1991 Ford Escort Owner Complaints

AFTER FILLING UP WITH GAS AND STILL BESIDE THE GAS PUMPS I ATTEMPTED TO START THE VEHICLE IN PARK. THE CAR KEPT CRANKING BUT NOT STARTING. TURNED THE IGNITION SWITCH OFF AND CAR KEPT CRANKING. PULLED THE KEY OUT AND CAR KEPT CRANKING. PUT THE KEY BACK IN AND GOT THE VEHICLE IN DRIVE WHILE CRANKING AND IT STOPPED. TURNED KEY AND VEHICLE STARTED (IN DRIVE MODE). VEHICLE WOULD NOT STOP CRANKING IN PARK OR NEUTRAL MODES BUT WILL IN DRIVE MODE. WITH NO KEY VEHICLE TRIES TO START IN BOTH PARK AND NEUTRAL. MAJOR SAFETY ISSUE. I WAS SCARED WHEN IT KEPT CRANKING BESIDE THE GAS STATION TANKS THINKING I WAS GOING TO END UP BLOWING UP THE STATION. *TR

NHTSA ID

10525875

Incident

Jul 14, 2013

Mileage

124,750 mi

THE ACCELERATOR STUCK TO THE FLOOR CAUSING THE VEHICLE TO BE IN FULL THROTTLE. THIS OCCURRED WHILE STOPPED AT A TRAFFIC LIGHT. FORTUNATELY IT WAS A MANUAL TRANSMISSION AND OUT OF GEAR WHEN THE INCIDENT HAPPENED. I HAD STOMPED ON THE GAS PEDAL BY MISTAKE. I SEARCHED THE FLOOR AND ENGINE COMPARTMENT FOR ANYTHING THAT MAY HAVE PREVENTED THE ACCELERATOR FROM DISENGAGING AND FOUND NO APPARENT REASON FOR THE PHENOMENON. *TR

NHTSA ID

10319837

Incident

Mar 15, 1994

Mileage

34,000 mi

TL* THE CONTACT OWNS A 1991 FORD ESCORT. FATIGUE CRACKS HAVE DEVELOPED IN THE SOLDER JOINT BETWEEN THE FUEL RETURN TUBE AND THE FUEL PUMP SENDING UNIT LOCATED AT THE TOP OF THE FUEL TANK. THERE MUST HAVE BEEN AN INTERNAL FIRE CAUSED BY THE FAILURE, BECAUSE THE WIRING HARNESS HAD MELTED. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL # 92V117000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER AND THE DEALER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 151000.

NHTSA ID

10290381

Incident

Oct 11, 2008

Mileage

151,000 mi

1. MY 1991 FORD ESCORT LX STATION WAGON DEVELOPED A FUEL LEAK AROUND THE FUEL TANK. 2. IT OCCURS EVERY TIME I ADD FUEL TO THE TANK. 3. I REPORTED THE PROBLEM TO FORD, INCLUDING THE EXISTENCE OF A RECALL NOTICE (NHTSA ACTION NUMBER EA92012; NHTSA CAMPAIGN ID NUMBER: 92V117000)). FORD HAS IGNORED THE RECALL LETTER, CLAIMING THERE IS NO SUCH RECALL LETTER, AND ... IN GENERAL GIVING ME THE RUNAROUND. FRANKLY, I'M MAD AS '!@#$%. THIS PROBLEM IS A FIRE HAZARD, AND FORD IS REFUSING TO ADDRESS IT!!!!! WHAT CAN I DO?? THANKS! KES *TR

NHTSA ID

10237636

Incident

Jul 3, 2008

Mileage

83,000 mi

TL*THE CONTACT OWNS A 1991 FORD ESCORT LX. THE CONTACT POURED BRAKE FLUID INTO THE POWER STEERING RESERVOIR. SHE TOOK HER VEHICLE TO A MECHANIC TO HAVE THE VEHICLE BLED. THE MECHANIC REPLACED THE POWER STEERING PUMP WITHOUT AUTHORIZATION, AND NOW THE VEHICLE IS SPEWING FORTH POWER STEERING FLUID. THE ALTERNATOR WAS LOPSIDED AND ITS SCREWS WERE MISSING. THE MOTOR MOUNT WAS REMOVED AND THE CONTACT DOES NOT KNOW THE REASON. WHEN SHE ARRIVED HOME AND TURNED OFF THE VEHICLE, IT FAILED TO RESTART AFTER MANY ATTEMPTS. THE MECHANIC STATED THAT HE WOULD SEND A TOW, BUT ONE NEVER ARRIVED. THE FAILURE MILEAGE WAS 101,000.

