2025 Ford Escape Hybrid Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Ford Escape Hybrid, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system1100.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
On XXX at approximately 2:45pm MDT I was traveling on XXX in [XXX]. I had approximately a quarter tank of gas. I received a low fuel alert, stating 50 miles to empty. My plan was to stop at the next exit approximately 10 miles away. However, over approximately the next minute, the distance to empty rapidly decreased to 0, at which point the vehicle stopped moving while in the right lane of traffic. I could not re-start the car. It would not move out of park into gear. After several minutes sitting stalled in the lane of travel, I was able to get the vehicle started for a few seconds to move to the shoulder. The gas gauge still showed 1/4 tank but at the same time, there was an alert that said 0 miles to empty. In the Ford app, it showed a fuel level of 21% and 0 miles to empty. I had to contact a company who came and poured two gallons of gas into the vehicle for $180.00. At this point I was able to safely make it to the gas station to fill up. I noted that the vehicle took 10 gallons of gas. The tank is 14.3 gallons. That confirms that I did still have 2 gallons in the tank (which would be about 50 miles) plus the two gallons from the tow company. I was not out of gas. There was an error in the Ford app that said “The Hybrid Powertrain Control Module has disabled the gasoline engine function due to an additional concern being detected”. Images of the driver gauges and Ford app readings, along with the high voltage warning are attached. After filling up, the Ford app was still incorrect - it said it was 31% full with 117 miles to empty even though I had just filled it up - and the physical gauge on the dash showed full with 379 miles to empty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .