2021 Ford Escape Hybrid Problems

While driving the vehicle it lost power and all the check lights came on. Had to have it towed to a dealership where they stated it needed a new motor and new high voltage battery. The car has only 116000 miles on it. There should be a total recall for this type of vehicle if I would have been at a higher speed I would have injured myself or others. This car is riddled with problems and has over 19 recalls as of date.

My engine failed while driving. Towed to Ford dealership, found out about recall 23S27. Symptoms were the EXACT same but ford is refusing to cover warranty repairs because they said it did not throw the proper code. However ford has offered to cover half of the engine replacement, leaving me with a $4000 bill. Do I have any options? Is there a system of checks and balances that assures that ford is doing everything correctly on their end?

Subject: Formal Complaint – Recall 23B56 & 23S27 + Rental Car Reimbursement Demand – McCombs Ford (7111 NW Loop 410) To Whom It May Concern, I am writing to file a formal complaint regarding the unacceptable service I experienced at McCombs Ford West, located at 7111 NW Loop 410, San Antonio, TX, concerning two open safety recalls on my 2021 Ford Escape, VIN: [XXX] and to formally request reimbursement for out-of-pocket expenses caused directly by the dealership's failure to prepare for my scheduled appointment. I scheduled a service appointment in February 2026 to address two outstanding safety recalls: •Recall 23B56 – Inspect front door check-arm reinforcement spot welds •Recall 23S27 – Underhood fire risk After waiting nearly five months, I was given an appointment on July 7, 2026. I dropped off my 2021 Ford Escape on July 7, 2026 as scheduled. At drop-off, I was informed the repairs would take multiple days, and I was told no loaner vehicle would be provided. Based on that, I rented a vehicle at my own expense to cover my transportation needs. The following day, I received a call from the service department informing me: 1.Recall 23B56 (Door Reinforcement): The dealership was unable to perform the repair because they had never ordered the required replacement door — despite having five months' notice from my original February 2026 booking. They stated they would "order it now." This is entirely unacceptable and reflects a clear failure of basic service planning. 2.Recall 23S27 (Underhood Fire): The dealership refused to perform Supporting documents attached : McCombs Ford service reference document & rental car invoice ($43.92) Reference details /dealership : MCCOMBS. 7111 N.W. LOOP 410 SAN ANTONIO, TEXAS 78238 (210) 509-1000 VIN: [XXX] 23S27 UNDER HOOD FIRE 26S14 FRONT WIPER MOTOR REPAIR 23E09 REPROGRAM POWERTRAIN CONTROL MODULE 23B56 INSPECT FRONT DOOR CHECK-ARM REINFORCEMENT SPOT WELDS 23N06 LONG BLOCK REPLACEMENT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

My driver front door latch assembly failed at 42,153 miles. I had it inspected and repaired at the dealership. I had to pay out of pockets due to no longer being covered by the 3/36 warranty. The symptoms were that the driver front door would not lock at all. It took a while to figure this out as I just thought maybe we left it unlocked. Also this vehicle has the perimeter key fob so it automatically unlocks when you have the fob with you and attempting to open. This had been going in fine moths u til we figured out the problem and took it to the dealership. They did offer a discount since I purchased it there but they said due to the design it messed an entire assembly and was over $1k before the discount. They also had parts in stock and I did confirm they had seen this failure before. While we did not have an actual incident happen with us, our vehicle was vulnerable and we had no idea, because the lock appeared to work and it still moved visually, it just wasn’t actually doing anything inside the door. This is my wife’s vehicle so my fear was either someone breaking into the vehicle or even worse, attempting to enter the vehicle while she was inside but she would be unable to lock the doors. As mentioned, the dealer did repair the vehicle and it is worked properly for now. Thought we did have to pay out of pocket.

While driving the vehicle it lost power and all the check lights came on. Had to have it towed to a dealership where they stated it needed a new motor and new high voltage battery. The car has only 116000 miles on it. There should be a total recall for this type of vehicle if I would have been at a higher speed I would have injured myself or others. This car is riddled with problems and has over 19 recalls as of date.

While vehicle is set on cruise control , set at 70 MPH , ( or set to any other speed) , anytime the speed limit changes to 80 MPH (or other change) Car accelerates and cruise control is set to 100 MPH . It also accelerates and resets to 90 -100 MPH at random . It is frightening and dangerous to have my car randomly accelerate. I have attempted to pass a vehicle, when my car randomly accelerates to 100 MPH . This is very dangerous and can happen at any random time . The lane assist is also dangerous when car can not see lines separating lanes . I have had my car jerk the wheel when I was detoured through construction. I am very concerned with my car accelerating. Not only does it leave me vulnerable to receiving a speeding ticket , it also increases the likelihood of hitting an object or having an accident.

The contact owns a 2021 Ford Escape. The contact stated that while driving approximately 45 MPH, the vehicle suddenly decelerated and failed to properly accelerate while depressing the accelerator pedal. The vehicle was parked on the side of the road and was later towed to the local dealer. The vehicle was serviced by the dealer. No further information was available. The contact stated that after retrieving the vehicle, the vehicle unintendedly accelerated and erroneously accelerated into an intersection. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 50,000.

I own a 2021 Ford Escape Hybrid SEL, VIN [XXX]. The vehicle currently has approximately 104,708 miles. The vehicle has developed a shuddering, vibration, and chatter condition during low-speed turns, parking maneuvers, backing up, and other tight turning situations. The condition is most noticeable while turning in parking lots and at low speeds. The vehicle was inspected by a Ford dealership while it was being repaired for a separate engine concern. During that inspection, the dealership diagnosed a rear differential/internal clutch concern and provided an estimate of approximately $2,709 for repair. After receiving the diagnosis, I learned that Ford issued TSB 25-2351 regarding low-speed turning chatter, vibration, and shudder concerns on certain Ford Escape vehicles. My vehicle is experiencing symptoms consistent with those described in the bulletin. In addition to the vibration and chatter during turns, I have also noticed abnormal noises from the vehicle during low-speed maneuvering and when shifting into park. The condition appears to be worsening with continued operation. I contacted Ford Motor Company and opened a customer assistance case regarding this concern. I later contacted Ford again to update my case and advise them that my vehicle is experiencing symptoms consistent with TSB 25-2351. Ford advised me that there are currently no recalls, special coverage programs, or customer satisfaction programs available for my VIN. I was advised to keep my repair records and receipts in the event a future recall or reimbursement program is issued. I am submitting this complaint so that this issue can be documented and evaluated. I am concerned about the continued deterioration of the rear differential or rear drive unit components and the potential impact on the safe operation and reliability of the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving the vehicle it lost power and all the check lights came on. Had to have it towed to a dealership where they stated it needed a new motor and new high voltage battery. The car has only 116000 miles on it. There should be a total recall for this type of vehicle if I would have been at a higher speed I would have injured myself or others. This car is riddled with problems and has over 19 recalls as of date.

The fuel neck tube requires replacement as per the mechanic's assessment. When refueling, the pump frequently stops every 5-10 seconds, as though the tank is full, necessitating multiple restarts. This defect makes it difficult to ascertain when the tank is genuinely full, leading to the risk of overfilling. On two occasions, despite the pump's intermittent stopping, it eventually functioned normally but resulted in overfilling, causing fuel to overflow from the fuel neck. This issue has been deemed out of warranty; however, Ford has offered to cover 50% of the repair costs as a goodwill gesture. Nonetheless, I believe that this defect should be fully covered and that a recall is warranted due to its significant safety implications. Additionally, a Technical Service Bulletin (TSB) exists for this issue, and there is a substantial online community documenting similar defects in the 2020-2023 Escape Hybrids. The estimated repair cost is $1,100, and the vehicle has less than 14,000 miles on the odometer. Enclosed are the diagnostic report (repairs pending), email correspondence from Ford, and the relevant TSB.

The contact owns a 2021 Ford Escape. The contact stated that while driving approximately 45 MPH, the vehicle suddenly decelerated and failed to properly accelerate while depressing the accelerator pedal. The vehicle was parked on the side of the road and was later towed to the local dealer. The vehicle was serviced by the dealer. No further information was available. The contact stated that after retrieving the vehicle, the vehicle unintendedly accelerated and erroneously accelerated into an intersection. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 50,000.

While vehicle is set on cruise control , set at 70 MPH , ( or set to any other speed) , anytime the speed limit changes to 80 MPH (or other change) Car accelerates and cruise control is set to 100 MPH . It also accelerates and resets to 90 -100 MPH at random . It is frightening and dangerous to have my car randomly accelerate. I have attempted to pass a vehicle, when my car randomly accelerates to 100 MPH . This is very dangerous and can happen at any random time . The lane assist is also dangerous when car can not see lines separating lanes . I have had my car jerk the wheel when I was detoured through construction. I am very concerned with my car accelerating. Not only does it leave me vulnerable to receiving a speeding ticket , it also increases the likelihood of hitting an object or having an accident.