NHTSA ID

10226363

Incident

Apr 26, 2008

Mileage

101,000 mi

MOTORIZED SEAT BELTS INOPERATIVE. LAP BELT DOES NOT RESTRAIN. *TR

NHTSA ID

10226055

Incident

Apr 10, 2008

Mileage

107,000 mi

LOST CONTROL ON WET ROAD HIT TREE HEAD-ON AND SEAT BELT CAME OUT OF TRACK ALLOWED DRIVER TO BE DECAPITATED. *NM

NHTSA ID

10156478

Incident

Oct 30, 1992

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 92V117000 CONCERNING FUEL PUMP SENDING ASSEMBLY. THIS CONSUMER IS EXPERIENCING THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE. *AK UPDATD 01/25/06. *JB

NHTSA ID

10143357

Incident

Dec 23, 2003

Mileage

133,000 mi

DT: 1991, FORD, ESCORT HATCHBACK. CONSUMER'S WIFE CAME HOME YESTERDAY, AND SAID SHE SMELLED SMOKE. CONSUMER CHECKED VEHICLE AND FOUND OUT THAT THIRD BRAKE LIGHT LOCATED AT TOP OF REAR WINDOW SMOKED WHEN BRAKE WAS PRESSED. CONSUMER TOOK LIGHT APART, AND FOUND SAME PART AT A JUNK YARD. CONSUMER REPLACED HEAT SHIELD AND HALOGEN BULB WITH ONE FROM JUNK YARD. CONSUMER CALLED FORD AND GAVE FORD INFORMATION ABOUT THE INCIDENT. FORD TOLD CONSUMER THERE WERE NO RECALLS, BUT THEY WERE GOING TO TURN IT IN TO ENGINEERING. CONSUMER BELIEVED THAT A LOWER WATT, COOLER BULB WOULD KEEP LIGHT FROM CAUSING FIRE.*AK BULB HOUSING HAD HOLE MELTED THROUGH IT. REPLACED HOUSING WITH GOOD HEAT SHIELD (ORIGINAL HEAT SHIELD HAD BURNED OFF CAUSING THE PROBLEM).*SB

NHTSA ID

10125284

Incident

Jun 13, 2005

Mileage

90,000 mi

WHEN YOU TURN IGNITION OFF RADIO CONTINUES TO PLAY FOR ABOUT 10 MINUTES OR UNTIL YOU MANUALLY SHUT IT OFF, REPLACED IGNITION AND STILL HAS SAME PROBLEM.*AK

NHTSA ID

10112688

Incident

Mar 1, 2005

FATALITY INVOLVING 1991 FORD ESCORT. *MR THE CONSUMERS AUNT WAS DRIVING AND WAS SEVERELY INJURED AND THE CONSUMERS MOTHER WAS KILLED IN THE ACCIDENT. THE CONSUMER REQUESTED TO KNOW IF THE VEHICLE WAS CHECKED OR CORRECTED FOR THE PROBLEM. (INSPECT THE BOLT LENGTH BEFORE DRIVEN OR DEMONSTRATED OR DELIVERED THE VEHICLE UNTIL THEY HAVE BEEN INSPECTED) THIS WAS THE CONSUMER'S AUNT'S FIRST ACCIDENT UNTIL THE PROBLEM WITH THE ACCELERATOR. THE THROTTLE LINKAGE WAS POSSIBLY DEFECTIVE. RECALL# 90V076000 *SC THERE WAS ALSO A LEAKAGE PRESENT AT THE RIGHT FRONT BRAKE CALIPER UPON INSPECTION. *JB

NHTSA ID

10089429

Incident

Dec 14, 2002

MY DAUGHTER WAS DRIVING A 1991 FORD ESCORT IN DOWNTOWN PITTSBURGH WHEN SMOKE BEGAN POURING OUT OF THE DASHBOARD BEHIND THE SPEEDOMETER SECTION. SHE PULLED OVER AND EXITED THE CAR AFTER TURNING OFF THE IGNITION SWITCH. THE SMOKE CEASED AND A POLICE OFFICER STOPPED BY TO ASSIST. HE REMAINED TO DIRECT TRAFFIC UNTIL THE TOW TRUCK CAME TO RETURN THE VEHICLE TO MY HOUSE. THE VEHICLE HAS LIABILITY INSURANCE ONLY. I WAS NOT ABLE TO INVESTIGATE THE CAUSE OF THE SMOKE FOR A FEW DAYS. I NEEDED MORE INFORMATION IN HOW TO GET BEHIND THE DASHBOARD. UPON OPENING THE DASHBOARD, I FOUND THE WIRING BUNDLE LEADING TO THE DASHBOARD METERING WAS MELTED INTO A BUNDLE AND THE WIRES WERE NOT DISTINGUISHABLE IN COLOR ANY MORE. THE MELTED SECTION OF WIRING WAS FURTHER FOUND IN LEADING INTO THE LARGER BUNDLE GOING DEEPER INTO THE DASHBOARD AND INTO THE ENGINE WELL. I CONTACTED FORD CONCERNING THIS AND WAS REFERED BY THEM TO MY INSURANCE AGENT. THE CONSUMER SAFETY COMMISSION SENT ME IN YOUR DIRECTION. IS THERE ANYTHING I CAN DO BESIDES TRASH THE CAR?*AK

