEM." BROUGHT IT TO LOCAL DEALER, WHO SAID IT NEEDS A NEW MASTER CYLINDER & HCU. *TR

NHTSA ID

10701986

Incident

Mar 26, 2015

Mileage

199,231 mi

DRIVING DOWN THE HIGHWAY WITH MY FAMILY, A CAR SWERVED INTO OUR LANE CUTTING US OFF. WE HIT THE BRAKES, THE ABS AND BRAKE LIGHT CAME ON AND THE BRAKES ONLY WORKED WHEN WE SLAMMED ON THEM! HAD TO HAVE THE CAR TOWED AS IT WAS NOT DRIVABLE. MECHANIC SAID IT NEEDED A NEW ABS CONTROL MODULE. ORDERED THAT PART TWICE. TOOK CAR TO CAR COMPUTER SPECIALIST - SAID CAR WAS COULD NOT BE REPROGRAMMED. BILL IS NOW OVER $2,000 AND IT HAS BEEN OVER 2 WEEKS. MECHANIC CALLED FORD (LOTS OF COMPLAINTS ONLINE ABOUT THIS ISSUE). THEY SAID THEY COULD TRY TO REPROGRAM IT, BUT IT COULD TAKE UP TO 10 HOURS AND MAY NOT WORK. FORD SAID THE LAST PROBLEM THEY SAW LIKE THIS DIDN'T WORK AND THE OWNER HAD TO TRADE IN FOR A NEW CAR! NOT ONLY COULD THIS INCIDENT HAVE SERIOUSLY HARMED MY FAMILY, BUT NOW I'M OUT OF A CAR AND $2,000!

NHTSA ID

10690921

Incident

Feb 4, 2015

Mileage

86,000 mi

I WAS STOPPED AT A DRIVE THRU LINE MY CAR MADE A NOISE I DON'T KNOW HOW TO DESCRIBE ACCURATELY WITH WORDS. I LOOKED DOWN AND MY ABS AND BRAKE LIGHT WERE ON AND THE BRAKE SERVICE NEEDED WAS ON THE DASH DISPLAY. I PUT THE CAR IN PARK AND TURNED THE CAR OFF THEN ON. ALL THE SAME WARNINGS WERE STILL THERE. I PULLED FORWARD SLOWLY AND WHEN BRAKING I STILL DIDN'T STOP IN A REASONABLE TIME AND ALMOST COMPLETELY MISSED THE DRIVE THRU WINDOW. NEEDLESS TO SAY A DRIVE HOME AT 10-15MPH STILL FELT LIKE I WAS IN DANGER OF HITTING SOMEONE BECAUSE I COULD NOT JUDGE STOPPING DISTANCE EVEN WITH MY FOOT APPLYING FULL PRESSURE ON THE BRAKES. FROM ALL THE INFORMATION I HAVE FOUND ON LINE THIS SEEMS A VERY APPARENT CASE OF SOMETHING FORD SHOULD BE MAKING A RECALL ISSUE OF HIGH IMPORTANCE. I AM HOPING MY REPORTING IT HERE MAY HELP IN PREVENTING SOMETHING VERY DANGEROUS FROM HAPPENING IN THE FUTURE. *TR

NHTSA ID

10689856

Incident

Feb 22, 2015

Mileage

87,265 mi

WHEN THE VEHICLE IS WARMED UP AND DECELERATING BELOW 40MPH THEY GASOLINE ENGINE WILL SHUT OFF AS THE REGENERATIVE BRAKING CHARGES THE HYBRID HIGH VOLTAGE BATTERY. ON A RARE OCCASION DURING THIS BRAKING, THE GASOLINE ENGINE WILL TURN BACK ON GIVING A BRIEF SURGE WHICH REQUIRES PRESSING THE BRAKE HARDER. IT HAS DONE THIS SINCE I BOUGHT THE VEHICLE. *TR

NHTSA ID

10633774

Incident

Jan 15, 2010

Mileage

40,205 mi