Brakes became sluggish and parking brake would not disengage. Towed car to Autonation Ford. They diagnosed and found "internal failure of electric brake booster requiring replacement. It took them 30 days to locate a part and complete repairs. Car had 41,634 miles and the cost was $3,087 not including my $2,406 rental charges before they offered a loaner. When I contacted Ford, they said it was out of warranty...I knew that.

Received a notice that a recall was necessary to correct fuel vapor issues which might result in a fire. Simultaneously notified the dealer that the brake booster was defective. They agreed and both assured me the part had been delivered and subsequently informed me that the part for the brakes was defective. I was told that the fuel vapor issue had been addressed and resolved however according to your records it has not. I have been waiting for a call that the parts were available for the warranty repairs since December 19.

Seatbelt locks in position on the passenger side. Must stop car let seatbelt retract all the way and reattach seatbelt. Dealer wanted $225 to diagnose problem if they could not find and/or duplicate issue.

The contact owns a 2021 Ford Escape. The contact stated while driving 65 MPH and at various speeds, the cruise control and several other features failed to activate. The contact stated that the air bag indicator and a message that the rear seat monitor default warning light were illuminated. The vehicle was then taken to a dealer where it was diagnosed and determined to replace the driver's side seat belt buckle. The vehicle was not repaired because the dealer was waiting for the part to be received. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,500.

The contact owns a 2021 Ford Escape. The contact stated while driving 35 MPH, the check engine warning light illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed that the high-voltage battery had failed and needed to be replaced. The contact stated that the dealer reset the check engine warning light. The contact stated that the following day after the reset, the check engine warning light illuminated a second time. The contact related the failure to NHTSA Campaign Number: 21V869000 (ELECTRICAL SYSTEM, HYBRID PROPULSION SYSTEM); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 129,000.

The contact owns a 2021 Ford Escape. The contact stated that the check engine warning light was illuminated, and the message that the vehicle had lost power was displayed. The contact disconnected the Hybrid setting and indicated the loss of power with the Hybrid battery. The failure was self-corrected; however, the failure still occurred intermittently. The contact became aware of NHTSA Campaign Numbers: 21V869000 (Electrical System, Hybrid Propulsion System) and 22V149000 (Electrical System, Hybrid Propulsion System). The vehicle was taken to the dealer where it was confirmed that the VIN was not included in the recalls. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer confirmed the VIN was not included in the recalls. The failure mileage was 50,000.

The contact owns 2021 Ford Escape. The contact stated that the rear passenger’s side window failed to operate as designed and was stuck in the open position and failed to close. The vehicle was taken to the local dealer who repaired the vehicle. No further information was available. The contact stated that the failure recently reoccurred with the rear driver’s side window. Additionally, the instrument cluster malfunctioned, and the contact was unable to view the speedometer and fuel gauge. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was unknown.

The contact owns a 2021 Ford Escape. The contact stated that after driving for an hour and parking the vehicle, after picking up her coat from the passenger’s side seat she saw a burn mark on the seat with smoke coming from the seat. Additionally, the contact had a burning sensation in her eyes due to the strong chemical burning odor coming from the passenger’s seat. The contact did not seek medical assistance. There was no warning light illuminated. The dealer was notified of the failure and an appointment was scheduled for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline. The failure mileage was approximately 37,600.

The contact owns a 2021 Ford Escape. The contact stated that there was a metal piece inside the front driver's seat that was poking him while driving. The contact stated that the failure was distracting while driving as he would manually attempt to move the part while driving. The vehicle was taken to the dealer on three separate occasions and the dealer installed a pad that stopped the failure from reoccurring for two months. The dealer informed the contact that upon evaluating the seat comfort level no issues were found. The vehicle was not repaired. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 2,000.

On Dec. 26, 2021, I was in a collision with another vehicle and the driver side airbag failed to activate. I suffered a fractured sternum as a result. The car was a total loss, sent to a yard and sold. I don’t know if it is available for inspection. The police report states the air bags were deployed, but only the bottom one was and not the top one. I have a photo of the steering wheel which says “airbag” and shows it did not activate. My insurance company is Allstate and deemed the car a total loss.