NHTSA ID

10082982

Incident

May 17, 2004

Mileage

136,000 mi

IGNITION SWITCH FAILURE TO TURN OFF ENGINE. SMOKE COMING INTO THE INSIDE OF VEHICLE FROM THE ENGINE. *AK

NHTSA ID

10066376

Incident

Apr 17, 2004

AUTOMATIC PASSIVE RESTRAINT SYSTEM FAILED TO OPERATE WHEN OPENING THE DOOR. MECHANISM JAMMED, AND HAD TO BE MANUALLY DISCONNECTED TO GET IN AND OUT OF THE VEHICLE. *AK *NM

NHTSA ID

10057240

Incident

Dec 1, 2003

Mileage

135,000 mi

THE CONSUMER WAS MAKING A LEFT HAND TURN WHEN THE IGNITION LOCK CYLINDER FELL ONTO THE FLOOR. THE STEERING WHEEL LOCKED UP AND THE CONSUMER WAS FORCED TO COME TO A STOP. THE DEALER HAD BEEN CONTACTED. PLEASE DESCRIBE FURTHER. *JB *MR

NHTSA ID

10051613

DRIVER'S AUTOMATIC SHOULDER BELT WOULD NOT RETRACT BACK TO THE LOCKING POSITION. CONSUMER IS UNABLE TO WEAR THE SEAT BELT PROPERLY. *AK

NHTSA ID

10056065

Incident

Dec 28, 2003

Mileage

149,000 mi

THE FRONT SEAT BELTS WERE INOPERATIVE. *JB THE VEHICLE CAME EQUIPPED WITH THE AUTOMATIC SEAT BELTS, THE SEAT BELTS FAILED IN THE OPEN POSITION.*SCC *JB

NHTSA ID

10032458

Incident

Jul 17, 2003

WHILE TRAVELING ABOUT 50MPH AND WITHOUT PRIOR WARNING CONSUMER'S VEHICLE HIT ANOTHER VEHICLE FROM BEHIND, AND DRIVER SIDE STRAP BROKE FROM THE FRAME OF THE SEAT BELT. *AK

NHTSA ID

10026763

Incident

Jun 12, 2003

CONSUMER STATES THAT THE WIRING ASSEMBLY TO THE FUEL PUMP HAS BURNED UP 3X IN THE LAST MONTH. DEALER DIAGNOSED PROBLEM AS INCORRECT SPECIFIED 30AMP FUSE FOR FUEL PUMP.*AK

NHTSA ID

10024878

Mileage

132,000 mi

VEHICLE WAS HAVING THE SAME PROBLEM AS MENTIONED IN RECALL#92V17000 CONCERNING FUEL TANK. DEALER WILL NOT REPAIR VEHICLE BECAUSE IT IS NOT COVERED UNDER RECALL DUE TO VIN. *AK

NHTSA ID

10022205

Incident

May 31, 2003

THE STEERING WHEEL WAS VERY HARD TO TURN. THERE WAS A RECALL 94E019000 WHICH DESCRIBED THE EXACT PROBLEM, THE CONSUMER'S VEHICLE EXPERIENCED. *JB

NHTSA ID

10015009

Mileage

120,000 mi

THE IGNITION SWITCH WAS STUCK IN ONE POSITION. POSSIBLY RELATED TO RECALL 93V057000.*JB *TS

NHTSA ID

10007387

Incident

Feb 12, 2003

CONSUMER STATES THAT THE SEAT BELT WILL NOT RETRACT BACK INTO POSITION AND IT COULD CAUSE THE SEAT BELT TO BE DEFECTIVE IN THE EVENT OF AND ACCIDENT. DEALER NOTIFIED. PH

NHTSA ID

8023431

Incident

Nov 18, 2002

CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING THE VEHICLE WILL STICK IN PARK AND WILL NOT SHIFT GEARS CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS

NHTSA ID

8023400

Incident

Nov 10, 2002

CONSUMER NOTICED FUEL ON THE GROUND, THE VEHICLE WAS TAKEN TO A MECHANIC, AND IT WAS DISCOVERED THAT GAS HAD LEAKED OUT OF THE FUEL LINE WHICH CONNECTED TO THE TANK. PLEASE PROVIDE ANY FURTHER INFORMATION. THE FUEL TANK AND PUMP WAS REPLACED.*JB

NHTSA ID

8022735

Incident

Oct 2, 2002

Mileage

210,100 mi